NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
58 reportsClear category filter85,000 miles · Jun 18, 2014
Electrical SystemEngineSteering
THE IGNITION SWITCH -- WHICH WAS REPLACED IN 2012 WITH A NEW GM DEALER PART -- TURNS BY ITSELF TO THE ACC SETTING WHILE DRIVING (ENGINE CUTS OUT AND POWER STEERING LOSES POWER). I SUSPECT THAT THIS IS RELATED TO THE GM IGNITION SWITCH RECALL PROBLEM, BUT SINCE THIS MODEL IS NOT ON THE RECALL LIST, I AM ENCOUNTERING A CHALLENGE …
Read full complaint
THE IGNITION SWITCH -- WHICH WAS REPLACED IN 2012 WITH A NEW GM DEALER PART -- TURNS BY ITSELF TO THE ACC SETTING WHILE DRIVING (ENGINE CUTS OUT AND POWER STEERING LOSES POWER). I SUSPECT THAT THIS IS RELATED TO THE GM IGNITION SWITCH RECALL PROBLEM, BUT SINCE THIS MODEL IS NOT ON THE RECALL LIST, I AM ENCOUNTERING A CHALLENGE TO GET IT REPAIRED. PLEASE PHONE ONLY -- NOT AN E-MAIL USER. *TR
NHTSA ODI #10604263
98,001 miles · Mar 14, 2014
Electrical SystemSteering
WHEN DRIVING MY 1999 OLDSMOBILE INTRIGUE AT APPROXIMATELY 45MPH I HIT A VERY LARGE POT HOLE IN THE STREET. IT JARRED THE VEHICLE AND SWITCHED THE IGNITION IN MY VEHICLE OFF. I LOST POWER IN THE VEHICLE AND MY ABILITY TO PROPERLY STEER THE VEHICLE. I WAS THANKFULLY IN A LANE WHERE I WAS ABLE TO PULL THE VEHICLE OVER WITHOUT IS…
Read full complaint
WHEN DRIVING MY 1999 OLDSMOBILE INTRIGUE AT APPROXIMATELY 45MPH I HIT A VERY LARGE POT HOLE IN THE STREET. IT JARRED THE VEHICLE AND SWITCHED THE IGNITION IN MY VEHICLE OFF. I LOST POWER IN THE VEHICLE AND MY ABILITY TO PROPERLY STEER THE VEHICLE. I WAS THANKFULLY IN A LANE WHERE I WAS ABLE TO PULL THE VEHICLE OVER WITHOUT ISSUE (POWER STEERING WAS NOT AVAILABLE AND THE WHEEL WAS ALMOST LOCKED AND IT REQUIRED A LOT OF PULLING TO BE ABLE TO PULL OVER) AND RESTART THE CAR. I DID HAVE A LARGE/HEAVY KEY RING ON MY KEYS AT THAT TIME. *TR
NHTSA ODI #10569375
99,000 miles · Mar 8, 2010
Steering
I HAVE A 1999 OLDSMOBILE INTRIGUE THAT IS HAVING THE SAME PROBLEMS WITH POWER STEERING LOSS AT LOW SPEEDS THAT GM IS HAVING WITH THEIR COBALT AND PONTIAC MODELS. THERE HAS BEEN NO RECALL ON THE INTRIGUE FOR THIS PROBLEM. THE MECHANIC CAN'T FIND WHAT IS WRONG WITH IT BECAUSE IT DOES NOT HAPPEN ALL THE TIME. THIS HAS BEEN GOING …
Read full complaint
I HAVE A 1999 OLDSMOBILE INTRIGUE THAT IS HAVING THE SAME PROBLEMS WITH POWER STEERING LOSS AT LOW SPEEDS THAT GM IS HAVING WITH THEIR COBALT AND PONTIAC MODELS. THERE HAS BEEN NO RECALL ON THE INTRIGUE FOR THIS PROBLEM. THE MECHANIC CAN'T FIND WHAT IS WRONG WITH IT BECAUSE IT DOES NOT HAPPEN ALL THE TIME. THIS HAS BEEN GOING ON FOR CLOSE TO 2 YEARS. THE LOSS OF STEERING OCCURS MORE IN HOT WEATHER. *TR
