Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 7 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Diesel. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports3 fire reports0 injury reports
What owners actually said
7 reports
Mileage unknown · Jun 29, 2011
Engine And Engine CoolingFire
2005 PETERBILT 379, UNIT 1 WAS TRAVELING EASTBOUND ON THE OHIO TURNPIKE IN THE MIDDLE LANE WHEN HIS TRUCK CAUGHT FIRE FROM UNDERNEATH THE FRONT HOOD NEAR THE ENGINE. UNIT 1 THEN DROVE TO THE SOUTH SIDE OF THE SHOULDER WHERE HE PUT THE FIRE OUT. *BF OIL LEAKED FROM UNDERNEATH THE HOOD. (OHIO TRAFFIC CRASH REPORT # 10-0302-90)…
Read full complaint
2005 PETERBILT 379, UNIT 1 WAS TRAVELING EASTBOUND ON THE OHIO TURNPIKE IN THE MIDDLE LANE WHEN HIS TRUCK CAUGHT FIRE FROM UNDERNEATH THE FRONT HOOD NEAR THE ENGINE. UNIT 1 THEN DROVE TO THE SOUTH SIDE OF THE SHOULDER WHERE HE PUT THE FIRE OUT. *BF OIL LEAKED FROM UNDERNEATH THE HOOD. (OHIO TRAFFIC CRASH REPORT # 10-0302-90)*JB
NHTSA ODI #10409964
200,000 miles · Feb 17, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 PETERBILT CONVENTIONAL 379. THE CONTACT NOTICED THAT THE FAN HUB WAS FRACTURED. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED. APPROXIMATELY TWO YEARS EARLIER, THE FAN HUB WAS REPLACED BUT BECAME FRACTURED AGAIN. THE VEHICLE WAS AT AN AUTHORIZED DEALER BEING REPAIRED. THE CURRENT MILEAGES …
Read full complaint
TL* THE CONTACT OWNS A 2005 PETERBILT CONVENTIONAL 379. THE CONTACT NOTICED THAT THE FAN HUB WAS FRACTURED. NEITHER THE DEALER NOR THE MANUFACTURER HAD BEEN NOTIFIED. APPROXIMATELY TWO YEARS EARLIER, THE FAN HUB WAS REPLACED BUT BECAME FRACTURED AGAIN. THE VEHICLE WAS AT AN AUTHORIZED DEALER BEING REPAIRED. THE CURRENT MILEAGES WAS 490,000 AND THE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10383040
Mileage unknown · Jul 26, 2010
Tires
2005 PETERBUILT 379, UNIT 2 HAD A BLOWOUT ON THE TRAILER. DEBRIS FROM THE FAILURE STRUCK UNIT 1 CAUSING DAMAGE. *BF (OHIO TRAFFIC CRASH REPORT # 10-0359-91)*JB UPDATED 08/06/10 *BF
NHTSA ODI #10345509
Mileage unknown · Mar 22, 2010
Power Train
2005 PETERBILT 379 CONVENTIONAL, DRIVE SHAFT BROKE FROM TRUCK ONTO THE ROADWAY AND ANOTHER VEHICLE STRUCK IT. *BF OHIO TRAFFIC CRASH REPORT # 10-0279-90 UPDATED 05/03/10 *BF
NHTSA ODI #10321932
350,000 miles · Jan 28, 2010
Fuel System, DieselFire
TL*THE CONTACT OWNS A 2005 PETERBILT 379 TRACTOR. WHILE DRIVING APPROXIMATELY 65 MPH ON NORMAL ROAD CONDITIONS. THERE WAS A STRONG ODOR OF FUEL COMING FROM OUTSIDE OF THE VEHICLE. THE FUEL PRESSURE GAUGE DISPLAYED FLUCTUATED READINGS. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION. SUDDENLY, THE DRIVER PULLED OVER TO THE SIDE O…
Read full complaint
TL*THE CONTACT OWNS A 2005 PETERBILT 379 TRACTOR. WHILE DRIVING APPROXIMATELY 65 MPH ON NORMAL ROAD CONDITIONS. THERE WAS A STRONG ODOR OF FUEL COMING FROM OUTSIDE OF THE VEHICLE. THE FUEL PRESSURE GAUGE DISPLAYED FLUCTUATED READINGS. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION. SUDDENLY, THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND EXITED THE VEHICLE. THE VEHICLE WAS ENGULFED IN MASSIVE FLAMES. THE FIRE AND POLICE DEPARTMENT WERE CALLED TO THE SCENE. THE VEHICLE WAS TOWED AND COMPLETELY DESTROYED. THE FAILURE MILEAGE WAS 350,000. THE VIN WAS UNAVAILABLE. UPDATED 11/16/10. *LJ
NHTSA ODI #10303048
Mileage unknown · Jun 17, 2008
Power TrainFire
2005 PETERBILT 379 CAUGHT FIRE. CONSUMER HEARD A HISSING NOISE AND PULLED OVER AND NOTICE THE TIRES WERE ON FIRE. *NJ THE DRIVER NOTICED SMOKE COMING FROM THE DRIVE AXLES. OHIO TRAFFIC REPORT # 10-0196-89 UPDATED 04/15/10 *BF
NHTSA ODI #10231773
101,000 miles · Apr 18, 2006
Fuel System, Diesel
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, FUEL LEAKED FROM THE FUEL TANK. THERE WERE NO OBVIOUS ROAD HAZARDS. THE VEHICLE WAS SEEN BY A DEALER FOR INSPECTION. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM.
