NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
39 reportsClear category filter133,389 miles · May 13, 2005
Engine And Engine CoolingPower TrainSteering
1995 OLDSMOBILE AURORA EXPERIENCING PROBLEMS WITH STEERING WHEEL.*MR...CONSUMER TOOK VEHICLE TO PREMIER AUTOMOTIVE SERVICES , AND THEY RECOMMENDED THE REPLACEMENT OF STEERING RACK ANS PINION AND STEERING PRESSURE HOSE DUE TO LEAKING STEERING FLUID/EPAIRMENT OF TRANSMISSION TORQUE CONVERTER CLUTCH/ REPLACEMENT OF VALVE COVER GAS…
Read full complaint
1995 OLDSMOBILE AURORA EXPERIENCING PROBLEMS WITH STEERING WHEEL.*MR...CONSUMER TOOK VEHICLE TO PREMIER AUTOMOTIVE SERVICES , AND THEY RECOMMENDED THE REPLACEMENT OF STEERING RACK ANS PINION AND STEERING PRESSURE HOSE DUE TO LEAKING STEERING FLUID/EPAIRMENT OF TRANSMISSION TORQUE CONVERTER CLUTCH/ REPLACEMENT OF VALVE COVER GASKETS AND ENGINE MOUNTS/ REPAIRED COOLANT LEAK. CONSUMER PURCHASED A WYNNS USA EXTENDED WARRANTY, WHICH DID NOT NOT COVER ALL REPAIR WORK NEEDED. *AK
NHTSA ODI #10121459
90,000 miles · Feb 1, 2005
Engine And Engine CoolingFire
TRIED TO START VEHICLE, VEHICLE BACKFIRED. A FEW MINUTES LATER, I NOTICED THAT SMOKE WAS COMING OUT FROM UNDER THE CAR, AND THE ICE ON THE VEHICLE WAS MELTING. I OPENED THE HOOD AND DISCOVERED THAT THE ENGINE WAS ON FIRE. I WAS ABLE TO EXTINGUISH THE FIRE WITH A BLANKET.*AK
NHTSA ODI #10108380
Mileage unknown · Nov 5, 2004
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
WHILE DRIVING SMELLED OF STRONG GAS FUMES IN/OUT. FUEL WAS LEAKING INTO THE ENGINE COMPARTMENT. REPLACED THE FUEL PUMP. *BF THE CONSUMER REQUESTED REIMURSEMENT.THE DRIVER DOOR LOCK DID NOT LOCK AUTOMATICALLY UNLOCK THE DOOR, THE FUEL PUMP LOST PRESSURE, THE SERPINTINE BELT CRACKED, AND THERE WAS EXTENDED CRANKING WHEN REST…
Read full complaint
WHILE DRIVING SMELLED OF STRONG GAS FUMES IN/OUT. FUEL WAS LEAKING INTO THE ENGINE COMPARTMENT. REPLACED THE FUEL PUMP. *BF THE CONSUMER REQUESTED REIMURSEMENT.THE DRIVER DOOR LOCK DID NOT LOCK AUTOMATICALLY UNLOCK THE DOOR, THE FUEL PUMP LOST PRESSURE, THE SERPINTINE BELT CRACKED, AND THERE WAS EXTENDED CRANKING WHEN RESTARTING THE VEHICLE WARM. RECALL# 04V110000 *SC
NHTSA ODI #10101048
99,000 miles · Oct 4, 2004
Engine And Engine Cooling
A RECALL FOR THE OIL WAS RECEIVED. CONSUMER TOOK THE VEHICLE TO THE DEALER ON THREE OCCASIONS FOR THE SAME REPAIRS. CHECK ENGINE LIGHT WAS ON, AND THE OIL LEAK CONTINUED. *AK
NHTSA ODI #10094992
Mileage unknown · Sep 24, 2004
Engine And Engine CoolingVehicle Speed Control
WHILE APPLYING THE BRAKE PEDAL WENT O THE FLOOR, AND VEHICLE CONTINUED TO ACCELERATE. CONSUMER NOTICED THAT THE VEHICLE HESITATED AND SURGED. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE IDLE SPEED MOTOR AND EGR VALVE NEEDED TO BE REPLACED. *AK
NHTSA ODI #10094331
75,000 miles · Sep 10, 2004
Electrical SystemEngine And Engine CoolingVehicle Speed Control
MY CHECK ENGINE LIGHT CAME ON WHEN I WAS ON THE FREE WAY WHEN ALL OF SUDDEN AS I SLOWED DOWN MY CAR LOST POWER AND CONTROL. I SKID ACROSS THE FREEWAY AND ALMOST GOT KILLED. IT STARTED BACK UP TEN MIN LATER AND TOOK IT TO SHOP THEY SAID CODE WAS INPUT SPEED SENSOR AND EGR VALVE. COST 2000$ FOR REPAIR PLUS LABOR. *AK
NHTSA ODI #10090788
70,000 miles · Aug 17, 2004
Engine And Engine Cooling
