NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
3 reports468,742 miles · Feb 19, 2025
EngineFuel System, Diesel
The contact owns a 2012 Peterbilt 587. The contact stated while driving 65 MPH, the vehicle stalled. The contact was unaware of a warning light being illuminated. The contact pulled over to the side of the road where the vehicle failed to restart. The vehicle was towed to West Truck Services Center, where it was diagnosed and de…
Read full complaint
The contact owns a 2012 Peterbilt 587. The contact stated while driving 65 MPH, the vehicle stalled. The contact was unaware of a warning light being illuminated. The contact pulled over to the side of the road where the vehicle failed to restart. The vehicle was towed to West Truck Services Center, where it was diagnosed and determined that the fuel pump had failed. The vehicle was then towed to the dealer, where it was diagnosed that the fuel pump plungers had fractured and intruded the engine. Additionally, the dealer informed the contact that there were metal shavings inside the oil filter. The dealer determined that the fuel pump and engine rod bearings needed to be replaced. The vehicle was being repaired. The contact related the failure to TSB Number: 140019. The manufacturer was notified of the failure and a claim was filed; however, the claim was denied. The failure mileage was 468,742.
NHTSA ODI #11643608
Mileage unknown · Apr 22, 2013
Electrical SystemFire
2012 PETERBILT TRACTOR. CONSUMER WRITES IN REGARDS TO POTENTIAL FIRE DEFECT. *SMD THE CONSUMER STATED HE RECENTLY INVESTIGATED THE CAUSE OF A FIRE IN THE TRACTOR AND DETERMINED THE CAUSE TO BE RELATED TO A POTENTIAL DEFECT IN THE MANNER IN WHICH THE BATTERY CABLES WERE SUPPORTED. THE BATTERY CABLES PASSED FROM THE BATTERY …
Read full complaint
2012 PETERBILT TRACTOR. CONSUMER WRITES IN REGARDS TO POTENTIAL FIRE DEFECT. *SMD THE CONSUMER STATED HE RECENTLY INVESTIGATED THE CAUSE OF A FIRE IN THE TRACTOR AND DETERMINED THE CAUSE TO BE RELATED TO A POTENTIAL DEFECT IN THE MANNER IN WHICH THE BATTERY CABLES WERE SUPPORTED. THE BATTERY CABLES PASSED FROM THE BATTERY BOX ON THE DRIVER SIDE OF THE TRACTOR, AT A POSITION BEHIND THE CAB, TO THE ENGINE COMPARTMENT. AT THE LOCATION WHERE THE BATTERY CABLES PASSED THE ELECTRONIC CLUTCH ACTUATOR, THEY WERE HELD IN PLACE BY A PLASTIC TIE. DUE TO DRIVE TRAIN VIBRATION AND MOVEMENT, THE PLASTIC TIE USED TO SECURE THE BATTERY CABLES TO THE CLUTCH ACTUATOR SHIELD WERE PRONE TO FAILURE. THE PLASTIC TIE BROKE AT SOME TIME DURING ITS SERVICE LIFE AND THE WEIGHT OF THE BATTERY CABLES CAUSED THEM TO MIGRATE TOWARD THE BOTTOM OF THE CLUTCH ACTUATOR SHIELD. MOVEMENT BETWEEN THE UNSECURED CABLES AND THE SHIELD, WHICH OCCURRED OVER TIME, ABRADED THE INSULATION OF ONE OF THE POSITIVE CABLES. ONCE THE ELECTRICAL INSULATION FAILED, THE CABLE ARCED AGAINST THE SHIELD, ENERGIZING THE ENGINE AND TRANSMISSION. UPDATED 7/1/13 ...UPDATED 10-24-13 *BF
NHTSA ODI #10509048
Mileage unknown · Apr 11, 2013
Electrical SystemFire
TL* THE CONTACT OWNS A 2012 PETERBILT 587. THE CONTACT STATED THAT HE NOTICED SMOKE COMING FROM THE UNDERCARRIAGE. THE CONTACT EXITED THE VEHICLE AND DISCOVERED THERE WAS A FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. AFTER FURTHER INSPECTION, IT WAS DETERMINED THAT THE BATTERY CABLE HAD IGNITED. T…
Read full complaint
TL* THE CONTACT OWNS A 2012 PETERBILT 587. THE CONTACT STATED THAT HE NOTICED SMOKE COMING FROM THE UNDERCARRIAGE. THE CONTACT EXITED THE VEHICLE AND DISCOVERED THERE WAS A FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER. AFTER FURTHER INSPECTION, IT WAS DETERMINED THAT THE BATTERY CABLE HAD IGNITED. THE CABLES WERE ATTACHED TO THE ELECTRONIC CLUTCH ACTUATOR, WHICH HAD A PLASTIC COVER. THE PLASTIC TIE FRACTURED AND CAUSED THE BATTERY CABLES TO FAIL, ENERGIZING THE TRANSMISSION AND ENGINE BLOCK. THE HIGH HEAT CAUSED IT TO BECOME COMBUSTIBLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN BECAUSE OF THE FIRE DAMAGE. *TR UPDATED 7/2/13 *CN THE CONSUMER STATED DUE TO THE VIBRATION AND MOVEMENT, THE PLASTIC TIE USED TO SECURE THE BATTERY CABLES TO THE CLUTCH ACTUATOR SHEILD IS PRONE TO FAILURE. UPDATED 11/1/2013 *JS
NHTSA ODI #10505965
Official recalls
8Apr 6, 2020
PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."
