IllustrationOUR IGNITION WENT OUT ON OUR CAR, WE PAID $193.58 IN PARTS AND $200 IN LABOR AND THEN IT WAS INVOLVED IN RECALL 14350 AND THEY WON'T REIMBURSE US. *TR
1999 Oldsmobile Intrigue
Owner reports · Recalls · Investigations
More warning signs than most Intrigue years
Owner complaints for the 1999 Oldsmobile Intrigue are substantially higher than the model-year median of 108.
About this comparison →How this year compares
Owner complaints by model year
Compare all Intrigue years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
1025–50K
2450–75K
3075–100K
15100–150K
11150K+
106 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports14 fire reports11 injury reports
What owners actually said
256 reportsTHIS CAR IS AN ELECTRICAL NIGHTMARE. THE INTRIGUE SEEMS TO HAVE SO MANY OF THE SAME ALERO PROBLEMS, BUT NO RESOLUTION FROM GM REGARDING THEM. VEHICLE CONTINUALLY WILL: NOT START, START AND THEN DIE, HAVE THE INSTRUMENT CLUSTER GO HAYWIRE (ALL GAUGES DROP TO THE BOTTOM, THEN JUMP BACK UP, LIGHTS COMING ON THEN GOING OFF - ABS,…
Read full complaint
THIS CAR IS AN ELECTRICAL NIGHTMARE. THE INTRIGUE SEEMS TO HAVE SO MANY OF THE SAME ALERO PROBLEMS, BUT NO RESOLUTION FROM GM REGARDING THEM. VEHICLE CONTINUALLY WILL: NOT START, START AND THEN DIE, HAVE THE INSTRUMENT CLUSTER GO HAYWIRE (ALL GAUGES DROP TO THE BOTTOM, THEN JUMP BACK UP, LIGHTS COMING ON THEN GOING OFF - ABS, CHECK ENGINE, SERVICE ENGINE, ETC) ADDITIONALLY - SECURITY (PASSLOCK) LIGHT WILL COME ON SOMETIMES WHEN THE INSTRUMENT CLUSTER GOES NUTS, AND THEN WILL STAY ON. THIS OFTEN LEADS TO A NO-START CONDITION. IF BATTERY IS DISCONNECTED FOR A FEW MINUTES, THIS WILL USUALLY RESOLVE THE ISSUE. SOMETIMES, WHEN THERE'S A NO-START (NO CRANKING) - TURNING THE CAR TO ACC, AND THEN MOVING THE SHIFTER THROUGH A COUPLE GEARS, WILL RESOLVE THE ISSUE. WHEN THERE'S A NO-START (WITH CRANKING) - THIS CAN EVENTUALLY BE RESOLVED BY DISCONNECTING THE BATTERY FOR A LONG TIME. THE GAUGES GOING CRAZY WHILE DRIVING: OFTEN, WHEN NOT ACTIVELY PRESSING THE ACCELERATOR, THE GAUGES WILL DROP TO THE BOTTOM (EMPTY GAS TANK LIGHT COMES ON, RPM, GAS, AND HEAT NEEDLES DROP TO ZERO; SPEED USUALLY REMAINS FUNCTIONAL). WHEN PRESSING THE ACCELERATOR, THEY ALL POP BACK UP TO FUNCTIONAL (ONLY TO DROP AGAIN WHEN THERE'S NO ACCELERATION). THE KEY - CAN BE TAKEN OUT OF THE IGNITION SWITCH WHILE THE CAR IS RUNNING, WITH NO RESISTANCE. I HAVE REPLACED: BATTERY MULTIPLE TIMES, BATTERY CABLES ONCE, THE IGNITION SWITCH & CYLINDER HAVE BEEN REPLACED AT LEAST ONCE OR TWICE BY A MECHANIC TRYING TO RESOLVE THE ISSUE; WIRING HARNESSES WITHIN THE ENGINE COMPARTMENT AND BELOW THE STEERING WHEEL HAVE BEEN REPLACED. *TR
THE IGNITION SWITCH -- WHICH WAS REPLACED IN 2012 WITH A NEW GM DEALER PART -- TURNS BY ITSELF TO THE ACC SETTING WHILE DRIVING (ENGINE CUTS OUT AND POWER STEERING LOSES POWER). I SUSPECT THAT THIS IS RELATED TO THE GM IGNITION SWITCH RECALL PROBLEM, BUT SINCE THIS MODEL IS NOT ON THE RECALL LIST, I AM ENCOUNTERING A CHALLENGE …
Read full complaint
