Engine And Engine Cooling. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports2 fire reports4 injury reports

Steering complaints

3 reports

Clear category filter

Mileage unknown · Sep 16, 2002

Power TrainSteering

THE 2 OUTER TIE RODS, REPORTED OF A LOT OF NOISE IN THE FRONT END FROM 5K TO 23K+ MILES. CONSUMER/MECHANIC THOUGHT THAT THIS NOISE COULD BE FROM A LOOSE BUMPER, THEREFORE CLIPS WERE ADDED, BUT THE RATTLE NOISE IS STILL THERE. *SCC

NHTSA ODI #567458

Mileage unknown · Dec 19, 2001

Steering

WHILE DRIVING AT HIGHWAY SPEEDS, DRIVER LOST CONTROL OF THE VEHICLE DUE TO A DEFECTIVE STEERING SHAFT. DEALER HAS REPLACED STEERING SHAFT. *AK CONSUMER HAD NO STEERING, HOWEVER WAS ABLE TO GET THE VEHICLE OFF OF THE ROAD SAFELY INTO A DITCH. *SLC

NHTSA ODI #8000926

Mileage unknown · Apr 26, 2001

Steering

WHEN TRYING TO TURN STEERING WHEEL IT WILL BIND UP, MAKING IT HARD TO TURN. TOOK VEHICLE TO DEALER, AND THEY PUT A NEW POWER STEERING PUMP.*AK

NHTSA ODI #886869

Official recalls

04V597000 · Latches/locks/linkages:doors:latch

Dec 22, 2004

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Consequence & remedy

Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

01V264000 · Latches/locks/linkages:doors:latch

Aug 21, 2001

VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.

Consequence & remedy

Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

01V067000 · Latches/locks/linkages:doors:latch

Mar 8, 2001

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.

Consequence & remedy

Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

00V228003 · Seat Belts

Aug 7, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Consequence & remedy

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

99V268000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Sep 29, 1999

VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."

Consequence & remedy

Consequence: IN A VEHICLE ROLLOVER ACCIDENT, IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.

Remedy: DEALERS WILL INSPECT THE VEHICLES TO LOCATE AND REPLACE THOSE FUEL TANKS THAT COULD HAVE INOPERATIVE ROLLOVER VALVES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE04064 · POWER-SLIDING Door

Opened Sep 17, 2004 · Closed Dec 22, 2004

Status: closed (inferred from source dates) · Structure:body:door

SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.

PE02017 · Shoulder Harness Clip

Opened Feb 11, 2002 · Closed Aug 2, 2002

Status: closed (inferred from source dates) · Seat Belts

No summary supplied.

SQ00014 · Unexpected Opening Of Sliding Door

Opened Jul 25, 2000 · Closed Oct 22, 2001

Status: closed (inferred from source dates) · Structure

There is no summary currently available