NHTSA ODI #10317666
137,000 miles · Apr 20, 2009
Engine And Engine CoolingSteeringFire
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED AND MAKING A LEFT TURN, THE CONTACT HEARD AN EXPLOSION THAT SHOOK HER VEHICLE. SHE LOST CONTROL OF THE STEERING, THE BATTERY WARNING LIGHT ILLUMINATED, AND SMOKE WAS PRESENT UNDERNEATH THE HOOD. A RELATIVE, WHO IS ALSO A MECHANIC, STATED THAT TH…
Read full complaint
TL*THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. WHILE DRIVING AT AN UNKNOWN SPEED AND MAKING A LEFT TURN, THE CONTACT HEARD AN EXPLOSION THAT SHOOK HER VEHICLE. SHE LOST CONTROL OF THE STEERING, THE BATTERY WARNING LIGHT ILLUMINATED, AND SMOKE WAS PRESENT UNDERNEATH THE HOOD. A RELATIVE, WHO IS ALSO A MECHANIC, STATED THAT THE FLUID ON THE MANIFOLD CAUSED THE VEHICLE TO BEGIN SMOKING AND THE STEERING KNUCKLE FELL OFF OF THE VEHICLE, WHICH COULD ALSO HAVE CAUSED FLUID TO LEAK AND SMOKE TO APPEAR. A FEW MONTHS AGO, THE CONTACT HEARD A HIGH PITCHED SOUND IN THE STEERING WHEEL. PRIOR TO THE FAILURE, SHE NOTICED AN OIL LEAK AND THE DEALER REPLACED THE PISTONS. THE VIN WAS UNAVAILABLE. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 137,000.
NHTSA ODI #10266061
104,855 miles · Nov 14, 2006
Engine And Engine CoolingService Brakes, HydraulicSteering
DT*: THE CONTACT STATED ON START UP, THE VEHICLE SPUTTERED AND STALLED. WHILE DRIVING 30 MPH, THE ENGINE OVERHEATED, THE CHECK OIL LIGHT AND TRACTION CONTROL LIGHTS ILLUMINATED, PRIOR TO THE ENGINE POWER FAILING. THE BRAKES SQUEAKED BADLY AS THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO THE SALES/SERVICE DEALER FOR REPAIR…
Read full complaint
DT*: THE CONTACT STATED ON START UP, THE VEHICLE SPUTTERED AND STALLED. WHILE DRIVING 30 MPH, THE ENGINE OVERHEATED, THE CHECK OIL LIGHT AND TRACTION CONTROL LIGHTS ILLUMINATED, PRIOR TO THE ENGINE POWER FAILING. THE BRAKES SQUEAKED BADLY AS THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO THE SALES/SERVICE DEALER FOR REPAIRS. ON THE FIRST VISIT, THE THERMOSTAT AND THERMOSTAT HOUSING WERE REPLACED. THE INTERMEDIATE SHAFT ASSEMBLY WAS SERVICED AND THE OIL AND FILTER WERE REPLACED. THE STALLING CONTINUED AND THE VEHICLE WAS RETURNED TO THE SALES/SERVICE DEALER, WHERE THE RIGHT PORTIONING VALVE WAS REPLACED AND THE BRAKE LINES WERE BLED. THE OIL AND FILTER WERE REPLACED AGAIN. THE POWER FAILED AGAIN WHILE TRAVELING 55 MPH. AFTER INSPECTION OF THE VEHICLE THE SALES MANAGER INFORMED THE CONTACT, THE CRANKSHAFT POSITION SENSOR, REAR STRUTS AND STEERING GEAR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. UPDATED 12/3/2006 - *NM
NHTSA ODI #10173451
53,000 miles · Feb 22, 2006
