IllustrationFRONT DIFF DRIVER SIDE AXLE PUSHING OUT. *TR
2006 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2006 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
580–25K
7925–50K
10050–75K
6475–100K
51100–150K
24150K+
376 reports with mileage · 54 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 194 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports10 fire reports7 injury reports
What owners actually said
430 reports2006 NISSAN TITAN,,,AXLE SEAL FAILURE...4TH ONE, LEAKING OIL ALL OVER THE BRAKES. *TR
ON SATURDAY AUG. 7 I NOTICED A PUDDLE OF WHAT APPEARED TO BE OIL AT THE RIGHT REAR OF MY 2006 NISSAN TITAN.THE ENTIRE WHEEL WAS COVERED IN OIL,AFTER INSPECTING, I FOUND I HAD A LEAK FROM THE SEAL ON THE AXLE. WHILE TRYING TO FIND OUT HOW AND WHY, I FOUND OUT THAT THIS IS A COMMON PROBLEM WITH NISSAN . WHY IS THERE NOT A RECALL. …
Read full complaint
ON SATURDAY AUG. 7 I NOTICED A PUDDLE OF WHAT APPEARED TO BE OIL AT THE RIGHT REAR OF MY 2006 NISSAN TITAN.THE ENTIRE WHEEL WAS COVERED IN OIL,AFTER INSPECTING, I FOUND I HAD A LEAK FROM THE SEAL ON THE AXLE. WHILE TRYING TO FIND OUT HOW AND WHY, I FOUND OUT THAT THIS IS A COMMON PROBLEM WITH NISSAN . WHY IS THERE NOT A RECALL. THIS COULD BE AN EXPENSIVE REPAIR TO ANY OWNER. NISSAN NEEDS TO STAND BEHIND THEIR PRODUCT. *TR
06 NISSAN TITAN 4X4 SE W/ OFF ROAD PACKAGE. THE LEFT REAR AXLE SEAL FAILED AT 65,000 MILES. THE DEALER REPLACED THE LEFT SEAL AND AXEL. *TR
2006 NISSAN TITAN LE 4X4, REAR AXLE SEALS FAILING CAUSING OIL TO LEAK ON REAR DISK BRAKES. SEEMS TO BE PRETTY COMMON ON TITANS. *TR
I HAVE NOTICED MY REAR AXLE SEALS LEAKING FOR A WHILE AND WAS TOLD BY THE DEALERSHIP THAT IT WAS NOT AN ISSUE. I HAVE NOW RECENTLY NOTICED WHEN I USE MY EMERGENCY BRAKE AND REAR BRAKES THEY HAVE BEEN AFFECTED BY THE LEAKING FLUID. I WAS WONDERING IF THIS IS AN ISSUE THEY SHOULD ADDRESS, OR IS IT JUST REGULAR MAINTENANCE. I HAVE …
Read full complaint
I HAVE NOTICED MY REAR AXLE SEALS LEAKING FOR A WHILE AND WAS TOLD BY THE DEALERSHIP THAT IT WAS NOT AN ISSUE. I HAVE NOW RECENTLY NOTICED WHEN I USE MY EMERGENCY BRAKE AND REAR BRAKES THEY HAVE BEEN AFFECTED BY THE LEAKING FLUID. I WAS WONDERING IF THIS IS AN ISSUE THEY SHOULD ADDRESS, OR IS IT JUST REGULAR MAINTENANCE. I HAVE BEEN READING FORUM COMPLAINTS ABOUT PEOPLE WITH THE SAME TRUCK AND THEY HAVE ALSO EXPERIENCED THIS PROBLEM LOW IN MILE. MY TRUCK IS A 2006 NISSAN TITAN SE CREW CAB 4WD. I HAVE NOTICED THE SEALS LEAKING SINCE ABOUT 40K MILES AND NOW HAVE AROUND 56K. *TR
I HAVE OWNED MY 2006 CREW CAB SINCE DEC 2006 AND HAVE HAD PROBLEMS WITH STEERING WHEEL SHAKING WHILE BRAKING. TOOK TRUCK TO DEALER IN 2008 MILES 10, 850 THEY TURNED THE ROTORS AND APPLIED GREASE. TOOK TRUCK BACK TO DEALER ON JULY 9TH 2010 AND THEY AGAIN SAID ROTORS NEEDED TO BE TURNED THE TRUCK ONLY HAS 27,980 MILES. THE SERV…
Read full complaint
I HAVE OWNED MY 2006 CREW CAB SINCE DEC 2006 AND HAVE HAD PROBLEMS WITH STEERING WHEEL SHAKING WHILE BRAKING. TOOK TRUCK TO DEALER IN 2008 MILES 10, 850 THEY TURNED THE ROTORS AND APPLIED GREASE. TOOK TRUCK BACK TO DEALER ON JULY 9TH 2010 AND THEY AGAIN SAID ROTORS NEEDED TO BE TURNED THE TRUCK ONLY HAS 27,980 MILES. THE SERVICE MAN SAID THE ROTORS WERE NO LONGER COVERED AND I WOULD HAVE TO PAY HAVE ROTORS TURNED. I WAS TOLD THE ROTORS WERE GOOD FOR 30,000 MILES. I THINK IT'S STRANGE THAT THE ROTORS NEED TO BE TURNED EVERY 10,000 TO 15,000 MILES. SERVICE MAN ACTED LIKE THIS WAS A COMMAND THING AND THAT IT WAS THE DRIVERS FAULT NOT THE COMPANY'S. I ASKED ABOUT RECALLS AT THE DEALER AND WAS TOLD THEY WOULD CONTACT ME I HAVE NOT HEARD FROM THE DEALER SINCE. NISSAN NEEDS TO SEE THIS AS A MANUFACTURERS DEFECT AND MAKE A RECALL. *TR
