IllustrationTHE LEFT FRONT WHEEL/RIM CRACKED FROM AIR VALVE OPENING TO A LUG OPENING. THE CRACK IS COMPLETELY THROUGH ON BOTH SIDES. *NM
2000 Pierce Dash
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Dash years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Wheels complaints
2 reportsCRACK IN RIGHT FRONT WHEEL FROM AIR VALVE OPENING TO A LUG OPENING. THE CRACK IS COMPLETELY THROUGH FROM THE OUTSIDE THROUGH THE INSIDE. SAME PROBLEM AROSE ONE YEAR AGO ON THE LEFT WHEEL. *NM
Official recalls
817V348000 · Power Train:axle Assembly:axle Shaft
May 30, 2017
Pierce Manufacturing (Pierce) is recalling certain 1999-2013 Arrow XT, Dash, Enforcer, Quantum and Velocity fire trucks equipped with the electric All-steer rear steering option. The affected vehicles have rear steer axle shafts that were not properly heat treated.
Consequence & remedy
Consequence: Axle shafts that are not properly heat treated may break and potentially disable the vehicle, increasing the risk of a crash.
Remedy: Pierce will notify owners, and dealers will replace the rear steer axle shafts, free of charge. An interim notice was mailed on July 24, 2017. The recall began June 3, 2020. Owners may contact Pierce customer service at 1-888-974-3723.
13V525000 · Equipment
Oct 22, 2013
Pierce Manufacturing Inc. (Pierce) is recalling certain model year 2000-2009 Enforcer and model year 2000-2010 Dash, Lance, and Arrow XT vehicles. While raising or lowering the cab as part of vehicle maintenance, the mounts on which the cab tilt cylinders pivot may fatigue and fail allowing the cab to fall until the safety catch activates.
Consequence & remedy
Consequence: If a person is in the path of the moving cab when a mount fails, the person may be hit by the falling cab, increasing the risk of injury.
Remedy: Pierce will notify owners, and dealers will affix new safety signs advising the operator to stay clear of the cab while it is being tilted, free of charge. The recall began on January 6, 2014. Owners may contact Pierce at 1-920-832-3000. Pierce's recall number is 74B240.
11V384000 · Fuel System, Other
Jul 26, 2011
PIERCE HAS DECIDED THAT CERTAIN MODEL YEAR 1995-2008 ARROW XT, DASH, CUSTOM CONTENDER, LANCE, ENFORCER, PIERCE ARROW, QUANTUM, SABER AND COMMERCIAL FIRE TRUCKS MANUFACTURED FROM JANUARY 2, 1995, THROUGH JANUARY 21, 2008, CONTAIN A SAFETY DEFECT. THESE VEHICLES ARE EQUIPPED WITH FUEL TANK STRAPS THAT MAY CORRODE DUE TO WINTER ROAD SALT OR LIQUID DE-ICING CHEMICALS. IF THE FUEL TANK STRAPS CORRODE SUFFICIENTLY, THE FUEL TANK SUPPORTING STRAPS MAY FRACTURE AND THE FUEL TANK MAY FALL FROM THE VEHICLE.
Consequence & remedy
Consequence: THE VEHICLES MAY LOSE POWER AND STALL. IN ADDITION, THE FUEL TANK MAY RUPTURE AND SPILL DIESEL FUEL ON THE ROADWAY. EITHER OF THESE OUTCOMES MAY CAUSE A FIRE TRUCK OR SURROUNDING VEHICLES TO SLIP OR SLIDE ON THE ROADWAY SURFACE, INCREASING THE RISK OF A CRASH.
Remedy: FOR FIRE TRUCKS THAT ARE LESS THAN 10 YEARS OLD, DEALERS WILL INSPECT THE FUEL TANK STRAPS AND REPLACE THEM IF NECESSARY WITH STAINLESS STEEL STRAPS FREE OF CHARGE. FOR VEHICLES THAT ARE OLDER THAN 10 YEARS, PIERCE IS NOT OFFERING A FREE REMEDY, BUT WILL OFFER FOR PURCHASE REPLACEMENT FUEL TANKS STRAPS AND PROVIDE INSTRUCTIONS FOR INSTALLATION. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
11V255000 · Vehicle Speed Control:accelerator Pedal
Apr 26, 2011
PIERCE IS RECALLING CERTAIN MODEL YEAR 1999-2008 ARROW XT, DASH, LANCE, AND ENFORCER FIRE APPARATUS MANUFACTURED FROM JUNE 22, 1999, THROUGH MAY 12, 2008, AND EQUIPPED WITH AN ELECTRONIC ACCELERATOR PEDAL. AFTER REPEATED USE WITH EXCESSIVE FORCE, THE ACCELERATOR PEDAL ARM MAY BEND AND CAUSE THE PEDAL TO MOVE CLOSER TO THE FLOOR. IF THE PEDAL ARM BENDS FAR ENOUGH, THE PEDAL MAY CONTACT THE CAB FLOOR WITHOUT WARNING AND STICK IN THE FULL THROTTLE POSITION.
Consequence & remedy
Consequence: IF THE ACCELERATOR PEDAL BECOMES STUCK, THE OPERATOR MAY LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REMOVE THE EXISTING ACCELERATOR ARM AND INSTALL A REDESIGNED PEDAL ARM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.
