NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
10 reportsClear category filter70,000 miles · Oct 8, 2006
Service Brakes, Hydraulic
THIS IS A 1995 OLDSMOBILE AURORA. I AM THE ORIGINAL OWNER. THE CAR HAS LESS THAN 70K MILES, HAS BEEN GARAGED AND HAS NOT BEEN IN ANY ACCIDENTS. AFTER DRIVING IN WINTER STORMS THE CAR WAS ALWAYS WASHED UNDER THE CHASSIS IN THE CAR WASH TO REMOVE SALT. ON 10/5/2006, AS I WAS PULLING OUT OF THE GARAGE, THE BRAKE PEDAL FELT TOTALLY…
Read full complaint
THIS IS A 1995 OLDSMOBILE AURORA. I AM THE ORIGINAL OWNER. THE CAR HAS LESS THAN 70K MILES, HAS BEEN GARAGED AND HAS NOT BEEN IN ANY ACCIDENTS. AFTER DRIVING IN WINTER STORMS THE CAR WAS ALWAYS WASHED UNDER THE CHASSIS IN THE CAR WASH TO REMOVE SALT. ON 10/5/2006, AS I WAS PULLING OUT OF THE GARAGE, THE BRAKE PEDAL FELT TOTALLY SOFT AND THE CAR STOPPED WITH DIFFICULTY AFTER PUMPING THE BRAKES MANY TIMES, ETC. OUR GARAGE HAS A HIGH SLOPE INTO THE STREET. I PULLED THE CAR SLOWLY BACK INTO THE GARAGE AND OBSERVED BRAKE FLUID ON MY DRIVEWAY. I RAISED THE CAR ON JACKS AND I INSPECTED THE UNDERBODY. THE BRAKE FLUID LINES GOING TOWARDS THE BACK WHEELS ARE HEAVILY CORRODED AND A SPOT WAS LEAKING HEAVILY. I HAVE OWNED SEVERAL CARS IN THE PAST AND KEPT THEM FOR MANY YEARS AND HIGH MILEAGE BUT I NEVER FACED SUCH A SERIOUS SAFETY ISSUE. IMAGINE IF I WAS DRIVING ON THE HIGHWAY, AT 65 MILES/HOUR!*JB
NHTSA ODI #10170243
27,500 miles · Jul 11, 2003
Service Brakes, Hydraulic
BRAKES COMLPETELY FAILED WITHOUT WARNING DRIVING DOWN THE HIGHWAY.*AK
NHTSA ODI #10025895
Mileage unknown · Jan 29, 2001
Engine And Engine CoolingExterior LightingPower TrainCrashInjury
FIVE DAYS AFTER THE PURCHASE RADIATOR CRACKED, CAR OVERHEATED, TOOK TO DEALERSHIP, WHILE SPEAKING WITH THE SERVICE MANAGER, I EXPLAINED THE ABS/TRACTION CONTROL LIGHT CAME ON AND STAYS ON AS OF 3RD DAY AFTER PURCHASE AND THAT THE ENGINE WAS SURGING AND BACK FIRE TYPE NOISE FROM UNDER THE HOOD DURING ACCELERATION AND THE CAR HAD …
Read full complaint
FIVE DAYS AFTER THE PURCHASE RADIATOR CRACKED, CAR OVERHEATED, TOOK TO DEALERSHIP, WHILE SPEAKING WITH THE SERVICE MANAGER, I EXPLAINED THE ABS/TRACTION CONTROL LIGHT CAME ON AND STAYS ON AS OF 3RD DAY AFTER PURCHASE AND THAT THE ENGINE WAS SURGING AND BACK FIRE TYPE NOISE FROM UNDER THE HOOD DURING ACCELERATION AND THE CAR HAD NO POWER. THE FRONT RIGHT FOG LIGHT WAS NOT WORKING THE DAY OF PURCHASE AND TO REPLACE