NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
256 reports104,855 miles · Nov 14, 2006
Engine And Engine CoolingService Brakes, HydraulicSteering
DT*: THE CONTACT STATED ON START UP, THE VEHICLE SPUTTERED AND STALLED. WHILE DRIVING 30 MPH, THE ENGINE OVERHEATED, THE CHECK OIL LIGHT AND TRACTION CONTROL LIGHTS ILLUMINATED, PRIOR TO THE ENGINE POWER FAILING. THE BRAKES SQUEAKED BADLY AS THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO THE SALES/SERVICE DEALER FOR REPAIR…
Read full complaint
DT*: THE CONTACT STATED ON START UP, THE VEHICLE SPUTTERED AND STALLED. WHILE DRIVING 30 MPH, THE ENGINE OVERHEATED, THE CHECK OIL LIGHT AND TRACTION CONTROL LIGHTS ILLUMINATED, PRIOR TO THE ENGINE POWER FAILING. THE BRAKES SQUEAKED BADLY AS THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO THE SALES/SERVICE DEALER FOR REPAIRS. ON THE FIRST VISIT, THE THERMOSTAT AND THERMOSTAT HOUSING WERE REPLACED. THE INTERMEDIATE SHAFT ASSEMBLY WAS SERVICED AND THE OIL AND FILTER WERE REPLACED. THE STALLING CONTINUED AND THE VEHICLE WAS RETURNED TO THE SALES/SERVICE DEALER, WHERE THE RIGHT PORTIONING VALVE WAS REPLACED AND THE BRAKE LINES WERE BLED. THE OIL AND FILTER WERE REPLACED AGAIN. THE POWER FAILED AGAIN WHILE TRAVELING 55 MPH. AFTER INSPECTION OF THE VEHICLE THE SALES MANAGER INFORMED THE CONTACT, THE CRANKSHAFT POSITION SENSOR, REAR STRUTS AND STEERING GEAR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. UPDATED 12/3/2006 - *NM
NHTSA ODI #10173451
95,000 miles · Oct 28, 2006
Visibility
(1) OPENING AND CLOSING THE DOOR; (2) DOOR WILL NOT OPEN OR SHUT DUE TO THE FRAME/METAL TO WHICH THE DRIVER'S DOOR HINGE MOUNTS TO FLEXING CAUSEING THE DOOR TO BE MISALIGNED WITH THE LATCH. AFTER TRYING TO SHUT THE DOOR THE DRIVER'S WINDOW FELL DOWN AND WILL NOT ROLL UP OR DOWN WITH THE CONTROLS... (3) AT THE MOMENT THE WI…
Read full complaint
(1) OPENING AND CLOSING THE DOOR; (2) DOOR WILL NOT OPEN OR SHUT DUE TO THE FRAME/METAL TO WHICH THE DRIVER'S DOOR HINGE MOUNTS TO FLEXING CAUSEING THE DOOR TO BE MISALIGNED WITH THE LATCH. AFTER TRYING TO SHUT THE DOOR THE DRIVER'S WINDOW FELL DOWN AND WILL NOT ROLL UP OR DOWN WITH THE CONTROLS... (3) AT THE MOMENT THE WINDOW IS HELD UP WITH A PAIR OF VICE GRIPS UNTIL I CAN AFFORD TO REPLACE THE WHOLE DOOR...*NM
NHTSA ODI #10172024
46,000 miles · Sep 25, 2006
Visibility
WHILE CAR WAS STILL UNDER WARRANTY, DRIVERS FRONT AND PASSENGERS BACK ELECTRIC WINDOWS FAILED AND WERE REPLACED. CAR IS OWNED BY SINGLE ADULT, NO CHILDREN, WINDOWS ARE NOT ABUSED....WITHIN PAST 6 MONTHS DRIVERS FRONT, DRIVERS BACK, AND PASSENGERS FRONT ELECTRIC WINDOWS HAVE ALL FAILED. PLASTIC CLIP THAT HOLDS THE CABLE HAS BROK…
Read full complaint
