NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
9 reportsClear category filter154,000 miles · Oct 26, 2007
Visibility
1) THE FAILURE OCCURRED UNDER NORMAL USE OF WIPERS IN HEAVY RAIN. 2) DURING NORMAL USE, THE PASSENGER SIDE WIPER ARM APPEARED TO BECOME DISLODGED AND BEGAN MOVING ERRATICALLY. AFTER INSPECTION OF THE WIPER ASSEMBLY IT WAS DISCOVERED THAT THE PLASTIC HOUSING THAT HOLDS THE WIPER ARM TO THE WIPER MOTOR WAS CRACKED AND BROKEN AWA…
Read full complaint
1) THE FAILURE OCCURRED UNDER NORMAL USE OF WIPERS IN HEAVY RAIN. 2) DURING NORMAL USE, THE PASSENGER SIDE WIPER ARM APPEARED TO BECOME DISLODGED AND BEGAN MOVING ERRATICALLY. AFTER INSPECTION OF THE WIPER ASSEMBLY IT WAS DISCOVERED THAT THE PLASTIC HOUSING THAT HOLDS THE WIPER ARM TO THE WIPER MOTOR WAS CRACKED AND BROKEN AWAY FROM THE LINKAGE TO THE WIPER MOTOR. THE CONSEQUENCES OF THIS FAILURE IS THAT NEITHER WIPER ARM OPERATES AND THIS CAUSES HAZARDOUS DRIVING CONDITIONS BY REDUCING VISIBILITY DURING RAIN OR FROST. 3) AFTER RESEARCHING THIS APPARENT DEFECT IN THE MANUFACTURERS ORIGINAL PART, I DISCOVERED AN OPEN RECALL IS ALREADY IN EFFECT FOR THIS PARTICULAR YEAR, MAKE, AND MODEL (NHTSA CAMPAIGN ID# 01V068000). THE DESCRIPTION UNDER THIS RECALL IS IDENTICAL TO THE PROBLEM I ENCOUNTERED AND IS FOR THE SAME VEHICLE. I CONTACTED THE MANUFACTURER, GM-OLDSMOBILE, AND THE OPEN RECALL WAS VERIFIED, BUT I WAS TOLD MY PARTICULAR VIN# WAS NOT ON THEIR LIST. I WAS TOLD THAT IF GM HAPPENS TO ADD OTHER VEHICLES FROM THE SAME YEAR, MAKE, AND MODEL TO THE LIST THEN I WOULD BE NOTIFIED, BUT NO REPAIRS WOULD BE OFFERED. *TR
NHTSA ODI #10206993
15,000 miles · Jul 26, 2005
Visibility
RECALL CAMPAIGN#01V068000 WINDSHIELD WIPER LINKAGE BREAKAGE WILL NOT COVER MY BREAKAGE BECAUSE I AM IN A SOUTHERN STATE, MY VIN IS NOT ON THEIR RACALL LIST.
NHTSA ODI #10130080
Mileage unknown · Mar 13, 2005
Electrical SystemEngine And Engine CoolingEquipment
I CURRENTLY HAVE THE FOLLOWING PROBLEMS WITH MY 1998 OLDS CUTLASS GL. MY POWER STEERING IS STIFF AND MAKES A "WAILING" NOISE. MY COOLENT SYSTEM HAS A LEAK. MY HEAT AND AIR HAVE COMPLETEY STOPPED WORKING. I HAVE HAD PROBLEMS (IN THE PAST THAT HAVE BEEN REPAIRED_ WITH MY POWER WINDOW LOCKING UP (DRIVERS SIDE). THE SOUND SYSTEM S…
Read full complaint
I CURRENTLY HAVE THE FOLLOWING PROBLEMS WITH MY 1998 OLDS CUTLASS GL. MY POWER STEERING IS STIFF AND MAKES A "WAILING" NOISE. MY COOLENT SYSTEM HAS A LEAK. MY HEAT AND AIR HAVE COMPLETEY STOPPED WORKING. I HAVE HAD PROBLEMS (IN THE PAST THAT HAVE BEEN REPAIRED_ WITH MY POWER WINDOW LOCKING UP (DRIVERS SIDE). THE SOUND SYSTEM SHORTED OUT. THE CD PLAYER QUIT WORKING. I HAVE REPLACED MY WIPER BLADES SEVERAL TIMES AND THEY STILL DO NOT CLEAR THE WINDSHIELD COMPLETELY. ONE TIME WHEN MY TEENS WERE USING MY CAR, THEY WERE ON THE INTERSTATE AND THE CAR WENT COMPLETELY DEAD...NOT ONLY WERE THEY TERRIFIED, IT WAS A VERY DANGEROUS SITUATION FOR THEM TO BE IN.*AK
NHTSA ODI #10114007
71,000 miles · Apr 30, 2004
Visibility