IT, I WAS CHARGED FOR THE REPLACEMENT BULB. THERE WAS NO BUYERS GUIDE ON THIS VEHICLE ON THE DAY I TEST DROVE THE CAR NOR ON THE DAY OF PURCHASE, I PURCHASED A ONE YEAR EXTENDED WARRANTY THROUGH THE DEALERSHIP IN THE AMOUNT OF $1295.00, AND WAS TOLD IT COVERED EVERYTHING. SERVICE MANAGER WAS CONTACTED ON THE DAY I PICKED THE CAR UP AFTER THE RADIATOR REPAIR, AND WAS TOLD THE OTHER ISSUES WERE NOT CORRECTED AT THIS TIME DUE TO THE WARRANTY NOT HAVING TIME TO PROCESS. A FEW HOURS LATER, I CALLED THE SERVICE MANAGER TO REPORT THAT THE CAR WAS RUNNING HOT , SMOKING FROM UNDER THE HOOD AND HE BLEW IT OFF AS COOLANT BURNOFF AND IF IT CONTINUED TO RETURN IT ON THE FOLLOWING MONDAY, THIS WAS ON A FRIDAY. WAS INVOLVED IN ACCIDENT THAT SAME FRIDAY NIGHT, YET IT WAS MINOR AND I DROVE THE CAR HOME FROM THE SCENE. I DROVE TO A REPAIR FACILITY ON MONDAY, AND THERE IS WHEN I WAS INFORMED THAT THE RADIATOR REPAIR FROM THE PREVIOUS WEEK WAS NOT DONE AND PICTURES WERE TAKEN AND I MET WITH THE SALES MANAGER AND SHOWED HIM THE PICTURES, YET HE STILL INSISTED THE REPAIR WAS DONE, I E-MAILED THE PHOTOS TO GM AND OLDSMOBILE WITH MY COMPLAINT. NO RESPONSE TO THIS DAY 01/29/01. *AK
NHTSA ODI #740105
Mileage unknown · Jan 3, 2001
Fuel System, OtherService Brakes, Hydraulic
A NARROW STREM OF FUEL WAS SPRAYING FROM ONE OF THE PLASTIC FUEL LINES UNDER THE HOOD CAUSING FUEL ODOR INSIDE THE VEHICLE. NLM
NHTSA ODI #558753
Mileage unknown · Aug 30, 2000
EquipmentExterior LightingFuel System, Gasoline
HEADLIGHTS FLICKER OR BLINK LIKE FLASHERS WHILE DRIVING. FUEL INJECTION SYSTEM SEEMS NOT TO BE GETTING NECESSARY FUEL AT ALL TIMES. PAINT HAS BEEN PEELING ON THE MOLDING AND I HAVE BEEN NOTICING SPOTS IN THE PAINT MORE AND MORE EVERY WEEK. HAD PROBLEM WITH ANTI-LOCK BRAKING SYSTEM MADE LOUD NOISES AND MALFUNCTIONED WHILE DRIVING…
Read full complaint
HEADLIGHTS FLICKER OR BLINK LIKE FLASHERS WHILE DRIVING. FUEL INJECTION SYSTEM SEEMS NOT TO BE GETTING NECESSARY FUEL AT ALL TIMES. PAINT HAS BEEN PEELING ON THE MOLDING AND I HAVE BEEN NOTICING SPOTS IN THE PAINT MORE AND MORE EVERY WEEK. HAD PROBLEM WITH ANTI-LOCK BRAKING SYSTEM MADE LOUD NOISES AND MALFUNCTIONED WHILE DRIVING. TRANSMISSION SHUT DOWN ON THE INTERSTATE WAS DRIVING 70MPH THEN ALLL OF A SUDDEN IT SHUT DOWN TO 35MPH AND IT WOULDN'T GO ANY FASTER. AIR CONDITION VENTS ARE STUCK IN CLOSE POSITION AND SOME OF THEM ARE NOT GETTING AIR THROUGH THEM AT ALL.
