NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
77 reportsClear category filter130,000 miles · Aug 12, 2015
Electrical SystemEngineFuel/propulsion System
NISSAN QUEST CLUSTER LOSES ABILITY TO MONITER FUEL AND TEMPERATURE , WHICH CAUSED ME TO RUN OUT OF FUEL WHILE TRAVELLING AT A SPEED OF 55MPH. AFTER RESEARCHING ONLINE I SEE THERE IS A REPAIR BUT HOW DOES THE DEALER NOT SEE AN ISSUE WITH THIS PROBLEM. THE LCD SCREEN ESSENTIALLY PEEL AWAY FROM THE SCREEN DUE TO HEAT OR HUMIDITY . …
Read full complaint
NISSAN QUEST CLUSTER LOSES ABILITY TO MONITER FUEL AND TEMPERATURE , WHICH CAUSED ME TO RUN OUT OF FUEL WHILE TRAVELLING AT A SPEED OF 55MPH. AFTER RESEARCHING ONLINE I SEE THERE IS A REPAIR BUT HOW DOES THE DEALER NOT SEE AN ISSUE WITH THIS PROBLEM. THE LCD SCREEN ESSENTIALLY PEEL AWAY FROM THE SCREEN DUE TO HEAT OR HUMIDITY . I SEE THIS AS A DANGER AND I FEEL IT PUTS MY FAMILY ALONG WITH OTHERS IN DANGER .
NHTSA ODI #10748245
98,000 miles · Jun 9, 2015
Electrical SystemStructureUnknown Or OtherInjury
CHILDREN WAS ENTERING VEHICLE AND DOOR SPONTANEOUSLY CLOSED ON HAND. THIS HAS HAPPENED PERIODICALLY SINCE, BUT NEVER WITH THE EXACT SAME CIRCUMSTANCES. IE OPENED DOOR TO LOAD PACKAGES, TURNED BACK AROUND AND DOOR STARTED CLOSING.
NHTSA ODI #10724190
133,000 miles · Apr 27, 2015
Electrical SystemEngine
2004 NISSAN QUEST. CONSUMER WRITES IN REGARDS TO ECM CORROSION PROBLEMS. *SMD THE CONSUMER STATED THE VEHICLE STALLED AND IT WOULD NOT RE-START. THE DEALER INFORMED THE CONSUMER THE INTELLIGENT POWER DISTRIBUTION MODULE WOULD ALSO NEED TO BE REPLACED IN ORDER FOR THE VEHICLE TO RUN. *JB
NHTSA ODI #10712775
105,000 miles · Mar 16, 2015
Electrical System
ODOMETER , GAS GAUGE. TEMPERATURE GAUGE, STOPPED WORKING, ON THE LEFT SIDE OF DASH MAKING THE VEHICLE NOT BE ABLE TO PASS INSPECTION. *TR
NHTSA ODI #10694408
1,500,000 miles · Feb 4, 2015
Electrical System
MY BATTERY KEEPS GOING DEAD IF THE VAN SITS MORE THEN A DAY. I TOOK IT TO A LOCAL MECHANIC BUT HE COULD NOT FIND THE PROBLEM. WHEN I PICKED UP MY VAN THE LEFT SIDE OF THE DASH DOES NOT WORK. I LOOKED UP COMPLAINTS ON THE COMPUTER AND THEY ARE THE SAME AS MINE. THE ECM HAS RUSTED BECAUSE OF THE PLACEMENT IN THE VAN 2004 THROUGH 2…
Read full complaint
MY BATTERY KEEPS GOING DEAD IF THE VAN SITS MORE THEN A DAY. I TOOK IT TO A LOCAL MECHANIC BUT HE COULD NOT FIND THE PROBLEM. WHEN I PICKED UP MY VAN THE LEFT SIDE OF THE DASH DOES NOT WORK. I LOOKED UP COMPLAINTS ON THE COMPUTER AND THEY ARE THE SAME AS MINE. THE ECM HAS RUSTED BECAUSE OF THE PLACEMENT IN THE VAN 2004 THROUGH 2009 ARE IN THE SAME PLACE. I CALLED NISSAN BUT THE SAID THEY HAD NO IDEA WHAT I WAS TALKING ABOUT THAT I COULD NOT BELIEVE EVERY THING I READ ON THE INTERNET. THIS IS BAD BECAUSE NOW I CAN NOT GET MY VAN INSPECTED BECAUSE THE DASH DOES NOT WORK. I NEED MY VAN TO GO TO WORK. IT CUTS OFF FOR NO REASON. I CANNOT TELL HOW MUCH GAS I HAVE. I CAN TELL HOW MANY MILES I HAVE THAT WAS THE SECOND THING THAT WENT. THE FIRST WAS THE RADIO. THEY TOLD ME AT NISSAN THAT I HAD TO TAKE IT TO A NISSAN MECHANIC BUT I CAN NOT AFFORD $110.00 AN HOUR. THIS SHOULD BE A RECALL BECAUSE ALL 2004 TO 2009 VAN ARE MADE THIS WAY AND ARE HAVE ELECTRICAL PROBLEMS. PLEASE HELP. *TR