Paccar Incorporated (Paccar) is recalling certain 2004-2013 Peterbilt 379, 357, 378, 367, 388, 365, 389, 385 and 386 trucks manufactured from April 3, 2003, through October 25, 2013 and equipped with tri-drive rear axles and a tag or pusher axle. The affected vehicles may be missing required information from the certification label, specifically the tag or pusher axle the gross axle weight rating, suitable tire and rim information, and recommended tire pressure information. Without this information, the vehicles do not comply with the requirements of 49 C.F.R. Part 567, "Certification."
Consequence & remedy
Consequence: As a result, the axles may be overloaded or the wrong tires could be installed or the tires could be improperly inflated. All of these issues increase the risk of a crash.
Remedy: Peterbilt will notify owners and dealers will inspect and replace the certification labels missing the necessary information. The recall is expected to begin in January 2014. Customers can contact Peterbilt at 1-940-591-4000. Peterbilt's number for this campaign is 1113-F.
PACCAR IS RECALLING 130 MY 2005-2007 KENWORTH C500, T800, W900, AND PETERBILT MODELS 357 AND 379 TRACTOR TRAILERS EQUIPPED WITH FABCO SLACK ADJUSTERS ON SISU AXLES. THE SLACK ADJUSTERS MAY FAIL AS A RESULT OF A FATIGUE CRACK RENDERING THE SLACK ADJUSTER INOPERATIVE. THIS COULD REDUCE BRAKING EFFECTIVENESS.
Consequence & remedy
Consequence: REDUCTION IN BRAKING CAPACITY COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE SLACK ADJUSTERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 21, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440 AND PETERBILT AT 1-940-591-4196.
ON CERTAIN NON-ABS EQUIPPED TRUCKS, AN AIR HOSE BETWEEN THE TRACTOR PROTECTION VALVE AND THE BACK OF THE CAB BULKHEAD WAS OMITTED.
Consequence & remedy
Consequence: THE ABSENCE OF THIS AIR HOSE COULD ADVERSELY AFFECT THE DRIVE AXLE BRAKE PERFORMANCE WHILE A TRAILER IS BEING PULLED, RESULTING IN LONGER STOPPING DISTANCES, INCREASING THE RISK OF A CRASH.
Remedy: PETERBILT WILL INSPECT THE AIR HOSE PLUMBING OF THE DRIVE AXLE BRAKE SYSTEM AND MAKE THE NECESSARY REPAIRS. THE RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT PETERBILT AT 1-940-591-4196.
ON CERTAIN TRUCKS, WHEN USING A CUMMINS ELECTRONIC ICON SERVICE TOOL 2.2, AN UNINTENDED ENGINE START WILL OCCUR.
Consequence & remedy
Consequence: GIVEN THE PURPOSE AND FUNCTIONALITY OF THIS SERVICE TOOL, THIS SERIES OF EVENTS WOULD ONLY OCCUR IN A SERVICE FACILITY AND COULD POSE A HAZARD IF THE TRUCK WERE TO UNEXPECTEDLY MOVE OR THE ENGINE TO START WITHOUT ANY WARNING, POSSIBLY CAUSING PERSONAL INJURY.
Remedy: CUMMINS IS CONDUCTING THIS RECALL (PLEASE SEE 06E063000) AND WILL REPLACE THE ICON SERVICE TOOL 2.2 WITH A NEW ICON SERVICE TOOL 2.3 FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR PETERBILT AT 1-940-591-4201.
ON CERTAIN TRACTORS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE VARIABLE VALVE ACTUATION OIL LINE MAY WEAR AGAINST THE SHARP EDGE OF THE CYLINDER HEAD IF NOT POSITIONED CORRECTLY.
Consequence & remedy
Consequence: THE OIL LINE MAY BE CUT ON THE CYLINDER HEAD CAUSING AN OIL LEAK AND A POSSIBLE FIRE.
Remedy: CATERPILLAR, IN CONJUNCTION WITH PACCAR, WILL BE CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN FREE OF CHARGE. OWNERS MAY CALL CATERPILLAR AT 309-675-6496, KENWORTH AT 425-828-5440, OR PETERBILT AT 940-591-4201.
ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE SUSPENSION HAS TRANSVERSE BEAM CASTINGS THAT MAY FRACTURE UNDER NORMAL LOADS. IF A CASTING BREAKS WHEN THE VEHICLE IS TRAVELING ON A ROADWAY THERE IS THE POTENTIAL FOR PIECES OF THE CASTING TO BECOME PROJECTILES AND THE SUSPENSION'S TRANSVERSE BEAM MAY DROP DOWN LOW ENOUGH TO CONTACT THE ROAD SURFACE.
Consequence & remedy
Consequence: THIS COULD CAUSE SPARKS THAT COULD POTENTIALLY IGNITE AND CAUSE A FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE DEFECTIVE TRANSVERSE BEAM ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 10, 2005, WITH LETTERS BEING MAILED TO PETERBILT OWNERS; AND ON JUNE 17, 2005, FOR KENWORTH OWNERS. OWNERS MAY CONTACT PETERBILT AT 940-591-4201 OR KENWORTH AT 425-828-5440.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Peterbilt 379 Problems, Complaints & Recalls | Skip That Year
Illustration