Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
Mileage unknown · Jul 27, 2004
Steering
LTR REQUEST NHTSA INVESTIGATE INCIDENTS OF FAILURE OF THE ALL STEER SYSTEM (ELECTRONIC ALL WHEEL STEERING) THAT OCCURRED IN TRUCKS IN FIVE OF THEIR FIRE DEPARTMENTS.*MR WHEN THE ALL STEER SYSTEM FAILED THE REAR AXLE OF THE APPARATUS TURNED AT AN ANGLE WHILE THE FIRE TRUCK WAS IN OPERATION, SWINGING THE END OF THE FIRE TRUCK OUT…
Read full complaint
LTR REQUEST NHTSA INVESTIGATE INCIDENTS OF FAILURE OF THE ALL STEER SYSTEM (ELECTRONIC ALL WHEEL STEERING) THAT OCCURRED IN TRUCKS IN FIVE OF THEIR FIRE DEPARTMENTS.*MR WHEN THE ALL STEER SYSTEM FAILED THE REAR AXLE OF THE APPARATUS TURNED AT AN ANGLE WHILE THE FIRE TRUCK WAS IN OPERATION, SWINGING THE END OF THE FIRE TRUCK OUT OF CONTROL. *NM
ON CERTAIN FIRE TRUCKS EQUIPPED WITH EMERGENCY (FIRE-RAY) STROBE WARNING LIGHTS, THE STROBE LIGHT HOUSING WAS MADE FROM AN ELECTRICALLY CONDUCTIVE MATERIAL AND A PERSON COULD RECEIVE A SEVERE ELECTRICAL SHOCK IF THEY CAME IN CONTACT WITH A VEHICLE OPERATING THE FIRE-RAY STROBE LIGHTS.
Consequence & remedy
Consequence: THIS CONDITION COULD BE LIFE-THREATENING SHOULD A SMALL CHILD OR A PERSON WITH A HEART CONDITION EXPERIENCE A SEVERE ELECTRICAL SHOCK. ALSO, A POSSIBLE FIRE HAZARD EXISTS.
Remedy: FEDERAL SIGNAL WILL NOTIFY ITS CUSTOMERS TO RETURN THE DEFECTIVE LIGHTS FOR A REPLACEMENT FREE OF CHARGE. OWNER NOTIFICATION WAS EXPECTED TO BEGIN DURING NOVEMBER 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FEDERAL SIGNAL'S SERVICE DEPARTMENT AT 800-433-9132 OR PIERCE AT 920-832-3000.
VEHICLE DESCRIPTION: FIRE TRUCKS EQUIPPED WITH OSHKOSH ALL-STEER ALL-WHEEL STEERING SYSTEM. THE REAR WHEELS OF A FIRE ENGINE CAN TURN UNINTENTIONALLY IF THE ALL-WHEEL STEERING SYSTEM KEY IS ON AND MOISTURE PENETRATES TO THE WIRE THAT CONNECTS THE STEERING SENSOR TO THE ELECTRONIC CONTROL UNIT (ECU). IT WAS DISCOVERED THAT THE INSULATION COVERING THE WIRES BETWEEN THE SENSOR AND THE ECU HAD BEEN NICKED DURING TIME OF ASSEMBLY. OVER TIME, THE NICK IN THE INSULATION ALLOWED MOISTURE TO PENETRATE TO THE ACTUAL WIRE.
Consequence & remedy
Consequence: UNDER THESE CONDITIONS, THE DRIVER CAN EXPERIENCE UNINTENDED TURNING OF A SINGLE OR A TANDUM REAR AXLE, POSSIBLY LEADING TO A VEHICLE CRASH OR INJURY OR DEATH TO A PEDESTRIAN OR FIRE FIGHTER.
Remedy: DEALERS WILL INSPECT FOR NICKED WIRES AND REPLACE THE WIRE HARNESS. THIS RECALL CAMPAIGN IS 100% COMPLETE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 Pierce Fire Truck Problems, Complaints & Recalls | Skip That Year
Illustration