Fuel System, Gasoline. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports4 fire reports14 injury reports

What owners actually said

214 reports

72,000 miles · Mar 6, 2003

Fuel System, Gasoline

THE VEHICLE STOPPED RUNNING. DIAGNOSIS IS FUEL PUMP AND SENDING UNIT. THE MANUFACTURER IS REFUSING A RECALL EVEN WITH THE PROOF THAT THIS HAS BEEN A NUMEROUS COMPLAINT. I AM NOW TOLD THAT I WOULD HAVE TO WAIT 2 MONTHS FOR THE PART DUE TO A HIGH DEMAND.*JB

NHTSA ODI #10008502

30,000 miles · Mar 6, 2003

Engine And Engine Cooling

THE EXHAUST MANIFOLDS ON THE NISSAN XTERRA WITH THE VG33? V-6 ENGINE HAS A CHRONIC PROBLEM WITH CRACKING AND/OR SHEARING BOLTS. I MYSELF HAVE FALLEN VICTIM TO THIS, AS THOUSANDS OF OTHER XTERRA OWNERS HAVE. JUST GO TO HTTP://WWW.XTERRAOWNERSCLUB.COM, TO THE FORUMS, AND YOU WILL SEE HOW MANY HAVE HAD TO HAVE THIS REPLACED, SOME…

Read full complaint

NHTSA ODI #10008489

89,000 miles · Mar 6, 2003

Fuel System, Gasoline

Read full complaint

MY HUSBAND AND I HAD JUST RETURNED HOME ONE EVENING AFTER DRIVING OUR XTERRA FOR APPROXIMATELY 1 HR. 15 MIN LATER MY 10 YR OLD SON CALLED NEEDING A RIDE HOME. SO I WENT OUT TO THE XTERRA AND IT WOULD NOT START. I HAD TO CALL A CAB TO GO GET HIM. WE NOTIFIED OUR DEALERSHIP, THEY SAID MOST LIKELY THE FUEL PUMP SENDING UNIT GONE BAD. THAT THEY HAVE SIX XTERRA'S IN THEIR LOT THAT HAVE BEEN THERE FOR 2 WEEKS WITH THE SAME PROBLEM. PARTS ARE ON NATIONAL BACK ORDER, AND THEY HAVE NO IDEA AS TO WHEN PARTS CAN BE EXPECTED. WE NOW HAVE TO HAVE OUR VEHICLE TOWED TO THE DEALER, AT OUR EXPENSE BECAUSE THE EXTENDED WARRANTY WE PAID $1,200 FOR JUST RAN OUT 2 WKS AGO !!! THEY DO NOT KNOW WHEN THEY CAN HAVE THE VEHICLE FIXED BECAUSE PARTS ARE ON BACK ORDER. THIS PROBLEM IS A SAFETY RELATED ISSUE AND SHOULD DEFINITELY BE RECALLED.*JB

NHTSA ODI #10008480

47,000 miles · Mar 5, 2003

Fuel System, Gasoline

THE VEHICLE STALLED IN THE MIDDLE OF THE INTERSECTION. *JB THE VEHICLE RESTARTED FIVE MINUTES AFTER THE INCIDENT. THE VEHICLE REACHED ITS DESTINATION, BUT WAS UNABLE TO BE RESTARTED AGAIN. THE FUEL TANKS SENDING UNIT WAS REPLACED. SCC

NHTSA ODI #10009958

75,000 miles · Feb 28, 2003

EquipmentFuel System, Other

FUEL SENDING SYSTEM FOR MY 2000 NISSAN XTERRA IS ON NATIONAL BACK ORDER MY CAR IS DISABLED FOR TWO WEEKS AT THE DEALER. FOUND THAT MANY OTHER PERSONS HAD THE SAME PROBLEM, WHICH IS MY CAR DIED ON A MAJOR HIGHWAY FOR NO EXPECTED REASON. *JB

NHTSA ODI #10008246

74,096 miles · Feb 26, 2003

Fuel System, Gasoline

Read full complaint

THE VEHICLE SUDDENLY LOST ALL POWER WHILE I WAS DRIVING, I HAD TO HAVE THE CAR TOWED TO A SERVICE STATION BECAUSE IT WOULD NOT RESTART. I HAD A NEW BATTERY, FULL TANK OF GAS, IT MADE NO SENSE. THE PROBLEM IS A CORRODED COMPONENT ON THE FUEL PUMP, NECESSITATING A NEW FUEL PUMP AND COMPONENT. PER THE SERVICE STATION, THEY WILL USE THE SAME EXACT PART AGAIN, HOWEVER A GEL WILL BE USED ON THE COMPONENT TO AVOID THE CORROSION THAT CAN OCCUR. WHY DIDN'T NISSAN DO THIS IN THE FIRST PLACE?? I AM OUT OVER $500 FOR REPAIRS AND COULD HAVE BEEN INJURED DUE TO THE LOSS OF POWER! *JB