WHILE CAR WAS STILL UNDER WARRANTY, DRIVERS FRONT AND PASSENGERS BACK ELECTRIC WINDOWS FAILED AND WERE REPLACED. CAR IS OWNED BY SINGLE ADULT, NO CHILDREN, WINDOWS ARE NOT ABUSED....WITHIN PAST 6 MONTHS DRIVERS FRONT, DRIVERS BACK, AND PASSENGERS FRONT ELECTRIC WINDOWS HAVE ALL FAILED. PLASTIC CLIP THAT HOLDS THE CABLE HAS BROKEN ON ALL THREE WINDOWS...CABLE WINDS INSIDE OF MOTOR MAKING IT NECESSARY TO REPLACE REGULATOR AND MOTOR. *NM
NHTSA ODI #10169244
105,000 miles · Mar 9, 2006
Fuel System, GasolineInjury
DT*: THE CONTACT STATED WHILE STARTING THE VEHICLE THE MANIFOLD BLEW UP. THE DEALERSHIP INSPECTED AND DETERMINED THE FIRE WAS DUE TO THE FUEL PRESSURE REGULATORS. THERE ARE PICTURES AVAILABLE AND ONE INJURY. THERE IS A NHTSA RECALL, # 04V090000, REGARDING THE FUEL SYSTEM GASOLINE DELIVERY. THE VEHICLE HAS THE SAME PROBLEMS A…
Read full complaint
DT*: THE CONTACT STATED WHILE STARTING THE VEHICLE THE MANIFOLD BLEW UP. THE DEALERSHIP INSPECTED AND DETERMINED THE FIRE WAS DUE TO THE FUEL PRESSURE REGULATORS. THERE ARE PICTURES AVAILABLE AND ONE INJURY. THERE IS A NHTSA RECALL, # 04V090000, REGARDING THE FUEL SYSTEM GASOLINE DELIVERY. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE MODEL AND VIN.
NHTSA ODI #10152295
53,000 miles · Feb 22, 2006
Power TrainSteering
DT*: THE CONTACT STATED THE VEHICLE STALLED OUT WHILE ATTEMPTING TO MAKE A LEFT TURN AT 10 MPH AND THERE WAS A LOSS OF ALL POWER. THERE IS A NHTSA RECALL, #03V527000, REGARDING THE STEERING. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS …
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE STALLED OUT WHILE ATTEMPTING TO MAKE A LEFT TURN AT 10 MPH AND THERE WAS A LOSS OF ALL POWER. THERE IS A NHTSA RECALL, #03V527000, REGARDING THE STEERING. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS SEEN BY A DEALER AND REPAIRS WERE MADE AS INSTRUCTED IN THE RECALL. UPDATED 2/9/2006 - AS OF 2/24/2006 THE VEHICLE HAS NOT BEEN REPAIRED. ON 2/10/06 THE DEALER REPLACED THE TRANSMISSION PRESSURE CONTROL SOLENOID AND REPLACED MASS AIR FLOW SENSOR. *NM
NHTSA ODI #10150918
110,000 miles · Feb 13, 2006
Fuel System, GasolineInjury
MY 1999 OLDSMOBILE INTRIGUE WOULD NOT START. I PUT THE HOOD UP AND TOLD MY GIRLFRIEND TO START THE CAR. WHEN SHE DID IT BACKFIRED INTO THE INTAKE AND BLEW UP IN MY FACE. I LOST HEARING IN MY LEFT EAR FOR ABOUT 4 DAYS. CAR GOT TOWED TO CHANCE'S AUTOMOTIVE IN EASTON, MARYLAND. SINCE I HAVE FULL COVERAGE ON THE CAR I GOT A RENTAL …
Read full complaint