VEHICLE WAS LEAKING FUEL ONTO THE ENGINE. MANUFACTURER WAS CONTACTED ABOUT THE RECALL FOR THE PROBLEM, HOWEVER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
NHTSA ODI #10089085
122,000 miles · Aug 10, 2004
Engine And Engine Cooling
VEHICLE WAS SPURTING GAS ONTO THE ENGINE. . VEHICLE WAS TOWED TO A REPAIR SHOP. THIS VEHICLE WAS NOT INCLUDED IN RECALL 04V100000 DUE TO VIN. *AK
NHTSA ODI #10087605
120,000 miles · Mar 29, 2004
Engine And Engine Cooling
VEHICLE IS PUMPING GAS ALL OVER THE ENGINE COMPARTMENT. *AK
NHTSA ODI #10065151
110,900 miles · Mar 27, 2004
Electrical SystemEngine And Engine CoolingPower Train
ENGINE LIGHT COMES ON...RPM'S RANDOMLY GO UP AND DOWN CAUSING VEHICLE TO SURGE AND/OR STALL. THIS IS EXTREMELY DANGEROUS. ALSO, WHEN SHIFTING FROM PARK TO REVERSE, THE TRANSMISSION ENGAGED ROUGHLY AND NOW WILL CAR WILL NOT SHIFT INTO 3RD GEAR TO ACCELETRATE BEYOND 40 M.P.H. TOOK CAR IN FOR SERVICE TWICE WHILE UNDER WARRANTY COM…
Read full complaint
ENGINE LIGHT COMES ON...RPM'S RANDOMLY GO UP AND DOWN CAUSING VEHICLE TO SURGE AND/OR STALL. THIS IS EXTREMELY DANGEROUS. ALSO, WHEN SHIFTING FROM PARK TO REVERSE, THE TRANSMISSION ENGAGED ROUGHLY AND NOW WILL CAR WILL NOT SHIFT INTO 3RD GEAR TO ACCELETRATE BEYOND 40 M.P.H. TOOK CAR IN FOR SERVICE TWICE WHILE UNDER WARRANTY COMPLAINING ABOUT JERK IN TRANSMISSION, THE TRANSMISSION WAS REPLACED THE FIRST, NOW 37,000 MILES LATER OUT OF WARRANTY AND COMPLETE FAILURE . COMPANY ADVERTISERS CAR WILL NOT NEED TUNEUP UNTIL 100,000 MILES, I HAVE HAD THE CAR FOR ONLY 60K MILES AND HAVE HAD TO HAVE IT TUNED UP TWICE AT $600+ A POP. AT THAT POINT CAR WAS STALLING NOT DELIVERING THE POWER THAT IT USUALLY DOES.*AK
NHTSA ODI #10063987
NHTSA investigations
5EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA00006 · Rear Seat Belt Retractor
Opened Feb 22, 2000 · Closed Mar 6, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
IN ITS LETTER DATED FEBRUARY 25, 2000 TO NHTSA, GENERAL MOTORS STATED THAT IT WILL CONDUCT A SAFETY RECALL OF 85,253 MODEL YEAR 1995 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES FOR THE DEFECT IN THE OUTBOARD REAR SEAT BELT RETRACTOR ASSEMBLIES.
PE99059 · Rear Seat Belt Retractor
Opened Sep 15, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
COMPLAINTS GENERALLY STATED THAT ONE OR BOTH OUTBOARD REAR SEAT BELTS DO NOT RETRACT AT ALL AND ARE USELESS.IT IS EVIDENT THAT THE SEAT BELTS DO NOT PROVIDE ANY TENSION AND HAVE EXCESS SLACK.THE RETRACTOR ASSEMBLY HAS A PLASTIC COVER NEXT TO THE RETRACTOR RETURN SPRING.ACCORDING TO GENERAL MOTORS (GM), HEAT MAY SOFTEN, WARP AND DEFLECT THE PLASTIC SPRING COVER ALLOWING THE RETURN SPRING TO DISENGAGE THROUGH AND JAM IN THE SPRING COVER ACCESS HOLE RENDERING THE RETURN SPRING NONFUNCTIONAL.TO ELIMANATE THE PROBLEM, GM CHANGED THE SPRING COVER MATERIAL AND ACCESS HOLE AT THE BEGINNING OF PRODUCTION OF MODEL YEAR (MY) 1996 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES.BOTH COMPLAINTS AND WARRANTY CLAIMS HAVE DECLINED SIGNIFICANTLY FROM MY 1995 SUBJECT VEHICLES TO MY 1996 VEHICLES.
SQ96012 · Rear Compartment Lid Rod Separation
Opened Jun 25, 1996 · No close date supplied
Status: open (inferred from source dates) · Structure
ADDITION INFORMATION IS NEEDED TO FULLY UNDERSTAND THE NATURE AND CIRCUMSTANCES OF THE SUBJECT BULLETIN.
Illustration