NHTSA ODI #10681085
121,012 miles · Jun 1, 2014
Electrical SystemFire
DROVE IT TO A PARK ABOUT 1:00 P.M. STAYED THERE TIL ABOUT 3:00 PM GOT HOME PARKED IN FRONT OF HOUSE ON STREET. WENT IN BACK YARD FOR A BBQ ABOUT 20 TO 30 MINUTES LATER NOTICED IT STARTED TO SMOKE UNDER HOOD TOWARD THE REAR OF ENGINE COMPARTMENT ON PASSENGER SIDE ABOUT WHERE PASS. FEET WOULD BE OR BEHIND GLOVE BOX. WITHIN 5 MINU…
Read full complaint
DROVE IT TO A PARK ABOUT 1:00 P.M. STAYED THERE TIL ABOUT 3:00 PM GOT HOME PARKED IN FRONT OF HOUSE ON STREET. WENT IN BACK YARD FOR A BBQ ABOUT 20 TO 30 MINUTES LATER NOTICED IT STARTED TO SMOKE UNDER HOOD TOWARD THE REAR OF ENGINE COMPARTMENT ON PASSENGER SIDE ABOUT WHERE PASS. FEET WOULD BE OR BEHIND GLOVE BOX. WITHIN 5 MINUTES WE HAD FLAMES AND BY THE TIME THE FIRE DEPT GOT HERE IT WAS A TOTAL LOSS. *TR
NHTSA ODI #10595425
Mileage unknown · Apr 18, 2014
Electrical System
MY VAN INDICATED A PROBLEM WITH A MIL ON THE DASH. AFTER GETTING IT TESTED THE CODE INDICATED AN ISSUE WITH A VENT VALVE P0447. I REPLACED THE SUGGESTED PART AND IT DID NOT FIX THE PROBLEM. AFTER RESEARCHING THE ISSUE, I FOCUSED MY ATTENTION ON THE ECM AS IT CONTROLS ALL THE SENSORS IN THE VEHICLE. I REMOVED THE ECM AND NOTICED …
Read full complaint
MY VAN INDICATED A PROBLEM WITH A MIL ON THE DASH. AFTER GETTING IT TESTED THE CODE INDICATED AN ISSUE WITH A VENT VALVE P0447. I REPLACED THE SUGGESTED PART AND IT DID NOT FIX THE PROBLEM. AFTER RESEARCHING THE ISSUE, I FOCUSED MY ATTENTION ON THE ECM AS IT CONTROLS ALL THE SENSORS IN THE VEHICLE. I REMOVED THE ECM AND NOTICED RUST AND CORROSION RIGHT AWAY. NISSAN DOES NOT CONSIDER IT BE A DEFECT, HOWEVER THE ECM IS MOUNTED UNDER THE LEAF SCREEN WHERE WATER IS SUPPOSED TO DRAIN. UPON REMOVING THE COVER TO THE ECM IT WAS DISCOVERED THAT THE CORROSION FROM THE WATER ATE AWAY AT THE METAL AND CREATED A HOLE IN THE SEALED ECM AND ALLOWED WATER TO GET AND CAUSE DAMAGE TO THE CIRCUIT BOARD. MY PROBLEM WAS ONLY 1 SENSOR, BUT IT WON'T PASS REQUIRED EMISSION IN MY STATE. THERE WERE SOME REPORTS OF DRIVABILITY ISSUES BY OTHERS THAT HAD THE DEALER TELL THEM THEY NEED THE ECM REPLACED AND IT WAS NOT COVERED UNDER WARRANTY. THIS IS A DESIGN FLAW AND SHOULD BE REPLACED BY THE MANUFACTURER. *TR
NHTSA ODI #10583466
147,000 miles · Dec 4, 2013
Electrical SystemEngineFire
ON NOVEMBER 27, 2013, WHILE PARKED OUTSIDE OF MY HOME, MY 2004 NISSAN QUEST BURST INTO FLAMES. THE CAR WITHIN SECONDS WAS COMPLETELY ENGULFED IN FLAMES, AND THERE WAS NOTHING ANYONE COULD DO BUT GET AS FAR AWAY FROM IT AS POSSIBLE AND HOPE THERE WOULD BE NO INJURIES OR FATALITIES. THE CAR IS TOTALED, AND I NEED ANSWERS AS TO HOW…