WHILE DRIVING AT 30 MPH ON A DOWN POUR, THE WINDSHIELD WIPERS STOPPED WORKING. THE WIPERS BEGAN TO WORK OUT OF SYNCH AND ENDED CROSSED UP ON THE WINDSHIELD. HAD TO REPLACE THE WIPER TRANSMISSION. NO RECALL NOTICE WAS RECEIVED. *LA
NHTSA ODI #10071935
Mileage unknown · Apr 23, 2002
Visibility
WHILE STARTING VEHICLE ENGINE IS RELEASING STRONG FUMES THROUGHT VENTS OF VEHICLE. DEALER HAS BEEN NOTIFIED; HOWEVER, HAS NOT BEEN ABLE TO FIND THE CAUSE. *AK
NHTSA ODI #8008428
Mileage unknown · Oct 26, 2001
Visibility
CONSUMER BROUGHT VEHICLE IN FOR INOPERATIVE RIGHT SIDE WINDSHIELD WIPER, DEALERSHIP REPLACED WIPER BLADE ASSEMBLIES AND ADJUSTED LEFT AND RIGHT WIPER ARMS, CONSUMER RECEIVED RECALL NOTICE, 01014S, AFTER REPAIRS WERE PERFORMED, BUT DEALERSHIP STATED THAT REPAIR WAS NOT COVERED BY RECALL, CONSUMER IS REQUESTING REIMBURSEMENT. *T…
Read full complaint
CONSUMER BROUGHT VEHICLE IN FOR INOPERATIVE RIGHT SIDE WINDSHIELD WIPER, DEALERSHIP REPLACED WIPER BLADE ASSEMBLIES AND ADJUSTED LEFT AND RIGHT WIPER ARMS, CONSUMER RECEIVED RECALL NOTICE, 01014S, AFTER REPAIRS WERE PERFORMED, BUT DEALERSHIP STATED THAT REPAIR WAS NOT COVERED BY RECALL, CONSUMER IS REQUESTING REIMBURSEMENT. *TT
NHTSA ODI #563795
Mileage unknown · May 27, 2001
Visibility
I WAS DRIVING ON ROUTE 9, A MAJOR HIGHWAY HERE IN THE CITY OF POUGHKEEPSIE AND I HAD MYWINDSHIELD WIPERS ON BECAUSE IT WAS RAINING. SUDDENLY THE PASSENGER SIDE WIPER ARM STOPPED MOVING, CAUSING THE DRIVER SIDE WIPER TO MOVE ACROSS IT FORMING AN 'X' ACROSS THE WINDSHIELD. THE WIPER SYSTEM STALLED AND I COULDN'T SEE THROUGH THE …
Read full complaint
I WAS DRIVING ON ROUTE 9, A MAJOR HIGHWAY HERE IN THE CITY OF POUGHKEEPSIE AND I HAD MYWINDSHIELD WIPERS ON BECAUSE IT WAS RAINING. SUDDENLY THE PASSENGER SIDE WIPER ARM STOPPED MOVING, CAUSING THE DRIVER SIDE WIPER TO MOVE ACROSS IT FORMING AN 'X' ACROSS THE WINDSHIELD. THE WIPER SYSTEM STALLED AND I COULDN'T SEE THROUGH THE WINDSHIELD AGAIN. LUCKILY THERE WASN'T TOO MUCH TRAFFIC AT THE TIME AND I WAS LUCKY ENOUGH TO PULL OUT OF THE ROAD WITHOUT CRASHING INTO ANYTHING. I HAD SEEN EARLIER IN THIS WEBSITE THAT THERE IS OR SUPPOSED TO BE A RECALL ON THE 98 CUTLASSES FOR THEIR DEFECTIVE WIPER SYSTEMS AND I'VE BEEN WAITING FOR A RECALL NOTE BUT I HAVEN'T RECIEVED ONE YET. MY QUESTION IS, IS MY DEALER REQUIRED TO PERFORM THE REPAIR/REPLACEMENT FOR FREE OR AM I REQUIRED TO PAY FOR THE SERVICE? *AK
NHTSA ODI #745967
Mileage unknown · Jan 9, 2001
Visibility
WHEN START USING DEFROSTER FOR WINDOWS SOME TYPE OF FIBER IS BLOWING FROM VENTS, CAUSING CONSUMER TO OPEN WINDOWS IN COLD INORDER NOT TO INHALE VAPOR. *AK
NHTSA ODI #877787
Mileage unknown · Oct 26, 1998
Visibility
DRIVER SIDE MIRROR VIBRATES NOTICEABLY AT ALL SPEEDS. DEALER ADJUSTED THE MIRROR ONCE & REPLACE THE MIRROR ASSEMBLY ONCE. THE MIRROR STILL VIBRATES.
NHTSA ODI #700100
Official recalls
2Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA99030 · Oversensitive Air Bag Deployment
Opened Oct 29, 1999 · Closed Mar 25, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE99037 · Inadvertent Air Bag Deployments
Opened May 19, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
Illustration