Consequence & remedy
Consequence: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.
Remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB.
Additional source detail variants (2)
Electronic Stability Control (esc)
PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."
Consequence: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.
Remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB.
Service Brakes, Air:antilock:abs Warning Light
PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."
Consequence: If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.
Remedy: PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB.
Oct 9, 2015
Paccar Incorporated (Paccar) is recalling certain model year 2012-2013 Peterbilt 579 and 587 trucks manufactured February 14, 2011, to December 5, 2012 and 2011 Kenworth T700 trucks manufactured September 21, 2010, to October 1, 2010. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage.
Consequence & remedy
Consequence: If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.
Remedy: PACCAR will notify owners, and dealers will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on December 7, 2015. Owners may contact Kenworth customer service at 1-425-828-5000 or Peterbilt customer service at 1-940-591-4000. Paccar's numbers for this recall are 15KWP (Kenworth) and 1015M (Peterbilt).
Jul 22, 2015
PACCAR Incorporated (PACCAR) is recalling certain model year 2012-2016 Peterbilt 365, 367, 384, 386, 388, 389, 567, 579, and 587 trucks manufactured January 13, 2011, to April 20, 2015. The affected trucks, equipped with extended-body Leece Neville alternators, have alternator charge cables that may chafe against a formed metal freon discharge line.
Consequence & remedy
Consequence: If the alternator cable rubs through its insulation, an electrical short may occur, increasing the risk of a fire.
Remedy: Peterbilt will notify owners, and dealers will reroute the alternator charge cable away from the metal freon line and install a plastic insulator on the cable end, free of charge. The recall began on September 23, 2015. Owners may contact Peterbilt customer service at 1-940-591-4000. Peterbilt's number for this recall is 715-K.
May 8, 2015
PACCAR Incorporated (PACCAR) is recalling certain model year 2014-2016 Kenworth T660, T680, T880 trucks manufactured February 18, 2013, to April 10, 2015, and 2011-2016 Peterbilt 386, 389, 567, 579, and 587 trucks manufactured December 13, 2010, to April 20, 2015. The affected trucks, equipped with PACCAR MX-13 engines and Delco-Remy 40SI alternators, have alternator charge cables that may chafe against a formed metal freon discharge line.
Consequence & remedy
Consequence: If the alternator cable rubs through its insulation, an electrical short may occur, increasing the risk of a fire.
Remedy: PACCAR will notify owners, and dealers will reroute the alternator charge cable away from the metal freon line, free of charge. PACCAR issued an interim notification to owners on July 10, 2015. The recall began on September 16, 2015. Owners may contact Kenworth customer service at 1-425-828-5000 or Peterbilt customer service at 1-940-591-4000. PACCAR's numbers for this recall are 15KWE and 515-F.
Mar 6, 2015
PACCAR Incorporated (PACCAR) is recalling certain model year 2006-2016 Peterbilt 587, 579, 567, 389, 388, 387, 385, 382, 379, 378, 367, 365 and 357 trucks manufactured July 25, 2005, to February 26, 2016. The affected vehicles may be equipped with Tire and Rim Certification Labels that list a tire pressure below the actual correct amount. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 120, "Tire selection and rims and motor home/recreation vehicle trailer load carrying capacity information for motor vehicles with a GVWR of more than 4,536 kilograms (10,000 pounds)."
Consequence & remedy
Consequence: If the tires are underinflated due to the incorrect inflation pressure listed on the label, the truck may not be able to carry the maximum gross vehicle weight rating (GVWR) load listed without experiencing tire failure which would increase the risk of a crash.
Remedy: Peterbilt will notify owners and mail them a corrected Tire and Rim certification label, free of charge. The recall began on June 19, 2015. Owners may contact Peterbilt customer service at 1-940-591-4000. PACCAR's number for this recall is 215-D.
Additional source detail variants (2)
Equipment:other:labels
PACCAR Incorporated (PACCAR) is recalling certain model year 2006-2016 Peterbilt 587, 579, 567, 389, 388, 387, 385, 382, 379, 378, 367, 365 and 357 trucks manufactured July 25, 2005, to February 26, 2016. The affected vehicles may be equipped with Tire and Rim Certification Labels that list a tire pressure below the actual correct amount. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 120, "Tire selection and rims and motor home/recreation vehicle trailer load carrying capacity information for motor vehicles with a GVWR of more than 4,536 kilograms (10,000 pounds)."
Consequence: If the tires are underinflated due to the incorrect inflation pressure listed on the label, the truck may not be able to carry the maximum gross vehicle weight rating (GVWR) load listed without experiencing tire failure which would increase the risk of a crash.