Read full complaint
ON NOVEMBER 27, 2013, WHILE PARKED OUTSIDE OF MY HOME, MY 2004 NISSAN QUEST BURST INTO FLAMES. THE CAR WITHIN SECONDS WAS COMPLETELY ENGULFED IN FLAMES, AND THERE WAS NOTHING ANYONE COULD DO BUT GET AS FAR AWAY FROM IT AS POSSIBLE AND HOPE THERE WOULD BE NO INJURIES OR FATALITIES. THE CAR IS TOTALED, AND I NEED ANSWERS AS TO HOW A CAR THAT IS PARKED ALL OF A SUDDEN BURSTS INTO FLAMES. I BELIEVE THAT THIS NEEDS TO BE INVESTIGATED. MY 2004 NISSAN QUEST CUT OFF ON ME AT A STOP SIGN ON OCTOBER 31, 2013. WHEN I GOT OUT OF THE CAR I COULD SMELL ANTIFREEZE. I HAD IT TOWED TO COWLS NISSAN THAT EVENING. WHEN I GOT TO COWLS NISSAN THEY WERE ABOUT TO CLOSE, BUT I WAS ABLE TO RENT A CAR FROM THEM WHILE MINE WOULD BE GETTING LOOKED AT AND HOPEFULLY FIXED THE NEXT DAY. THE NEXT DAY A REPRESENTATIVE FROM COWLS NISSAN CALLED ME AND TOLD ME THAT THE REAR COOLANT PUMP NEEDED FIXING AND THAT'?S WHY THE CAR CUT OFF AND WOULDN'?T START. THEY REPLACED THE PUMP AND REFILLED IT WITH ANTIFREEZE. I HAD MY WINDSHIELD WIPERS FIXED BECAUSE THEY SAID AS THEY DID A COURTESY MULTIPOINT INSPECTION THE WIPERS WEREN'?T WORKING BECAUSE OF A WIPER LINK ISSUE. WHEN I WENT TO PICK UP THE CAR I NOTICED ON THE RECEIPT THAT THERE WAS AN OIL LEAK ISSUE AND AIR FILTER ISSUE THAT WAS DISCOVERED IN THE MULTIPOINT INSPECTION. THEY ALSO NOTED THAT MY TIMING CHAIN WAS NOISY AT STARTUP AND THAT IT WOULD NEED TO BE DIAGNOSED FURTHER TO GET TO THE ROOT OF THE PROBLEM. AT NO TIME WAS I TOLD THAT THE CAR WASN'T SAFE TO DRIVE. ON NOVEMBER 10, 2013 I NOTICED THAT THERE WAS A HUMMING SOUND COMING FROM THE CAR, OFF AND ON, AND THEN THE PASSENGER SIDE HEADLIGHT WENT OUT. I TOOK THE CAR IN TO FIX THE HEADLIGHT ON 11/22/2013, BUT I WASN'T HEARING THE HUMMING SOUND THEN. I STARTED HEARING THE HUMMING SOUND AGAIN CLOSE TO THANKSGIVING (11/26/2013) AND PLANNED TO TAKE THE CAR BACK IN AFTER THE HOLIDAY. *TR
NHTSA ODI #10554765
65,000 miles · Nov 20, 2013
Electrical System
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THAT THE LED LIGHTS ON THE INSTRUMENT CLUSTER MALFUNCTIONED AND NONE OF THE READINGS COULD BE SEEN. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE INSTRUMENT CLUSTER REPLACED. THE DEALER STATED THAT WHILE ATTEMPTING TO REPLACE THE INSTRUMENT CLUSTER, THE MILEAG…
Read full complaint
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THAT THE LED LIGHTS ON THE INSTRUMENT CLUSTER MALFUNCTIONED AND NONE OF THE READINGS COULD BE SEEN. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE THE INSTRUMENT CLUSTER REPLACED. THE DEALER STATED THAT WHILE ATTEMPTING TO REPLACE THE INSTRUMENT CLUSTER, THE MILEAGE COULD NOT BE RETRIEVED TO TRANSFER INTO THE NEW CLUSTER. THE DEALER STATED IN ORDER TO KNOW THE TRUE ACCUMULATED MILEAGE OF THE VEHICLE, THE INSTRUMENT CLUSTER COULD NOT BE CHANGED. THE FAILURE MILEAGE WAS 65,000.