NHTSA ODI #729505
Mileage unknown · Jul 22, 1999
Power TrainService Brakes, HydraulicCrashInjury
ABS/TC DID NOT ALLOW ME TO STOP IN TIME AND I HIT THE VEHICLE IN FRONT OF ME. NOW THE TRACTION OFF LIGHT ILLUMINATES CONSTANTLY (> 40 MPH IT ENABLES THE FAULT) AND THE INSURANCE COMPANY WILL NOT PAY TO HAVE THE BPMV REPLACED.*AK
NHTSA ODI #708987
Mileage unknown · Jan 8, 1999
Engine And Engine CoolingService Brakes, Hydraulic
CHECK ENGINE LIGHT COMES ON DAILY ( DEALER CANT FIND REASON) MASTER CYLINDER LEAKING, REPLACEMENT OF DIRVERSIDE ENGINE MOUNT,(MOTER ACCELARATES TO HIGH RPM WHEN STARTED, CD PLAYED FAILED,TRANMISSION FAILED CYLINDER REPLACED.
NHTSA ODI #702001
Mileage unknown · Sep 15, 1998
Service Brakes, Hydraulic
MASTER CYLINDER LEAKING.
NHTSA ODI #541472
Mileage unknown · Sep 12, 1998
Electrical SystemEngine And Engine CoolingPower Train
SEAT BELTS/TRANSMISSION/ABS BRAKES/ STARTER FAILED. ALSO ENGINE CONTINUOUSLY OVERHEATED.
NHTSA ODI #540791
Mileage unknown · Jan 30, 1996
Service Brakes, Hydraulic
WHEN APPLY THE BRAKE IT FEELS LIKE THERE'S NO POWER HAVE ABS ANTI-LOCK BRAKE . TT
NHTSA ODI #978415
NHTSA investigations
5EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA00006 · Rear Seat Belt Retractor
Opened Feb 22, 2000 · Closed Mar 6, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
IN ITS LETTER DATED FEBRUARY 25, 2000 TO NHTSA, GENERAL MOTORS STATED THAT IT WILL CONDUCT A SAFETY RECALL OF 85,253 MODEL YEAR 1995 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES FOR THE DEFECT IN THE OUTBOARD REAR SEAT BELT RETRACTOR ASSEMBLIES.
PE99059 · Rear Seat Belt Retractor
Opened Sep 15, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
COMPLAINTS GENERALLY STATED THAT ONE OR BOTH OUTBOARD REAR SEAT BELTS DO NOT RETRACT AT ALL AND ARE USELESS.IT IS EVIDENT THAT THE SEAT BELTS DO NOT PROVIDE ANY TENSION AND HAVE EXCESS SLACK.THE RETRACTOR ASSEMBLY HAS A PLASTIC COVER NEXT TO THE RETRACTOR RETURN SPRING.ACCORDING TO GENERAL MOTORS (GM), HEAT MAY SOFTEN, WARP AND DEFLECT THE PLASTIC SPRING COVER ALLOWING THE RETURN SPRING TO DISENGAGE THROUGH AND JAM IN THE SPRING COVER ACCESS HOLE RENDERING THE RETURN SPRING NONFUNCTIONAL.TO ELIMANATE THE PROBLEM, GM CHANGED THE SPRING COVER MATERIAL AND ACCESS HOLE AT THE BEGINNING OF PRODUCTION OF MODEL YEAR (MY) 1996 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES.BOTH COMPLAINTS AND WARRANTY CLAIMS HAVE DECLINED SIGNIFICANTLY FROM MY 1995 SUBJECT VEHICLES TO MY 1996 VEHICLES.
SQ96012 · Rear Compartment Lid Rod Separation
Opened Jun 25, 1996 · No close date supplied
Status: open (inferred from source dates) · Structure
ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.
Illustration