I PLACED MY TRUCK ON A LIFT TO INSPECT THE UNDERBODY AND CHANGE MY OIL. DURING THE PROCESS, I SAW LIQUID STREAKS DOWN THE INSIDE OF MY LEFT REAR WHEEL HUB AND ROTOR. I HAD DETERMINED THE REAR AXLE SEAL WAS THE LEAKING CULPRIT, ENABLING AXLE FLUID TO DRAIN ONTO THE WHEEL HUB AND BRAKE ASSEMBLY. ALTHOUGH BRAKE PERFORMANCE WAS N…
Read full complaint
I PLACED MY TRUCK ON A LIFT TO INSPECT THE UNDERBODY AND CHANGE MY OIL. DURING THE PROCESS, I SAW LIQUID STREAKS DOWN THE INSIDE OF MY LEFT REAR WHEEL HUB AND ROTOR. I HAD DETERMINED THE REAR AXLE SEAL WAS THE LEAKING CULPRIT, ENABLING AXLE FLUID TO DRAIN ONTO THE WHEEL HUB AND BRAKE ASSEMBLY. ALTHOUGH BRAKE PERFORMANCE WAS NOTICEABLY DEGRADED, THE SITUATION COULD HAVE BECOME FAR WORSE. THE NISSAN DEALERSHIP REPLACED THE SEAL ASSEMBLY, BUT I AM NOT CONFIDENT THIS WILL CORRECT THE ISSUE. NUMEROUS INCIDENTS SIMILAR TO THIS NATURE HAVE BEEN REPORTED ON NISSAN TITAN AUTO CLUBS, SUCH AS WWW.TITANTALK.COM/FORUMS. THE DEALERSHIP ALREADY HAD A TECHNICAL SERVICE BULLETIN (WITH A THIRD REVISION DATE OVER 3 YEARS BEING OUT IN SERVICE) - THIS TELLS ME THAT NISSAN KNOWS THERE IS A PROBLEM WITH THE AXLE, BUT WILL NOT RECALL THE VEHICLES AND FIX THEM PROPERLY. *TR
TL*THE CONTACT OWNS A 2006 NISSAN TITAN. THE FUEL GAUGE DID NOT DISPLAY THE PROPER FUEL LEVEL IMMEDIATELY AFTER GASOLINE WAS ADDED TO THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY EVEN WHEN GASOLINE WASN'T AD…
Read full complaint
TL*THE CONTACT OWNS A 2006 NISSAN TITAN. THE FUEL GAUGE DID NOT DISPLAY THE PROPER FUEL LEVEL IMMEDIATELY AFTER GASOLINE WAS ADDED TO THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY EVEN WHEN GASOLINE WASN'T ADDED TO THE FUEL TANK. THE CONTACT RECEIVED NHTSA RECALL CAMPAIGN ID NUMBER 10V074000 BUT HAD NOT TAKEN TO THE VEHICLE IN TO BE SERVICED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 55,000.
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. WHILE HAVING THE VEHICLE ALIGNED, THE CONTACT WAS INFORMED THAT THE FRONT UPPER LINK MOUNTING BRACKET AND PAN HARD BRACKET ON THE PASSENGER SIDE HAD SEPARATED FROM THE VEHICLE. THE VEHICLE HAS NOT BEEN SERVICED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WAS 55000…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN TITAN. WHILE HAVING THE VEHICLE ALIGNED, THE CONTACT WAS INFORMED THAT THE FRONT UPPER LINK MOUNTING BRACKET AND PAN HARD BRACKET ON THE PASSENGER SIDE HAD SEPARATED FROM THE VEHICLE. THE VEHICLE HAS NOT BEEN SERVICED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WAS 55000.
Official recalls
510V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V064000 · Latches/locks/linkages:doors:latch
Mar 8, 2006
CERTAIN LIGHT TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN ARC WELD IS MISSING ON SOME RIGHT SIDE REAR DOOR UPPER LATCH ASSEMBLIES.
Consequence & remedy
Consequence: THIS MAY RESULT IN THE RIGHT SIDE DOORS COMING PARTIALLY OPEN INCREASING THE RISK OF INJURY TO OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE UPPER LATCH ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT NISSAN AT 800-662-6200.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.