NHTSA ODI #10553047
87,000 miles · Jul 1, 2013
Electrical SystemPower Train
VEHICLE LOST SPEED DRAMATICALLY ON THE ROAD. CAR WOULD NOT DRIVE MORE THAN 10 MPH, NO INCREASE IN RPMS WITH ACCELERATOR DEPRESSED. MECHANIC REPORTS ECM FAILED WHILE DRIVING DUE TO RUST DEVELOPMENT. ECM IS PLACED IN UNPROTECTED LOCATION DIRECTLY UNDER WINDSHIELD DRAIN. NISSAN OFFERS NO FIX. *TR
NHTSA ODI #10522748
Official recalls
4Oct 17, 2005
ON CERTAIN MINI VANS EQUIPPED WITH A FOLDING THIRD ROW REAR SEAT, WHEN THE THIRD ROW SEAT IS RAISED FROM ITS STOWED POSITION, IT ENGAGES STRIKER BRACKETS, ONE ON EACH SIDE OF THE SEAT CUSHION. THE FOLD-AWAY STRIKER LOOP IS WELDED TO A MOUNTING BRACKET. THE STRIKER MAY BECOME DETACHED FROM ITS MOUNTING BRACKET DUE TO A BROKEN WELD AT THE POINT OF ATTACHMENT TO THE BRACKET.
Consequence & remedy
Consequence: IF THE THIRD ROW SEAT STRIKER WELD FAILS, THE STRIKER COULD SEPARATE FROM THE MOUNTING BRACKET. STRIKER SEPARATION COULD AFFECT THE RISK OF INJURY IN CERTAIN TYPES OF CRASHES.
Remedy: DEALERS WILL REPLACE THE THIRD ROW SEAT STRIKER BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Oct 13, 2005
ON CERTAIN MINI VANS, THERE IS A SEAT ADJUSTMENT MECHANISM THAT CONTAINS EXPOSED MOVING COMPONENTS LOCATED AT THE REAR INSIDE EDGE OF THE SECOND ROW SEAT.
Consequence & remedy
Consequence: WHEN THE OPERATOR ATTEMPTS SEAT ADJUSTMENT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM WHICH COULD CAUSE AN INJURY.
Remedy: ON EARLIER MODEL VEHICLES BUILT THROUGH JUNE 28, 2004, DEALERS WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE, RIVET A PLASTIC REINFORCEMENT TO BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE TO THE INBOARD SIDE SHIELD. ON VEHICLES PRODUCED FROM JUNE 29, 2004 THROUGH SEPTEMBER 26, 2005, DEALERS WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE ON THE INBOARD SIDE SHIELD. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Apr 16, 2004
ON CERTAIN MINIVANS EQUIPPED WITH A POWER SLIDING DOOR(S), AT AN AMBIENT TEMPERATURE BELOW APPROXIMATELY 40 DEGREES FAHRENHEIT, THE ACTUATOR FOR THE POWER SLIDING DOOR(S) MAY EXPERIENCE BINDING DUE TO AN OUT-OF-SPECIFICATION CONDITION. IN ORDER TO OPEN, CLOSE OR REVERSE A POWER SLIDING DOOR, THE SHIFT SELECTOR LEVER MUST BE IN "PARK." IF THE ACTUATOR IS EXPERIENCING BINDING AND THE DRIVER SHIFTS THE VEHICLE OUT OF "PARK" WHILE A POWER SLIDING DOOR IS STILL CLOSING, THE DOOR LATCHES MAY NOT ENGAGE.
