IllustrationSTEERING BROKE. CAR WAS TOTALLY UNCONTROLLABLE. WENT INTO A STEEP DITCH WITH A MOM AND TWO CHILDREN IN IT. THE FRONT WHEELS WERE FACING OUT LIKE STEERING COLUMN BROKE.
1999 Oldsmobile Intrigue
Owner reports · Recalls · Investigations
More warning signs than most Intrigue years
Owner complaints for the 1999 Oldsmobile Intrigue are substantially higher than the model-year median of 108.
About this comparison →How this year compares
Owner complaints by model year
Compare all Intrigue years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
1025–50K
2450–75K
3075–100K
15100–150K
11150K+
106 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports14 fire reports11 injury reports
What owners actually said
256 reportsTHE ENGINE WILL DIE GOING DOWN THE ROAD AT ANY SPEED, WHICH IS A SAFTY HAZARD. WHEN ENGINE DIES... IT IS VERY HARD TOO STEER AND LOOSES BRAKING POWER. THE ENGINE THEN MAY NOT RESTART FOR SEVERAL MIN. TAKES SEVERAL ATTEMPPS TO GET GOING AGAIN. IF A PERSON HAD TO GET TO A HOSPITAL ON TIME IT COULD MAKE THE DIFFERANCE BETWEEN LIF…
Read full complaint
THE ENGINE WILL DIE GOING DOWN THE ROAD AT ANY SPEED, WHICH IS A SAFTY HAZARD. WHEN ENGINE DIES... IT IS VERY HARD TOO STEER AND LOOSES BRAKING POWER. THE ENGINE THEN MAY NOT RESTART FOR SEVERAL MIN. TAKES SEVERAL ATTEMPPS TO GET GOING AGAIN. IF A PERSON HAD TO GET TO A HOSPITAL ON TIME IT COULD MAKE THE DIFFERANCE BETWEEN LIFE OR DEATH. WE FEEL THIS SHOULD BE FIXED BY GM...FREE...AND SOON!!! THANKS JOHN & DAWN
WITHIN 30 DAYS, THREE OF THE FOUR POWER WINDOWS HAVE FAILED. ESTIMATES ON EACH WINDOW IS BETWEEN $370.00 AND $400.00 DOLLARS. I CAN SEE ONE WINDOW FAILING, BUT THREE WITHIN 30 DAYS IS A STATISTICAL IMPOSSIBILITY. AM AWAITING WORD FROM GM, OLDSMOBILE AND THE DISTRICT SERVICE MANAGER TO SEE WHAT, IF ANYTHING, THEY ARE GOING TO …
Read full complaint
WITHIN 30 DAYS, THREE OF THE FOUR POWER WINDOWS HAVE FAILED. ESTIMATES ON EACH WINDOW IS BETWEEN $370.00 AND $400.00 DOLLARS. I CAN SEE ONE WINDOW FAILING, BUT THREE WITHIN 30 DAYS IS A STATISTICAL IMPOSSIBILITY. AM AWAITING WORD FROM GM, OLDSMOBILE AND THE DISTRICT SERVICE MANAGER TO SEE WHAT, IF ANYTHING, THEY ARE GOING TO DO.
WHEN THE CONSUMER MADE A LEFT TURN, IT WAS DIFFICULT TO STEER BECAUSE THE STEERING WHEEL BECAME STIFF. AT THE SAME TIME VEHICLE STALLED. THE DEALER WAS NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. *JB
1999 OLDSMOBILE INTRIGUE GLS.*MR WHEN THE CONSUMER EXITED THE FREEWAY, HE HEARD A MECHANICAL NOISE WHICH RESULTED IN POWER STEERING LOST FOR LEFT TURNING ONLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE RACK AND PINION WAS REPLACED. THE VEHICLE EXPERIENCED OTHER PROBLEMS SUCH AS ENGINE STALLING SHORTLY AFTER STARTING, TH…
Read full complaint
1999 OLDSMOBILE INTRIGUE GLS.*MR WHEN THE CONSUMER EXITED THE FREEWAY, HE HEARD A MECHANICAL NOISE WHICH RESULTED IN POWER STEERING LOST FOR LEFT TURNING ONLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE RACK AND PINION WAS REPLACED. THE VEHICLE EXPERIENCED OTHER PROBLEMS SUCH AS ENGINE STALLING SHORTLY AFTER STARTING, THE WEATHER STRIP WAS DEFORMED, A PULSATING NOISE COMING FROM THE FRONT END, HOWEVER A ROAD TEST ONLY FOUND TIRE NOISE, THE RIGHT REAR WINDOW WAS INOPERATIVE, THE COOLANT LIGHT ILLUMINATED, THE FUEL PRESSURE REGULATOR WAS REPLACED, THE IGNITION SWITCH WAS REPLACED, THE FUEL FILTER, BATTERY AND REMOTE WERE REPLACED. THE VEHICLE ALSO EXPERIENCED AN OIL LEAK. *JB
WHILE MAKING A LEFT TURN IT WAS DIFFICULT TO STEER, AND THE STEERING WHEEL LOCKED. DEALER INDICATED RACK AND PINION NEEDED TO BE REPLACED.*AK
1999 OLDSMOBILE INTRIGUE - THIS CAR HAS BEEN NOTHING BUT TROUBLE SINCE THE FIRST DAY I PURCHASED IT. THE RACK AND PINION STEERING HAD TO BE REPLACED, THIS DID NOT CORRECT THE PROBLEM WITH LOOSE STEERING, ALONG THE CAR LOSING POWER STEERING AND STALLING. I HAVE BEEN DRIVING ON THE INTERSTATE AT 50-60 MILES AN HOUR, THE CAR WIL…
Read full complaint
1999 OLDSMOBILE INTRIGUE - THIS CAR HAS BEEN NOTHING BUT TROUBLE SINCE THE FIRST DAY I PURCHASED IT. THE RACK AND PINION STEERING HAD TO BE REPLACED, THIS DID NOT CORRECT THE PROBLEM WITH LOOSE STEERING, ALONG THE CAR LOSING POWER STEERING AND STALLING. I HAVE BEEN DRIVING ON THE INTERSTATE AT 50-60 MILES AN HOUR, THE CAR WILL CUT OFF ON YOU. I MAKE A HABIT TO DRIVE IN THE RIGHT LANE, SO THAT I CAN PULL OVER AND STALL OUT ON THE SIDE OF THE ROAD. I TRY AND STAY OFF THE INTERSTATE BECAUSE IF A TRUCK OR BAD DRIVER IS BEHIND ME THAT COULD REALLY CAUSE PROBLEMS (ACCIDENT/DEATH). I HAVE HAD MAJOR MECHANICAL REPAIRS DONE TO THIS CAR, NOTHING HELPS. I CAN NOT AFFORD TO AT THIS MOMENT GET ANOTHER CAR BUT AS SOON AS I AM ABLE I AM GOING TO GET RID OF IT. GENERAL MOTORS SHOULD NOT HAVE BEEN ALLOW TO SELL THIS TYPE OF DANGEROUS PRODUCT TO THE PUBLIC. THESE INCIDENTS ARE STILL GOING ON PROBLEM. THE LATEST BEING YESTERDAY, I SUDDENLY LOST MY POWER STEERING WHILE DRIVING. *LA
SO MUCH FOR INVESTING IN AMERICAN-MADE VEHICLES. I, LIKE OVER A DOZEN OTHERS WHO TOOK THE TIME TO FILE A COMPLAINT, AM EXPERIENCING THE FLICKER AND DIM OF ALL LIGHTING DURING THE EVENING HOURS - ESPECIALLY WHEN THE WEATHER'S COLDER. IT IS UNNERVING TO ME, AND I'M SURE TO THOSE DRIVERS AROUND ME, TO DRIVE WITH QUESTIONABLE EXTE…
Read full complaint
SO MUCH FOR INVESTING IN AMERICAN-MADE VEHICLES. I, LIKE OVER A DOZEN OTHERS WHO TOOK THE TIME TO FILE A COMPLAINT, AM EXPERIENCING THE FLICKER AND DIM OF ALL LIGHTING DURING THE EVENING HOURS - ESPECIALLY WHEN THE WEATHER'S COLDER. IT IS UNNERVING TO ME, AND I'M SURE TO THOSE DRIVERS AROUND ME, TO DRIVE WITH QUESTIONABLE EXTERIOR LIGHTING. AND, AS OTHERS HAVE SAID, GM DOES NOT VIEW THIS AS A "SAFETY ISSUE". WHAT SAY THEY HAVE THEIR SPOUSE, OR THEIR CHILD, DRIVE A VEHICLE WITH THIS SAME "NOT A SAFETY ISSUE" AND SEE IF THEIR VIEW DOESN'T CHANGE? I WORK, AND WITH DAYLIGHT SAVINGS TIME, THIS MEANS I AM TRAVELLING HOME IN THE DARK -- WITH MY ONE-YEAR-OLD AND NINE-YEAR-OLD IN THE CAR WITH ME. NONE OF THIS MATTERS TO THE FOLKS AT GM. BECAUSE THEY CAN POINT TO THE AGE AND MILEAGE OF THE VEHICLE TO GET THEM OFF THE HOOK, THEY ARE. THE FACT THAT THEY ISSUED A "BULLETIN" REGARDING THIS ISSUE IN FEB01 DOESN'T SEEM TO MATTER. $650+LABOR FOR A NEW ALTERNATOR MAY OR MAY NOT RESOLVE THE ISSUE, BUT THAT, APPARENTLY IS MY MONEY TO INVEST IN A POSSIBLE, BUT NOT GUARANTEED, SOLUTION. JUDGING FROM THE OTHER FILINGS HERE, IT DOESN'T SOUND TOO PROMISING, SO I'M LEFT WITH THE DEBATE OF DUMP THIS MONEY TO *MAYBE* FIX THE PROBLEM OR LET IT BE UNTIL SOMETHING BAD HAPPENS? MY CAR IS TOO OLD AND HAS TOO MANY MILES FOR THIS TO BE CONSIDERED SOMETHING FOR WHICH THEY, GM, WILL ASSUME RESPONSIBILITY. I WILL NEVER BUY GM AGAIN.*AK
THE WINDOW HAD FALLEN INTO THE DOOR ON THE DRIVERS SIDE FRONT, BACK AND PASSENGER DOOR WITH NO WARNING. ON ONE OCCASION, WHILE THE CONSUMER WAS DRIVING ON THE HIGHWAY WITH HER GRANDDAUGHTER IN THE PASSENGER SEAT, THE WINDOW HAD FALLEN INTO THE DOOR. THE DEALER STATED THAT THIS WAS A COMMON PROBLEM. WHEN THE POWER WINDOW NO LO…
Read full complaint
THE WINDOW HAD FALLEN INTO THE DOOR ON THE DRIVERS SIDE FRONT, BACK AND PASSENGER DOOR WITH NO WARNING. ON ONE OCCASION, WHILE THE CONSUMER WAS DRIVING ON THE HIGHWAY WITH HER GRANDDAUGHTER IN THE PASSENGER SEAT, THE WINDOW HAD FALLEN INTO THE DOOR. THE DEALER STATED THAT THIS WAS A COMMON PROBLEM. WHEN THE POWER WINDOW NO LONGER WORKED, IT WOULD FALL INTO THE DOOR. *SCC *JB
VEHICLE ENGINE SHUTS OFF AT SPEEDS BETWEEN 35-65 MPH RESULTING IN LOSS OF STEERING CAPABILITIES. WHICH IS A POSSIBLE CAUSE OF ACCIDENT ON 7/5/03 THAT RESULTED IN DEATH AND INJURY. *LA
Official recalls
615V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
00V044000 · Seat Belts
Feb 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.
Consequence & remedy
Consequence: THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.
Remedy: DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.
98V241000 · Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
Oct 5, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.8L V6 ENGINE. SOME OF THESE VEHICLES WERE BUILT WITHOUT A HEATER HOSE CLIP WHICH COULD ALLOW THE HOSE TO SAG AND CONTACT THE OXYGEN SENSOR RESULTING IN A COOLANT LEAK.
Consequence & remedy
Consequence: IF A COOLANT LEAK WERE TO OCCUR, AND LEAKING COOLANT CONTACTED THE HOT EXHAUST MANIFOLD, AN ENGINE COMPARTMENT FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A HEATER HOSE CLIP.
98V102000 · Exterior Lighting:headlights
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02005 · Headlamps Dim/flicker
Opened Jan 18, 2002 · Closed Apr 15, 2002
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA99019 · Rear Shoulder Belt Malfunction
Opened Jul 7, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
THE ALLEGED DEFECT CONCERNS TWO MAJOR SYMPTOMS:FAILURE TO RETRACT WEBBING AND INABILITY TO EXTEND THE WEBBINNG FOR USE. THE ROOT CAUSE OF THESE SYMPTOMS IS THE DESIGN OF THE TRIM BEZEL THROUGH WHICH THE SEBBING PASSES. BUILT INTO THE REAR PACKAGE SHELF, THE BEZEL INCLUDES A VERTICAL SLOT TO FACILITATE VEHICLE ASSEMBLY.THE SLOT IS POSITIONED SUCH THAT THE SHOULDER BELT WEBBING TENDS TO SLIP INTO IT.WEBBING INGESTION BY THE VERTICAL SLOT MAY RETARD WEBBING RETRACTION, OR ALLOW WEBBING TWISTS TO ACCUMULATE ON THE RETRACTOR SPOOL.IN EITHER CASE, THE RETRACTOR MAY FAIL TO MAINTAIN APPROPRIATE TENSION ON THE SEAT OCCUPANT.FAILURE OF THE SHOULDER BELT TO COMPLETELY RETRACT MAY ALSO RESULT IN AN INABILITY TO EXTEND IT FOR USE IF THE CHILD RESTRAINT CINCH FEATURE HAS BEEN INADVERTENTLY ENGAGE (BY EXTENDING THE WEBBING TO ITS MAXIMUM LENGTH).GM WILL REMEDY THE ALLEGED DEFECT IN THE SUBJECT VEHICLES BY STRAIGHTENING AN TWISTED REAR SHOULDER BELT WEBBING AND THEM INSTALLING A PLASTIC COVER THAT WILL PREVENT FURTHER WEBBING INGESTION BY THE WEBBING GUIDE VERTICAL SLOT.THIS ENGINEERIGN ANANLYSIS IS CLOSED.