IllustrationNISSAN XTERRA FRAME RUSTED BEYOND ANY SAFETY JUSTIFICATION. OIL LEAKS FROM ENGINE UP TWO 2 QUART A DAY LEAD TO ENGINE SEIZED UP WITHOUT WARNING.
2003 Nissan Xterra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Nissan Xterra do not stand out strongly from the model-year median of 78.
About this comparison →How this year compares
Owner complaints by model year
Compare all Xterra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
325–50K
850–75K
875–100K
13100–150K
6150K+
53 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports2 fire reports10 injury reports
Structure complaints
7 reportsCALLED ROADSIDE ASSISTANCE TO CHANGE A TIRE. THE SPARE TIRE RUBBER WAS BURNED IN THREE OR MORE PLACES FROM THE HEAT SPREADING UNDER THE VEHICLE, AND THE CHAR/MELTING/BURNING WENT THROUGH THE VEHICLE BODY FROM THE BOTTOM OF THE VEHICLE OUTSIDE TO THE FLOOR INSIDE. THE MAN CHANGING MY TIRE SUGGESTED IT WAS A FIRE WAITING TO HAPP…
Read full complaint
CALLED ROADSIDE ASSISTANCE TO CHANGE A TIRE. THE SPARE TIRE RUBBER WAS BURNED IN THREE OR MORE PLACES FROM THE HEAT SPREADING UNDER THE VEHICLE, AND THE CHAR/MELTING/BURNING WENT THROUGH THE VEHICLE BODY FROM THE BOTTOM OF THE VEHICLE OUTSIDE TO THE FLOOR INSIDE. THE MAN CHANGING MY TIRE SUGGESTED IT WAS A FIRE WAITING TO HAPPEN AND THAT THERE COULD BE A RECALL FOR THIS SORT OF ISSUE. I CHECKED AND DO NOT SEE ANYTHING LISTED. MY TIRED IS NOW DAMAGED FROM THE HEAT MELTING THE RUBBER, AND MY VEHICLE IS CHARRED IN PLACES. *TR
RADIATOR IS FALLING OUT OF TRUCK ,DUE TO SERIOUS RUST ON FRAMING, HOOD LATCH IS STARTING TO BREAK FREE HOOD COULD FLY UP ONTO WINDSHIELD . *TR
I DROVE THE VEHICLE ON A FREEWAY UNDER CONSTRUCTION WITH ONE FINISHED NEW PAVEMENT LANE. WHEN I WAS CHANGED THE OTHER OLD LANE TO THE NEW ONE, THE WHEEL SUDDENLY GOT OUT OF CONTROL AND SPUN FROM ONE LANE TO THE OTHER AND ENDED IN THE MIDIUM BUMPED INTO BARRIERS. LATELY I CONTACTED WITH NISSAN AND QUESTION IF THIS IS ASSOCIATED…
Read full complaint
I DROVE THE VEHICLE ON A FREEWAY UNDER CONSTRUCTION WITH ONE FINISHED NEW PAVEMENT LANE. WHEN I WAS CHANGED THE OTHER OLD LANE TO THE NEW ONE, THE WHEEL SUDDENLY GOT OUT OF CONTROL AND SPUN FROM ONE LANE TO THE OTHER AND ENDED IN THE MIDIUM BUMPED INTO BARRIERS. LATELY I CONTACTED WITH NISSAN AND QUESTION IF THIS IS ASSOCIATED WITH THE RECALL R1037. THEY DENIED. *TR
THE WHOLE FRONT END OF THE VEHICLE IS COMING APART IT HAS STRESS CRACKS AND WHERE THE SPOT WELDS ARE THEY ALSO ARE COMING APART. *NM
ON THE WAY TO THE BEACH TRAVELING 55 MPH IN MY 2003 NISSAN XTERRA, MY SURF BOARD FLEW OFF THE ROO TRACK INTO THE MIDDLE OF ROUTE 1 IN DELAWARE. THE TRAFFIC BEHIND ME MANAGED TO AVOID HITTING THE SURFBOARD THAT WAS SITUATED IN THE LEFT LANE OF TRAFFIC. MORE IMPORTANTLY, THERE WERE NO ACCIDENTS CAUSED BY THE INCIDENT HENCE THE P…
Read full complaint
ON THE WAY TO THE BEACH TRAVELING 55 MPH IN MY 2003 NISSAN XTERRA, MY SURF BOARD FLEW OFF THE ROO TRACK INTO THE MIDDLE OF ROUTE 1 IN DELAWARE. THE TRAFFIC BEHIND ME MANAGED TO AVOID HITTING THE SURFBOARD THAT WAS SITUATED IN THE LEFT LANE OF TRAFFIC. MORE IMPORTANTLY, THERE WERE NO ACCIDENTS CAUSED BY THE INCIDENT HENCE THE POLICE WERE NOT INVOLVED. AFTER REMOVING MY SURFBOARD FROM THE HIGHWAY AND INSPECTING DAMAGE TO IT AND THE ROOFRACK CROSSBARS, I NOTICED THE PLASTIC CLASP ON THE CROSSBAR HAD SNAPPED, CAUSING THE SURFBOARD TO FLY OFF THE ROOFOF MY XTERRA. THE FOLLOWING MONDAY, THE DEALERSHIP EVALUATED THE SITUATION AND ACKNOWLEDGED THAT THE RACK HAD "BROKEN FROM STRESS/FATIGUE" AND IS REPLACING IT UNDER WARRANTY. HOWEVER, MY SURFBOARD IS COMPLETELY DESTROYED AND NEITHER THE DEALERSHIP NOR THE NISSAN CONSUMER AFFAIRS WILL REIMBURSE ME FOR THE COST OF THE SURFBOARD, STATING THAT DAMAGE TO PERSONAL PROPERTY IS NOT COVERED UNDER WARRANTY.*AK