THE IGNITION SWITCH -- WHICH WAS REPLACED IN 2012 WITH A NEW GM DEALER PART -- TURNS BY ITSELF TO THE ACC SETTING WHILE DRIVING (ENGINE CUTS OUT AND POWER STEERING LOSES POWER). I SUSPECT THAT THIS IS RELATED TO THE GM IGNITION SWITCH RECALL PROBLEM, BUT SINCE THIS MODEL IS NOT ON THE RECALL LIST, I AM ENCOUNTERING A CHALLENGE TO GET IT REPAIRED. PLEASE PHONE ONLY -- NOT AN E-MAIL USER. *TR
THE FAN FOR THE HEAT AND AIR CONDITIONING KEEPS FAILING TO WORK, THE FRONT TURN SIGNAL EITHER BURNS OUT IN 4 DAYS OR WON'T WORK AT ALL EVEN WITH PROFESSIONALLY INSTALLED ALL NEW BULBS.THE ENGINE KEEPS RUNNING EVEN WHEN I REMOVE THE KEY FROM THE IGNITION. *JS
WHEN DRIVING MY 1999 OLDSMOBILE INTRIGUE AT APPROXIMATELY 45MPH I HIT A VERY LARGE POT HOLE IN THE STREET. IT JARRED THE VEHICLE AND SWITCHED THE IGNITION IN MY VEHICLE OFF. I LOST POWER IN THE VEHICLE AND MY ABILITY TO PROPERLY STEER THE VEHICLE. I WAS THANKFULLY IN A LANE WHERE I WAS ABLE TO PULL THE VEHICLE OVER WITHOUT IS…
Read full complaint
WHEN DRIVING MY 1999 OLDSMOBILE INTRIGUE AT APPROXIMATELY 45MPH I HIT A VERY LARGE POT HOLE IN THE STREET. IT JARRED THE VEHICLE AND SWITCHED THE IGNITION IN MY VEHICLE OFF. I LOST POWER IN THE VEHICLE AND MY ABILITY TO PROPERLY STEER THE VEHICLE. I WAS THANKFULLY IN A LANE WHERE I WAS ABLE TO PULL THE VEHICLE OVER WITHOUT ISSUE (POWER STEERING WAS NOT AVAILABLE AND THE WHEEL WAS ALMOST LOCKED AND IT REQUIRED A LOT OF PULLING TO BE ABLE TO PULL OVER) AND RESTART THE CAR. I DID HAVE A LARGE/HEAVY KEY RING ON MY KEYS AT THAT TIME. *TR
MY VEHICLE STARTED TO SMOKE AS I WAS DRIVING HOME. I HAD TO PULL OVER ON SIDE OF THE ROAD. A FRIEND TRAILED ME ABOUT A QUARTER OF A MILE AND WE NOTICED SMOKE AND FLAMES COMING FROM UNDER THE HOOD. MY CAR WENT UP IN FLAMES. *TR
PASS LOCK SYSTEM STARTED TO NOT WORK SPORADICALLY. FROM THEN ON IT JUST GOT WORSE IT WOULD QUIT AT TIMES LEAVING YOU STRANDED FOR PERIODS. *TR
ENGINE AND EVERYTHING ELECTRICAL STOPS INSTANTLY. EVERYTHING SHUTS OFF. DURING RESTART THE VEHICLE CRANKS LONGER (5-6 SECONDS) BEFORE STARTING AND MISSES FOR 3-4 SECONDS. THEN RUNS STRONG AS IF NOTHING HAPPENED. SOME TIMES TURN SIGNALS WILL STOP WORKING AFTER A RESTART AND OTHER TIMES THE TURN SIGNALS WILL STOP WORKING WHET…
Read full complaint
ENGINE AND EVERYTHING ELECTRICAL STOPS INSTANTLY. EVERYTHING SHUTS OFF. DURING RESTART THE VEHICLE CRANKS LONGER (5-6 SECONDS) BEFORE STARTING AND MISSES FOR 3-4 SECONDS. THEN RUNS STRONG AS IF NOTHING HAPPENED. SOME TIMES TURN SIGNALS WILL STOP WORKING AFTER A RESTART AND OTHER TIMES THE TURN SIGNALS WILL STOP WORKING WHETHER THE VEHICLE STALLED OR NOT. AT HIGHER SPEEDS (45MPH +) THE VEHICLE WILL FREQUENTLY SHUT OFF BUT INSTANTLY COME BACK ON. *TR
TL* THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ALIGNMENT FAILED WHILE THE TRACTION CONTROL, CHECK ENGINE AND AVS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE WHEEL SENSOR AND BEARINGS NEEDED TO BE REPLACED. THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ALIGNMENT FAILED WHILE THE TRACTION CONTROL, CHECK ENGINE AND AVS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS ADVISED THAT THE WHEEL SENSOR AND BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 116,000. *TR
TL* THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. THE CONTACT WAS DRIVING 60 MPH AND NOTICED SMOKE COMING FROM THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO STOP AND EXIT THE VEHICLE BEFORE THE VEHICLE BECAME ENGULFED IN FLAMES. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED FOR THE FAILURE. THE CONTACT RECEIVED NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 1999 OLDSMOBILE INTRIGUE. THE CONTACT WAS DRIVING 60 MPH AND NOTICED SMOKE COMING FROM THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO STOP AND EXIT THE VEHICLE BEFORE THE VEHICLE BECAME ENGULFED IN FLAMES. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED FOR THE FAILURE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 09V116000 (ENGINE AND ENGINE COOLING) AND CONTACTED THE MANUFACTURER. THE MANUFACTURER ADVISED THE CONTACT THAT THEY WOULD NOT BE ABLE TO ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 100,000. UPDATED 08/01/12*LJ THE CONSUMER STATED HE DID NOT RECEIVE A RECALL, UNTIL TWO MONTHS AFTER THE FIRE. UPDATED 08/02/12
Official recalls
615V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
00V044000 · Seat Belts
Feb 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.
Consequence & remedy
Consequence: THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.
Remedy: DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.
98V241000 · Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
Oct 5, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.8L V6 ENGINE. SOME OF THESE VEHICLES WERE BUILT WITHOUT A HEATER HOSE CLIP WHICH COULD ALLOW THE HOSE TO SAG AND CONTACT THE OXYGEN SENSOR RESULTING IN A COOLANT LEAK.
Consequence & remedy
Consequence: IF A COOLANT LEAK WERE TO OCCUR, AND LEAKING COOLANT CONTACTED THE HOT EXHAUST MANIFOLD, AN ENGINE COMPARTMENT FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A HEATER HOSE CLIP.
98V102000 · Exterior Lighting:headlights
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02005 · Headlamps Dim/flicker
Opened Jan 18, 2002 · Closed Apr 15, 2002
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA99019 · Rear Shoulder Belt Malfunction
Opened Jul 7, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
THE ALLEGED DEFECT CONCERNS TWO MAJOR SYMPTOMS:FAILURE TO RETRACT WEBBING AND INABILITY TO EXTEND THE WEBBINNG FOR USE. THE ROOT CAUSE OF THESE SYMPTOMS IS THE DESIGN OF THE TRIM BEZEL THROUGH WHICH THE SEBBING PASSES. BUILT INTO THE REAR PACKAGE SHELF, THE BEZEL INCLUDES A VERTICAL SLOT TO FACILITATE VEHICLE ASSEMBLY.THE SLOT IS POSITIONED SUCH THAT THE SHOULDER BELT WEBBING TENDS TO SLIP INTO IT.WEBBING INGESTION BY THE VERTICAL SLOT MAY RETARD WEBBING RETRACTION, OR ALLOW WEBBING TWISTS TO ACCUMULATE ON THE RETRACTOR SPOOL.IN EITHER CASE, THE RETRACTOR MAY FAIL TO MAINTAIN APPROPRIATE TENSION ON THE SEAT OCCUPANT.FAILURE OF THE SHOULDER BELT TO COMPLETELY RETRACT MAY ALSO RESULT IN AN INABILITY TO EXTEND IT FOR USE IF THE CHILD RESTRAINT CINCH FEATURE HAS BEEN INADVERTENTLY ENGAGE (BY EXTENDING THE WEBBING TO ITS MAXIMUM LENGTH).GM WILL REMEDY THE ALLEGED DEFECT IN THE SUBJECT VEHICLES BY STRAIGHTENING AN TWISTED REAR SHOULDER BELT WEBBING AND THEM INSTALLING A PLASTIC COVER THAT WILL PREVENT FURTHER WEBBING INGESTION BY THE WEBBING GUIDE VERTICAL SLOT.THIS ENGINEERIGN ANANLYSIS IS CLOSED.