Remedy: Peterbilt will notify owners and mail them a corrected Tire and Rim certification label, free of charge. The recall began on June 19, 2015. Owners may contact Peterbilt customer service at 1-940-591-4000. PACCAR's number for this recall is 215-D.
Tires
PACCAR Incorporated (PACCAR) is recalling certain model year 2006-2016 Peterbilt 587, 579, 567, 389, 388, 387, 385, 382, 379, 378, 367, 365 and 357 trucks manufactured July 25, 2005, to February 26, 2016. The affected vehicles may be equipped with Tire and Rim Certification Labels that list a tire pressure below the actual correct amount. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 120, "Tire selection and rims and motor home/recreation vehicle trailer load carrying capacity information for motor vehicles with a GVWR of more than 4,536 kilograms (10,000 pounds)."
Consequence: If the tires are underinflated due to the incorrect inflation pressure listed on the label, the truck may not be able to carry the maximum gross vehicle weight rating (GVWR) load listed without experiencing tire failure which would increase the risk of a crash.
Remedy: Peterbilt will notify owners and mail them a corrected Tire and Rim certification label, free of charge. The recall began on June 19, 2015. Owners may contact Peterbilt customer service at 1-940-591-4000. PACCAR's number for this recall is 215-D.
Jan 30, 2012
PACCAR IS RECALLING CERTAIN MODEL YEAR 2012-2013 KENWORTH T170, T270, T370, T440, T470, T660, T700, T800, W900, AND PETERBILT 320, 330, 337, 348, 365, 367, 382, 384, 386, 388, 389, AND 587 VEHICLES, MANUFACTURED FROM JANUARY 31, 2011, THROUGH JANUARY 19, 2012, AND EQUIPPED WITH BENDIX ATR-6 ANTILOCK TRACTION RELAY VALVES. IN EXTREMELY COLD CONDITIONS, THESE BENDIX RELAY VALVES MAY POTENTIALLY DEVELOP INTERNAL LEAKAGE. INTERNAL LEAKAGE CAN LEAD TO AIR PRESSURE BEING DELIVERED TO AFFECTED PRIMARY OR SECONDARY BRAKE CAUSING CONTINUOUS BRAKE APPLICATION.
Consequence & remedy
Consequence: UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE BRAKES TO OVERHEAT AND LEAD TO A FIRE. UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH. ALSO, THE BRAKES MAY BE APPLIED WITHOUT ILLUMINATING THE BRAKE LIGHTS, FAILING TO GIVE PROPER WARNING TO OTHER DRIVERS.
Remedy: PACCAR WILL NOTIFY OWNERS, AND PROVIDE A TEMPORARY REPAIR UNTIL BENDIX DEVELOPS A PERMANENT REMEDY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 10, 2012. OWNER MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196.
Jun 23, 2011
PACCAR IS RECALLING CERTAIN MODEL YEAR 2012 PETERBILT 587 TRACTORS, MANUFACTURED FROM JANUARY 12, 2011, THROUGH MAY 20, 2011, EQUIPPED WITH MERITOR'S MAXTON DRIVELINE ASSEMBLIES. THE TUBING MAY HAVE A SEAM WELD WITH INSUFFICIENT BONDING. THE AFFECTED DRIVELINE ASSEMBLIES ARE RPL25 COUPLING SHAFTS AND SLIP SHAFTS (MAIN) DRIVELINE ASSEMBLIES.
Consequence & remedy
Consequence: THIS CAN RESULT IN SEAM WELD FRACTURE WHEN TORQUE IS APPLIED. ONCE THE TUBE SEAM WELD IS FRACTURED, THE DRIVELINE MAY BECOME INOPERABLE WHICH MAY RESULT IN A DISABLED VEHICLE OR DEBRIS FROM THE DRIVELINE MAY FALL ON THE ROADWAY, BOTH OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE MAIN DRIVE SHAFT, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 11, 2011. OWNERS MAY CONTACT PACCAR AT 1-425-468-7400.
Feb 23, 2011
PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2012 KENWORTH T2000, T660, T700, T800, AND W900, AS WELL AS MODEL YEAR 2009-2012 PETERBILT 365, 367, 384, 386, 387, 388, 389, AND 587 TRUCKS EQUIPPED WITH PACCAR MX ENGINES. THE OIL MODULE CENTRIFUGAL SPINNER FILTER CAP IN THE PACCAR MX ENGINE MAY BECOME LOOSE, POSSIBLY ALLOWING THE CAP TO COME OFF AND ENGINE OIL TO PARTIALLY DISCHARGE FROM THE OIL MODULE ONTO EXHAUST COMPONENTS.
Consequence & remedy
Consequence: THE DISCHARGE OF ENGINE OIL ONTO EXHAUST COMPONENTS WHICH ARE HOT, SUCH AS WHEN THE ENGINE IS UNDER SIGNIFICANT LOAD, MAY CAUSE A FIRE.
Remedy: DEALERS WILL RE-TORQUE THE OIL MODULE FILTER CAP AND INSTALL A SECONDARY RETENTION DEVICE ON THE SECONDARY CENTRIFUGAL SPINNER FILTER CAP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration