MY FRONT PASS DOOR LOCKED AND COULD NOT BE OPENNED UNTIL THE SERVICE DEPT TOOK THE INSIDE DOOR PANEL OFF. I ASKED THEM WHAT WOULD I DO IN AN ACCIDENT ? I PAID TO REPLACE PART THAT FAILED. CALLED OLDS EDGE HOT LINE AND THEY DIDN'T SEEM TO CONCERNED. AFTER MORE THOUGHT, I PAID TO HAVE THE DRIVER'S SIDE REPLACED. THAT HAPPENED…
Read full complaint
MY FRONT PASS DOOR LOCKED AND COULD NOT BE OPENNED UNTIL THE SERVICE DEPT TOOK THE INSIDE DOOR PANEL OFF. I ASKED THEM WHAT WOULD I DO IN AN ACCIDENT ? I PAID TO REPLACE PART THAT FAILED. CALLED OLDS EDGE HOT LINE AND THEY DIDN'T SEEM TO CONCERNED. AFTER MORE THOUGHT, I PAID TO HAVE THE DRIVER'S SIDE REPLACED. THAT HAPPENED IN 1997 BUT SINCE I'M AWAY FROM HOME, I DON'T HAVE TRUE MILEAGE AND DATES OF OCCURRENCES. I FEEL THIS IS AS SERIOUS FAILURES AS THE BACK SEAT BELTS NOT WORKING NHTSA 00V057000. IMAGINE YOURSELF IN A CAR IN AN ACCIDENT AND THE DOOR LOCKS. FORTUNATELY, NOW I KNOW WHAT TO DO WHEN THIS HAPPENS TO ME. IT'S SCARY THE FIRST TIME IT HAPPENS. EVEN THE MECHANICS AT OLDS WERE PUZZLED BY IT. LAST MONTH, MY DRIVER DOOR STARTED LOCKING, AND IT LOCKED AGAIN YESTERDAY. SINCE I'M AWAY FROM HOME, I HAVEN'T GOT IT REPAIRED AGAIN. BELIEVE ME THIS IS VERY SERIOUS SINCE THE NUMBER OF ACCIDENTS AND MY DRIVING IS ALMOST 100% EXPRESSWAY DRIVING. *AK
NHTSA ODI #723081
Mileage unknown · Oct 20, 1997
Electrical SystemStructure
DRIVER UNABLE TO USE HORN BECAUSE OF ITS POSITION WITH THE AIR BAG. YH
NHTSA ODI #605533
Mileage unknown · Mar 21, 1997
Structure
CENTER CONSOLE SHIFT INDICATOR IS HARD TO READ DURING THE DAY, DRIVER HAS TO TAKE HIS EYES OFF THE ROAD TO LOOK AT CENTER SHIFT INDICATOR. AT NIGHT, THE CONSOLE SHIFT INDICATOR IS ALMOST IMPOSSIBLE TO READ. *AK
NHTSA ODI #515335
Mileage unknown · Jun 21, 1996
Structure
TRUNK DOESN'T HAVE HANDLE, HARD TO OPEN, DOESN'T POP UP. *AK
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR SHOULDER BELT(S) DO NOT RETRACT. A RETAINER COULD SEPARATE FROM A REAR SEAT SHOULDER BELT RETRACTOR WHICH RESULTS IN THE RETRACTOR RETURN SPRING BECOMING DISENGAGED.
Consequence & remedy
Consequence: IN A CRASH, AN OCCUPANT MAY RECEIVE MORE SEVERE INJURIES IF THERE IS EXCESSIVE SLACK IN THE SHOULDER BELT.
Remedy: DEALERS WILL INSPECT BOTH REAR SHOULDER BELT RETRACTORS FOR CORRECT FUNCTION AND INSTALL A SPRING COVER RETAINING STRAP TO EACH RETRACTOR. IF A RETRACTOR DOES NOT FUNCTION CORRECTLY, IT WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA00006 · Rear Seat Belt Retractor
Opened Feb 22, 2000 · Closed Mar 6, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
IN ITS LETTER DATED FEBRUARY 25, 2000 TO NHTSA, GENERAL MOTORS STATED THAT IT WILL CONDUCT A SAFETY RECALL OF 85,253 MODEL YEAR 1995 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES FOR THE DEFECT IN THE OUTBOARD REAR SEAT BELT RETRACTOR ASSEMBLIES.
PE99059 · Rear Seat Belt Retractor
Opened Sep 15, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
COMPLAINTS GENERALLY STATED THAT ONE OR BOTH OUTBOARD REAR SEAT BELTS DO NOT RETRACT AT ALL AND ARE USELESS.IT IS EVIDENT THAT THE SEAT BELTS DO NOT PROVIDE ANY TENSION AND HAVE EXCESS SLACK.THE RETRACTOR ASSEMBLY HAS A PLASTIC COVER NEXT TO THE RETRACTOR RETURN SPRING.ACCORDING TO GENERAL MOTORS (GM), HEAT MAY SOFTEN, WARP AND DEFLECT THE PLASTIC SPRING COVER ALLOWING THE RETURN SPRING TO DISENGAGE THROUGH AND JAM IN THE SPRING COVER ACCESS HOLE RENDERING THE RETURN SPRING NONFUNCTIONAL.TO ELIMANATE THE PROBLEM, GM CHANGED THE SPRING COVER MATERIAL AND ACCESS HOLE AT THE BEGINNING OF PRODUCTION OF MODEL YEAR (MY) 1996 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES.BOTH COMPLAINTS AND WARRANTY CLAIMS HAVE DECLINED SIGNIFICANTLY FROM MY 1995 SUBJECT VEHICLES TO MY 1996 VEHICLES.
SQ96012 · Rear Compartment Lid Rod Separation
Opened Jun 25, 1996 · No close date supplied
Status: open (inferred from source dates) · Structure
ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.
1995 Oldsmobile Aurora Problems, Complaints & Recalls | Skip That Year
Illustration