Consequence & remedy
Consequence: THIS CAN RESULT IN THE DOOR COMING OPEN UNEXPECTEDLY UPON RAPID ACCELERATION, AND AN OCCUPANT COULD FALL OUT OF THE DOOR AND BE INJURED.
Remedy: DEALERS WILL REPLACE THE ACTUATOR FOR THE POWER SLIDING DOOR(S). OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Mar 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE ADVANCED AIR BAG REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG FOR THE FRONT PASSENGER SEAT IS TO BE TURNED OFF (SO THAT IT DOES NOT INFLATE) WHEN CERTAIN OCCUPANTS, SUCH AS SMALL CHILDREN, ARE IN THE FRONT SEAT.
Consequence & remedy
Consequence: THIS REDUCES THE RISK OF SUCH OCCUPANTS BEING UNJURED BY AN INFLATING AIR BAG IN A COLLISION.
Remedy: DEALERS WILL INSPECT THE FRONT PASSENGER SEAT CUSHION/SENSOR ASSEMBLY. IF THE SEAT CUSHION/SENSOR IS FOUND TO BE OPERATING IMPROPERLY, THE SEAT WILL BE REMOVED AND RECALIBRATED. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
EA05012 · Finger Pinch Point
Opened Aug 19, 2005 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
THE SEAT ADJUSTMENT MECHANISM CONTAINS EXPOSED MOVING COMPONENTS, LOCATED AT THE REAR EDGE OF THE SECOND ROW SEAT.WHEN THE OPERATOR ATTEMPTS TO ADJUST THE SEAT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM.NISSAN WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF NISSAN QUEST VEHICLES.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005, NISSAN WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL THREE TIE-DOWNS AND INSTALL A FLANGE TO THE INBOARD SIDE SHIELD.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH JUNE 28, 2004, IN ADDITION TO THE ABOVE CORRECTIVE ACTIONS, NISSAN WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE WITH THE CURRENT PRODUCTION SEAT LEVER. NISSAN NORTH AMERICA, INC. WILL RECALL 109,437 MY 2004-2005 NISSAN QUEST VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005.ODI IS AWARE OF A TOTAL OF 11 COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS REPORTING 11 FINGER INJURIES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V474.
PE05019 · Finger Pinch Point
Opened Apr 21, 2005 · Closed Aug 19, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
ODI HAS RECEIVED FIVE REPORTS ALLEGING THAT THE CONSUMER WAS INJURED USING THE VEHICLE'S SECOND-ROW SEAT RELEASE LEVER TO FOLD THE SECOND ROW SEAT.NISSAN STATES, ...THE CUSTOMER OPERATION OF THE LEVER IN SOME CASES AND SUBSEQUENT ORIENTATION OF THEIR FINGERS IS DIFFERENT THAN EXPECTED.NISSAN ALSO REPORTED ADDITIONAL COMPLAINTS FOR A TOTAL OF 11 INJURIES.NISSAN MODIFIED THE LEVER FOR PRODUCTION TWICE.THE LATEST (SECOND MODIFICATION) DESIGN PROVIDES A LARGER SIZED HANDLE THAT CONTAINS A CUP INTO WHICH THE SEAT OCCUPANT CAN PLACE THEIR FINGERS TO OPERATE THE ADJUSTMENT LEVER.NISSAN REPORTS NO INJURIES ASSOCIATED WITH THE CUP DESIGN LEVER.BEGINNING JUNE 2004, NISSAN INITIATED A CUSTOMER SATISFACTION INITIATIVE THAT INCLUDED REPLACING THE ORIGINAL DESIGN HANDLE WITH THE FIRST MODIFICATION HANDLE (THIS IS NOT THE CUP DESIGN HANDLE MENTIONED ABOVE).THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-012) TO ALLOW FURTHER ANALYSIS OF THE ISSUE.
PE04027 · POWER-SLIDING Door Opening
Opened Mar 15, 2004 · Closed Jun 2, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Illustration