TICKING NOISE COMING FROM TOP REAR OF DRIVER DOOR (SEAL) AND HEAD-LINER RIGHT ABOVE DRIVER'S SEAT.*AK
Official recalls
310V554000 · Steering:column
Nov 11, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2002-2004 FRONTIER VEHICLES MANUFACTURED FROM JULY 9, 2001 THROUGH OCTOBER 20, 2004, AND MODEL YEAR 2002-2004, XTERRA VEHICLES MANUFACTURED FROM JULY 9, 2001, THROUGH JANUARY 6, 2005. OVER TIME CORROSION MAY FORM IN THE LOWER STEERING COLUMN JOINT AND LIMIT MOVEMENT OF THE JOINT. THE LIMITED MOVEMENT OF THIS JOINT MAY CREATE EXCESSIVE LOAD ON THE LOWER STEERING COLUMN SHAFT. IF THE VEHICLE CONTINUES TO BE DRIVEN IN THIS CONDITION, IT MAY LEAD TO CRACKING OF THE SHAFT DURING LOW SPEED MANEUVERS THAT REQUIRE LARGE STEERING INPUTS.
Consequence & remedy
Consequence: THE SHAFT MAY BREAK WHICH COULD RESULT IN LOSS OF STEERING CONTROL DURING THESE LOW SPEED MANEUVERS INCREASING THE RISK OF A CRASH.
Remedy: THE STEERING COLUMN SHAFT AND JOINT WILL BE REPLACED WITH A SHAFT OF A DIFFERENT DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
04V230000 · Fuel System, Gasoline:delivery:fuel Pump
May 24, 2004
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.
Consequence & remedy
Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.
Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
02V299000 · Suspension:rear
Nov 12, 2002
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, WATER MAY ENTER THE REAR AXLE HOUSING DUE TO INADEQUATE SEALING OF THE ANTI-LOCK BRAKING SYSTEM (ABS) SENSOR.
Consequence & remedy
Consequence: THIS CAN RESULT IN CORROSION AND EVENTUAL FAILURE OF THE WHEEL BEARING. IF THIS OCCURS, THE WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR AXLE FOR WATER INTRUSION AND ANY AFFECTED COMPONENTS WILL BE REPLACED. THE ABS SENSOR WILL BE RESEALED TO PREVENT WATER INTRUSION. OWNER NOTIFICATION BEGAN DECEMBER 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP03005 · Brake Rotor Warpage
Opened Jul 11, 2003 · Closed Jul 29, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:disc:rotor
MR. KENT JONES OF KERNERSVILLE, NC, SUBMITTED A PETITION TO NHTSA BY E-MAIL DATED JULY 1, 2003, REQUESTING NHTSA TO INVESTIGATE THE BRAKE ROTORS ON MY 2002 NISSAN XTERRA VEHICLES.THE PETITIONER ALLEGED THAT THE BRAKE ROTORS IN THESE VEHICLES WERE DEFECTIVE BECAUSE THE ROTORS OVERHEAT AND WARP FROM NORMAL USAGE.A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING MY 2001 THROUGH MY 2003 NISSAN XTERRA VEHICLES IDENTIFIED ONLY TWO REPORTS RELATED TO BRAKE ROTOR WARPING; ONE FOR A MY 2001 AND ONE FOR A MY 2002.THE COMPLAINT FOR THE MY 2002 NISSAN XTERRA WAS REPORTED BY THE PETITIONER.BRAKE ROTOR WARPING CAN RESULT IN BRAKE PULSATION AND SHAKING WHEN THE BRAKE IS APPLIED.BRAKE PULSATION, TIRE OR SUSPENSION VIBRATION, AND SIMILAR CONDITIONS ARE AN OBVIOUS ANNOYANCE TO THE DRIVER, BUT GENERALLY DO NOT CAUSE A DRIVER TO LOSE CONTROL OF A VEHICLE.FURTHERMORE, EVEN IF LEFT UNCORRECTED, ANY POTENTIAL INCREASE IN STOPPING DISTANCE WILL BE NEGLIGIBLE. THEREFORE, THIS CONDITION DOES NOT NORMALLY CONSTITUTE A SAFETY DEFECT, EVEN IF IT OCCURS WITH FAR MORE OFTEN FREQUENCY. IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF AN ALLEGED SAFETY-RELATED DEFECT AS DEFINED BY THE PETITIONER IN THE MY 2002 NISSAN XTERRA VEHICLES AT THE CONCLUSION OF AN INVESTIGATION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.