Power TrainSteering
DT*: THE CONTACT STATED THE VEHICLE STALLED OUT WHILE ATTEMPTING TO MAKE A LEFT TURN AT 10 MPH AND THERE WAS A LOSS OF ALL POWER. THERE IS A NHTSA RECALL, #03V527000, REGARDING THE STEERING. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS …
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE STALLED OUT WHILE ATTEMPTING TO MAKE A LEFT TURN AT 10 MPH AND THERE WAS A LOSS OF ALL POWER. THERE IS A NHTSA RECALL, #03V527000, REGARDING THE STEERING. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS SEEN BY A DEALER AND REPAIRS WERE MADE AS INSTRUCTED IN THE RECALL. UPDATED 2/9/2006 - AS OF 2/24/2006 THE VEHICLE HAS NOT BEEN REPAIRED. ON 2/10/06 THE DEALER REPLACED THE TRANSMISSION PRESSURE CONTROL SOLENOID AND REPLACED MASS AIR FLOW SENSOR. *NM
NHTSA ODI #10150918
86,500 miles · Jun 3, 2005
Steering
STEERING BECAME VERY LOOSE AT HIGHER SPEEDS (60 - 70 MPH). DIFFICULT TO MAINTAIN CONTROL.
NHTSA ODI #10124099
3,589 miles · Nov 22, 2004
Electrical SystemEngine And Engine CoolingSteering
POWER STEERING ASSIST (RACK/PINION-LONG SHAFT) UNIT SECOND FAILURE. *BF THE RIGHT REAR WEATHER STRIP WAS DEFORMED, ENGINE STALLED SHORTLY AFTER STARTING, PULSATING NOISE COMING FROM THE FRONT END, TIRE NOISE, RIGHT REAR WINDOW INOPERATIVE, CLUNKING NOISE IN THE FRONT END WHEN TURNING, THE BATTERY LIGHT HAD COME ON FOR 20 MIN…
Read full complaint
POWER STEERING ASSIST (RACK/PINION-LONG SHAFT) UNIT SECOND FAILURE. *BF THE RIGHT REAR WEATHER STRIP WAS DEFORMED, ENGINE STALLED SHORTLY AFTER STARTING, PULSATING NOISE COMING FROM THE FRONT END, TIRE NOISE, RIGHT REAR WINDOW INOPERATIVE, CLUNKING NOISE IN THE FRONT END WHEN TURNING, THE BATTERY LIGHT HAD COME ON FOR 20 MINUTES BUT THE PROBLEM BUT WAS ACTUALLY COOLANT LIGHT, THE ENGINE WOULD CRANK BUT NO START, THE VEHICLE WOULD RUN ROUGH AND DIES, FAILED IGNITION SWITCH, FAILED CRANKSHAFT SENSOR, REMOTE WAS NOT WORKING, LOST POWER STEERING ON A LEFT TURN AND STILL HAD POWER ON RIGHT TURNS, THERE WAS AN OIL LEAK, THERE WAS EXCESSIVE WEAR OF THE INTERMEDIATE STEERING SHAFT, AND EXCESSIVE PLAY IN THE LEFT FRONT HUB AND BEARING ASSEMBLY. *SC
NHTSA ODI #10101807
55,000 miles · Nov 5, 2004
Steering
WHEN TURNING THE VEHICLE IT MADE A LOUD CRUNCHING SOUND WHEN THE WEATHER TURNED COLD. CONSUMER TOOK VEHICLE TO A MECHANIC, WHERE IT WAS DETERMINED THAT THE RACK AND PINION STEERING ASSEMBLY NEEDED TO BE REPLACED. *AK
NHTSA ODI #10099512
66,648 miles · Sep 28, 2004
Steering
AT APPROXIMATELY 66000 MILES MY 1999 OLDSMOBILE INTRIQUE EXPERIENCED STEERING PROBLEMS. IT WOU EXPERIENCE VERY HARD STEERING TO THE LEFT. IT PROGRESSED TO THE POINT THAT THE STEERING RACK HAD TO BE REPLACED AT A COST OF $691. THEY LUBED TO INTERMITTENT STEERING SHAFT AS WELL. THIS MODEL WAS NOT INCLUDED IN THE RECALLS THAT W…