MY 1999 OLDSMOBILE INTRIGUE WOULD NOT START. I PUT THE HOOD UP AND TOLD MY GIRLFRIEND TO START THE CAR. WHEN SHE DID IT BACKFIRED INTO THE INTAKE AND BLEW UP IN MY FACE. I LOST HEARING IN MY LEFT EAR FOR ABOUT 4 DAYS. CAR GOT TOWED TO CHANCE'S AUTOMOTIVE IN EASTON, MARYLAND. SINCE I HAVE FULL COVERAGE ON THE CAR I GOT A RENTAL VEHICLE THROUGH THE INSURANCE COMPANY. WEEKS LATER THE INSURANCE COMPANY SAYS THAT THERE IS A RECALL ON MY CAR. HOWEVER I WAS NEVER NOTIFIED BY ANY MANUFACTURER SAYING SO. SINCE THERE WAS/IS A RECALL ON MY CAR THE INSURANCE COMPANY SAYS THAT THEY WILL NOT PAY FOR THE COST OF MY CAR BEING FIXED. SO I CALL A LOCAL GENERAL MOTORS DEALERSHIP. THE GENERAL MOTORS DEALERSHIP SAYS THAT THEY DO NOT HAVE ANY INFORMATION ABOUT THIS RECALL AND THEY ARE NOT GOING TO FIX IT BECAUSE THEY DO NOT HAVE A RECORD SAYING THERE IS A RECALL ON MY CAR. I HAVE CALLED MY INSURANCE COMPANY NUMEROUS TIMES TRYING TO FIND WHAT WEBSITE THEY WERE USING TO OBTAIN THIS INFORMATION. FINALLY AFTER WEEKS THEY GIVE ME YOUR WEBSITE. I SEARCHED THE REPORTS WITH 3 RECALL NUMBERS(WHICH 2 DO NOT EXIST;96V1160000 AND 03V473000) THAT THE INSURANCE COMPANY GAVE ME. RECALL # 04V09000 IS LISTED IN YOUR DATABASE BUT THE RECALL DOES NOT SPECIFICALLY MENTION MY CAR, A 1999 OLDSMOBILE INTRIGUE. HOWEVER THE MOTOR YOU SPECIFY IS THE SAME MOTOR IN MY CAR. FROM THIS INFORMATION I DO NOT KNOW WHOM SHOULD TAKE RESPONSIBILITY FOR IT. I HAVE BEEN GETTING THE RUN AROUND FOR A MONTH NOW FROM THE INSURANCE COMPANY AND THE LOCAL GENERAL MOTORS DEALERSHIP. I HAVE A RENTAL VEHICLE WHICH HAVE TO GO BACK TOMORROW, FEBRUARY 14, 2006. I HAVE A 10 YEAR OLD SON WHO I HAVE TO TAKE TO SCHOOL EVERYDAY AND I HAVE A CAREER OF MY OWN. WITHOUT TRANSPORTATION I CANNOT PROVIDE FOR MY CHILD. I JUST WANT THESE MESS TO BE SOLVED. IF YOU COULD HELP ME IN ANY WAY POSSIBLE PLEASE CONTACT ME. MY NAME IS [XXX] AND MY NUMBER IS [XXX] IF NO ANSWER PLEASE CALL [XXX]. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6
NHTSA ODI #10150157
112,284 miles · Jan 23, 2006
Electrical System
THE POWER WIRES FEEDING THE HEATER/AIR CONDITIONER FAN MOTOR BURNED. THE UNIT WAS FUNCTIONING NORMALLY FOR THE LIFE OF THE CAR. THEY WERE NEVER DAMAGED, OR CORRODED. THE AREA BURNED WAS EXTERNAL TO THE FAN AND HAD CONSIDERABLE COMBUSTIBLES SURROUNDING IT. THERE WAS NO APPARENT SERVICE BULLETIN AT THIS TIME. *AK
NHTSA ODI #10148424
Mileage unknown · Nov 28, 2005
Engine And Engine Cooling
THREE TIMES IN THE LAST TWO WEEKS, VEHICLE HAS STALLED AND THE MOTOR HAS CUT OFF WHILE DRIVING IN TRAFFIC. IT HAPPENS WHEN I LET UP ON THE ACCELERATOR PRIOR TO A TURN IN CITY TRAFFIC. THIS PROBLEM OCCURRED PREVIOUSLY, JUST AFTER I BOUGHT THE CAR IN 1999 AND IT WAS REPAIRED UNDER WARRANTY (CRANK SENSOR). IT HAPPENED AGAIN A COU…
Read full complaint
THREE TIMES IN THE LAST TWO WEEKS, VEHICLE HAS STALLED AND THE MOTOR HAS CUT OFF WHILE DRIVING IN TRAFFIC. IT HAPPENS WHEN I LET UP ON THE ACCELERATOR PRIOR TO A TURN IN CITY TRAFFIC. THIS PROBLEM OCCURRED PREVIOUSLY, JUST AFTER I BOUGHT THE CAR IN 1999 AND IT WAS REPAIRED UNDER WARRANTY (CRANK SENSOR). IT HAPPENED AGAIN A COUPLE YEARS AGO WHEN TRACTION WAS LOST ON ICE AND REPAIRED AT MY EXPENSE. EACH TIME THE VEHICLE STALLED AND THE ENGINE SHUT OFF WHILE MOVING IN TRAFFIC. *JB