NHTSA ODI #10008135

Mileage unknown · Feb 25, 2003

Fuel System, Gasoline

THE FUEL PUMP FAILED.*JB

NHTSA ODI #10009264

Mileage unknown · Feb 24, 2003

Engine And Engine Cooling

THE VEHICLE STALLED WITHOUT WARNING.*JB

NHTSA ODI #10009158

41,000 miles · Feb 24, 2003

Fuel System, Gasoline

2000 EXTERRA W/ 40,000 MILES. FUEL SENDING UNIT WIRES CORRODED, CAUSING ENGINE TO STOP. (NISSAN PART # 25060-4S415). INCIDENT LUCKILY OCCURRED WHILE TRAVELING AT LOW SPEED ON STREET WITH LIGHT TRAFFIC.

NHTSA ODI #10008015

Mileage unknown · Feb 22, 2003

Fuel System, Other

2000 NISSAN XTERRA SENDING UNIT FAILED CAUSING AUTO TO STOP IN THE MIDDLE OF THE ROAD

NHTSA ODI #10007996

Official recalls

04V230000 · Fuel System, Gasoline:delivery:fuel Pump

May 24, 2004

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH SIX CYLINDER ENGINES AND SPORT UTILITY VEHICLES EQUIPPED WITH FOUR OR SIX CYLINDER ENGINES, THE FUEL PUMP TERMINAL ON THE FUEL-SENDING UNIT CAN DEVELOP A CRACK IN THE PLASTIC MOLDING. THIS CAN CAUSE THE TERMINAL STRIP TO CORRODE UNDER SOME ENVIRONMENTAL CONDITIONS.

Consequence & remedy

Consequence: IF CORROSION OCCURS, THE TERMINAL STRIP COULD EVENTUALLY BREAK CAUSING THE FUEL PUMP TO STOP OPERATION. THIS WILL RESULT IN NOT BEING ABLE TO START THE ENGINE OR CAUSE THE ENGINE TO STOP RUNNING WITHOUT WARNING, WHICH CAN RESULT IN A CRASH.

Remedy: IN THE FOLLOWING STATES, DEALERS WILL REPLACE THE FUEL-SENDING UNIT. THESE STATES ARE CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THE OTHER STATES, THE DEALER WILL INSPECT THE FUEL PUMP TERMINAL ON THE SENDING UNIT FOR CORROSION. IF CORROSION IS PRESENT, THE DEALER WILL REPLACE THE UNIT. IF THERE IS NOT CORROSION, THE DEALER WILL APPLY SEALANT TO THE TERMINAL HOUSING TO HELP PREVENT CORROSION IN THE FUTURE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.

03V307000 · Wheels

Aug 22, 2003

2000 NISSAN XTERRA VEHICLES MANUFACTURED BETWEEN OCTOBER 15, 1999, AND FEBRUARY 29, 2000. THE ALLOY WHEELS USED ON THESE VEHICLES MAY NOT HAVE BEEN PROPERLY MANUFACTURED AND COULD DEVELOP CRACKS IN THE WHEEL SPOKES.

Consequence & remedy

Consequence: IF A SUFFICIENT NUMBER OF SPOKE CRACKS DEVELOP, THE WHEEL COULD FAIL AND SEPARATE FROM THE MOUNTING HUB, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT PRIOR WARNING.

Remedy: NISSAN WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FOUR ALLOY WHEELS WITH XTERRA SE MODEL BRIGHT ALLOY WHEELS FREE OF CHARGE. THE SPARE TIRE STEEL WHEEL IS NOT AFFECTED. OWNER NOTIFICATION BEGAN ON SEPTEMBER 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261. INFORMATION CAN ALSO BE OBTAINED THROUGH NISSAN'S WEB SITE AT WWW.NISSANUSA.COM.

00V288000 · Power Train:automatic Transmission

Oct 2, 2000

VEHICLE DESCRIPTION: PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT. " THESE VEHICLES COULD HAVE A SHIFT CABLE LOCK PLATE THAT IS TOO BRITTLE AND CAN BREAK. THE GEAR SHIFT LEVER AND THE "PRNDL" INDICATOR MAY MOVE, BUT THE TRANSMISSION WILL NOT SHIFT OUT OF THE PARK POSITION. OVER A PERIOD OF TIME, THE TRANSMISSION COULD SHIFT OUT OF THE PARK POSITION, BUT THE GEAR INDICATED ON THE DISPLAY MAY DIFFER FROM THE GEAR ENGAGED IN THE TRANSMISSION.

Consequence & remedy

Consequence: IF THE DRIVER SELECTS 'DRIVE' AND THE TRANSMISSION IS ACTUALLY IN 'REVERSE', A VEHICLE CRASH COULD OCCUR.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION SHIFT CABLE LOCK PLATE.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.