10V423000 · Steering
Sep 21, 2010
PIERCE IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2008 ARROW XT, LANCE, VELOCITY, ENFORCER, IMPEL, AND DASH CUSTOM FIRE APPARATUS VEHICLES MANUFACTURED FROM MAY 30, 1998 THROUGH NOVEMBER 25, 2008. THE STEERING GEAR BRACKET MAY FRACTURE AND BREAK. IF THIS OCCURS THE STEERING GEAR MAY DETACH FROM THE VEHICLE.
Consequence & remedy
Consequence: DETACHMENT OF THE STEERING GEAR WILL RESULT IN A LOSS OF STEERING CONTROL THAT COULD CAUSE A CRASH.
Remedy: PIERCE WILL NOTIFY OWNERS AND DEALERS WILL INSTALL A NEW STEERING GEAR MOUNTING BRACKET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 12, 2010. OWNERS ARE BEING INSTRUCTED TO INSPECT THE STEERING GEAR BRACKET PRIOR TO EACH TRIP. THE REMEDY TO REPAIR THIS DEFECT IS EXPECTED TO BEGIN NO EARLIER THE JANUARY 31, 2011. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.
05V351000 · Seats
Aug 10, 2005
CERTAIN FIRE TRUCKS WITH COMMAND CABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207,"SEATING SYSTEMS." THE RESCUE BODY OFFERINGS DO NOT MEET THE PULL TEST REQUIREMENTS. THE PEDESTAL SEAT WAS MOUNTED BY DRILLING AND TAPPING THE CAB OR BODY FLOOR.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE PEDESTAL SEAT FASTENERS COULD FAIL TO RESTRAIN THE SEAT, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL INSPECT THE SEAT PEDESTALS. IF THE SEAT WAS MOUNTED WITH TAPPED FASTENERS, THE FASTENERS WILL BE REMOVED AND A HOLE WILL BE DRILLED TO REPLACE THE MOUNTING FASTENERS WITH 7/16" BOLTS AND NUTS. THE RECALL BEGAN ON AUGUST 19, 2005. OWNERS MAY CONTACT PIERCE AT 920-832-3249.
05V072000 · Seats
Mar 4, 2005
CERTAIN FIRE TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, 'SEATING SYSTEMS.' THE SEAT TETHER RESTRAINS THE SEAT DURING PULL TESTING AS THE SUSPENSION COMPONENTS ARE NOT DESIGNED TO RESTRAIN THE SEAT ON THEIR OWN. THE SUSPENSION SEAT TETHERS ARE TOO LONG.
Consequence & remedy
Consequence: THE OCCUPANT WILL EXPERIENCE INSUFFICIENT SUSPENSION SEAT RESTRAINT WHICH COULD LEAD TO PERSONAL INJURY OR DEATH IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE SUSPENSION SEAT TETHERS WITH SHORTER TETHERS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.
02V037007 · Steering:linkages:tie Rod Assembly
Oct 8, 2002
ON SOME HEAVY DUTY CLASS 8 VEHICLES EQUIPPED WITH ARVINMERITOR AXLE ASSEMBLIES WHICH MAY HAVE BEEN MANUFACTURED WITH TRW MODEL 20EDL BALL SOCKETS, THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW SPECIFICATION CASE DEPTH AND/OR HARDNESS WHICH CAN LEAD TO PREMATURE WEAR OUT OF THE SOCKET IN SOME APPLICATIONS.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE STEERING CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE BALL SOCKET ASSEMBLIES. OWNER NOTIFICATION BEGAN OCTOBER 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PIERCE AT 920-832-3000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EQ11003 · Williams Controls Accelerator Pedals
Opened May 12, 2011 · Closed Jul 19, 2011
Status: closed (inferred from source dates) · Vehicle Speed Control:accelerator Pedal
On April 26, 2011, Pierce Manufacturing, Inc. (Pierce) notified the NHTSA that it had decided certain Pierce fire trucks, manufactured between June 22, 1999, and May 12, 2008, contain a safety related defect. Pierce stated that certain model year 1999 through 2008 Arrow XT, Dash, Lance, and Enforcer vehicles contain a Williams Controls, Inc. (Williams Controls) suspended electronic accelerator pedal that may become bent after repeated use with excessive force. If the pedal arm bends far enough, the pedal may contact the cab floor without warning and stick in the full throttle position. If the accelerator pedal becomes stuck, the operator may lose control of the vehicle increasing the risk of a crash. This issue was assigned recall number 11V-255.On May 12, 2011, RMD mailed an information request (IR) letter to Williams Controls requesting a list of customers who purchased the same or similar defective accelerator pedals.Williams Controls responded to RMD's IR letter on June 9, 2011 with a list those companies who purchased the same accelerator pedal.The list was submitted to NHTSA's Office of the Chief Counsel under a request for confidentiality.Williams Controls' response letter outlined several key points.First, it was noted that these pedals, item number 131507, are generic parts that are purchased by engineering staffs in accordance with their own specifications.According to Williams Controls, Pierce modified their purchased pedals post-purchase and this modification reduced the strength of the accelerator pedal assembly.Also, Williams Controls stated that it has, never had a warranty claim or other notice, other than by Pierce on their modified pedal, due to lever arm permanent deformation for item number 131507.While Williams Controls submitted a list of companies that purchased item number 131507, it noted that it did not sell the same or similar defective pedal assemblies to any company as the subject pedals were modified by Pierce.This Equipment Query is satisfied as, because of modifications not conducted by the pedal manufacturer, the same or similar pedals were not sold to other vehicle manufacturers and no other vehicles should be affected.However, RMD will continue to monitor recall activity to see if any similar issues are found in other manufacturers' vehicles.This EQ is closed.