Electrical SystemEngine And Engine CoolingEquipment
AWD DISABLE AND ABS LIGHTS ILLUMINATED. LEFT REAR WHEEL BEARING AND HUB ASSEMBLY FAILED AND WERE REPLACED (FOUR TIMES).*AK THE EVAP SOLENOID, FUEL SENDER AND PUMP ASSEMBLY WERE REPLACED. THE HEATING ELEMENT FOR THE FRONT DRIVER'S SEAT FAILED TWICE. THE RIGHT REAR SEAT BELT FAILED. THE RIGHT POWER SLIDING DOOR ACTUATOR MODUL…
Read full complaint
AWD DISABLE AND ABS LIGHTS ILLUMINATED. LEFT REAR WHEEL BEARING AND HUB ASSEMBLY FAILED AND WERE REPLACED (FOUR TIMES).*AK THE EVAP SOLENOID, FUEL SENDER AND PUMP ASSEMBLY WERE REPLACED. THE HEATING ELEMENT FOR THE FRONT DRIVER'S SEAT FAILED TWICE. THE RIGHT REAR SEAT BELT FAILED. THE RIGHT POWER SLIDING DOOR ACTUATOR MODULE FAILED. REAR WIPER FAILED INTERMITTENTLY. A/C CONDENSER FAILED. ENGINE FAILED. *NM
NHTSA ODI #10114146
27,600 miles · Mar 16, 2004
Seat BeltsInjury
WHILE DRIVING WITH MY FAMILY, TRAFFIC CAME TO A SUDDEN STOP AND MY SON (5YRS, IN A CAR SEAT), WHO WAS SITTING IN THE FIRST ROW BEHIND THE PASSENGER, SLAMMED HIS HEAD AGAINST THE BACK OF THE SEAT. MY WIFE BLAMED ME FOR NOT FASTENING HIM IN CORRECTLY. SO I LET HER DO IT, AND WE BOTH YANKED ON THE SEAT BELT TO MAKE SURE IT WAS OK. …
Read full complaint
WHILE DRIVING WITH MY FAMILY, TRAFFIC CAME TO A SUDDEN STOP AND MY SON (5YRS, IN A CAR SEAT), WHO WAS SITTING IN THE FIRST ROW BEHIND THE PASSENGER, SLAMMED HIS HEAD AGAINST THE BACK OF THE SEAT. MY WIFE BLAMED ME FOR NOT FASTENING HIM IN CORRECTLY. SO I LET HER DO IT, AND WE BOTH YANKED ON THE SEAT BELT TO MAKE SURE IT WAS OK. THEN IT HAPPENED AGAIN. MY WIFE TOOK THE VAN TO THE DEALER TO GET A NEW LATCH. WHILE WE WERE WAITING FOR THE PART TO ARRIVE, I WAS DRIVING AGAIN WITH MY FAMILY WHEN THE LIGHT TURNED YELLOW AND I SLAMMED ON THE BRAKES. MY SON NOW SITTING IN THE BACK ROW IN HIS CAR SEAT, AGAIN HIT THE BACK OF THE FRONT PASSENGER SEAT. NOW THE DEALER SAYS THAT THEY NEVER TOLD US THEY WOULD GET US ANOTHER PART, AND THAT WE HAD TO CALL GM. THEY SAID THEY WOULD SEND A REP OUT AND NEVER HAVE. FURTHERMORE WE RECEIVED A NOTICE THAT SAID OUR PARTS WERE IN AFTER THEY TOLD US THAT THEY COULDN'T GET THE PARTS. ALL WE WANT IS TO HAVE THE VEHICLE TESTED UNDER HARD BRAKING AND THE TWO LATCHES REPLACED. *JB
NHTSA ODI #10062368
25,000 miles · Jan 15, 2004
EquipmentSeat Belts
SEATBELT-2ND ROW PASSENGER SIDE BELT KEEPS PULLING TIGHTER AND TIGHTER AND LOCKING. CHILDREN WOULD REFUSE TO WEAR IT BECAUSE OF THE DISCOMFORT. REPLACED AND SEEMS FINE NOW. COMPUTER CONTROL- STILL ONGOING, BATTERY LIGHT KEEPS COMING ON AND OFF, ALTERNATER HAS BEEN REPLACED, STILL HAPPENING. SERVICE TRACTION CONTROL,TRACTION CON…
Read full complaint
SEATBELT-2ND ROW PASSENGER SIDE BELT KEEPS PULLING TIGHTER AND TIGHTER AND LOCKING. CHILDREN WOULD REFUSE TO WEAR IT BECAUSE OF THE DISCOMFORT. REPLACED AND SEEMS FINE NOW. COMPUTER CONTROL- STILL ONGOING, BATTERY LIGHT KEEPS COMING ON AND OFF, ALTERNATER HAS BEEN REPLACED, STILL HAPPENING. SERVICE TRACTION CONTROL,TRACTION CONTROL OFF INDICATOR LIGHT, ABS INDICATOR LIGHT, AIR BAG INDICATOR LIGHT, ALL COME ON AT THE SAME TIME. VAN HESITATES AND THE HEADLIGHTS GO DIM THEN BRIGHT. DEALER HASN'T BEEN ABLE TO PINPOINT TROUBLE BUT AFTER THEY WORK ON IT, IT GOES AWAY FOR ABOUT 3 WEEKS AND STARTS AGAIN.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
2002 Oldsmobile Silhouette Problems, Complaints & Recalls | Skip That Year
Illustration