NHTSA ODI #10143791
20,000 miles · Nov 9, 2005
Seat Belts
DT: THE CONTACT STATES THERE IS NHTSA RECALL 00V440000 CONCERNING SEAT BELTS. THIS VEHICLE IS EXPERIENCING THE SAME PROBLEMS AS INDICATED ON THE RECALL. THE MANUFACTURER SAID THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
NHTSA ODI #10142269
Mileage unknown · Nov 2, 2005
Electrical System
PASSLOCK SYSTEM FAILURE, CAR WILL NOT START, KEY 'CHIP' FADING. *NM
NHTSA ODI #10141488
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.
Consequence & remedy
Consequence: THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.
Remedy: DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.
Oct 5, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.8L V6 ENGINE. SOME OF THESE VEHICLES WERE BUILT WITHOUT A HEATER HOSE CLIP WHICH COULD ALLOW THE HOSE TO SAG AND CONTACT THE OXYGEN SENSOR RESULTING IN A COOLANT LEAK.
Consequence & remedy
Consequence: IF A COOLANT LEAK WERE TO OCCUR, AND LEAKING COOLANT CONTACTED THE HOT EXHAUST MANIFOLD, AN ENGINE COMPARTMENT FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A HEATER HOSE CLIP.
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02005 · Headlamps Dim/flicker
Opened Jan 18, 2002 · Closed Apr 15, 2002
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA99019 · Rear Shoulder Belt Malfunction
Opened Jul 7, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
THE ALLEGED DEFECT CONCERNS TWO MAJOR SYMPTOMS:FAILURE TO RETRACT WEBBING AND INABILITY TO EXTEND THE WEBBINNG FOR USE. THE ROOT CAUSE OF THESE SYMPTOMS IS THE DESIGN OF THE TRIM BEZEL THROUGH WHICH THE SEBBING PASSES. BUILT INTO THE REAR PACKAGE SHELF, THE BEZEL INCLUDES A VERTICAL SLOT TO FACILITATE VEHICLE ASSEMBLY.THE SLOT IS POSITIONED SUCH THAT THE SHOULDER BELT WEBBING TENDS TO SLIP INTO IT.WEBBING INGESTION BY THE VERTICAL SLOT MAY RETARD WEBBING RETRACTION, OR ALLOW WEBBING TWISTS TO ACCUMULATE ON THE RETRACTOR SPOOL.IN EITHER CASE, THE RETRACTOR MAY FAIL TO MAINTAIN APPROPRIATE TENSION ON THE SEAT OCCUPANT.FAILURE OF THE SHOULDER BELT TO COMPLETELY RETRACT MAY ALSO RESULT IN AN INABILITY TO EXTEND IT FOR USE IF THE CHILD RESTRAINT CINCH FEATURE HAS BEEN INADVERTENTLY ENGAGE (BY EXTENDING THE WEBBING TO ITS MAXIMUM LENGTH).GM WILL REMEDY THE ALLEGED DEFECT IN THE SUBJECT VEHICLES BY STRAIGHTENING AN TWISTED REAR SHOULDER BELT WEBBING AND THEM INSTALLING A PLASTIC COVER THAT WILL PREVENT FURTHER WEBBING INGESTION BY THE WEBBING GUIDE VERTICAL SLOT.THIS ENGINEERIGN ANANLYSIS IS CLOSED.
Illustration