Read full complaint
AT APPROXIMATELY 66000 MILES MY 1999 OLDSMOBILE INTRIQUE EXPERIENCED STEERING PROBLEMS. IT WOU EXPERIENCE VERY HARD STEERING TO THE LEFT. IT PROGRESSED TO THE POINT THAT THE STEERING RACK HAD TO BE REPLACED AT A COST OF $691. THEY LUBED TO INTERMITTENT STEERING SHAFT AS WELL. THIS MODEL WAS NOT INCLUDED IN THE RECALLS THAT WAS SUPPOST TO FIX THIS PROBLEM. THE INTERMEDIATE SHAFT WAS REPLACED UNDER WARRANTY BY OLDMOBILE.*AK
NHTSA ODI #10093242
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.
Consequence & remedy
Consequence: THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.
Remedy: DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.
Oct 5, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.8L V6 ENGINE. SOME OF THESE VEHICLES WERE BUILT WITHOUT A HEATER HOSE CLIP WHICH COULD ALLOW THE HOSE TO SAG AND CONTACT THE OXYGEN SENSOR RESULTING IN A COOLANT LEAK.
Consequence & remedy
Consequence: IF A COOLANT LEAK WERE TO OCCUR, AND LEAKING COOLANT CONTACTED THE HOT EXHAUST MANIFOLD, AN ENGINE COMPARTMENT FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A HEATER HOSE CLIP.
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02005 · Headlamps Dim/flicker
Opened Jan 18, 2002 · Closed Apr 15, 2002
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA99019 · Rear Shoulder Belt Malfunction
Opened Jul 7, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
THE ALLEGED DEFECT CONCERNS TWO MAJOR SYMPTOMS:FAILURE TO RETRACT WEBBING AND INABILITY TO EXTEND THE WEBBINNG FOR USE. THE ROOT CAUSE OF THESE SYMPTOMS IS THE DESIGN OF THE TRIM BEZEL THROUGH WHICH THE SEBBING PASSES. BUILT INTO THE REAR PACKAGE SHELF, THE BEZEL INCLUDES A VERTICAL SLOT TO FACILITATE VEHICLE ASSEMBLY.THE SLOT IS POSITIONED SUCH THAT THE SHOULDER BELT WEBBING TENDS TO SLIP INTO IT.WEBBING INGESTION BY THE VERTICAL SLOT MAY RETARD WEBBING RETRACTION, OR ALLOW WEBBING TWISTS TO ACCUMULATE ON THE RETRACTOR SPOOL.IN EITHER CASE, THE RETRACTOR MAY FAIL TO MAINTAIN APPROPRIATE TENSION ON THE SEAT OCCUPANT.FAILURE OF THE SHOULDER BELT TO COMPLETELY RETRACT MAY ALSO RESULT IN AN INABILITY TO EXTEND IT FOR USE IF THE CHILD RESTRAINT CINCH FEATURE HAS BEEN INADVERTENTLY ENGAGE (BY EXTENDING THE WEBBING TO ITS MAXIMUM LENGTH).GM WILL REMEDY THE ALLEGED DEFECT IN THE SUBJECT VEHICLES BY STRAIGHTENING AN TWISTED REAR SHOULDER BELT WEBBING AND THEM INSTALLING A PLASTIC COVER THAT WILL PREVENT FURTHER WEBBING INGESTION BY THE WEBBING GUIDE VERTICAL SLOT.THIS ENGINEERIGN ANANLYSIS IS CLOSED.
Illustration