Engine And Engine CoolingUnknown Or OtherVisibility
AS HAS HAPPENED TO CLOSE TO 100% OF QUEST/MERCURY VILLAGER OWNERS, I HAVE CRACKED MANIFOLDS, MISSING MANIFOLD STUDS, AND SEVERAL BROKEN MANIFOLD STUDS. THIS RESULTS IN POOR STARTS, EXHAUST LEAKS, AND A NOTICEABLE "CLACKING" (EXHAUST LEAK) UPON ACCELERATION. MY VEHICLE HAS 118K MILES. I UNDERSTAND THE LABOR FOR A COMPL…
Read full complaint
AS HAS HAPPENED TO CLOSE TO 100% OF QUEST/MERCURY VILLAGER OWNERS, I HAVE CRACKED MANIFOLDS, MISSING MANIFOLD STUDS, AND SEVERAL BROKEN MANIFOLD STUDS. THIS RESULTS IN POOR STARTS, EXHAUST LEAKS, AND A NOTICEABLE "CLACKING" (EXHAUST LEAK) UPON ACCELERATION. MY VEHICLE HAS 118K MILES. I UNDERSTAND THE LABOR FOR A COMPLETE FIX CAN RUN OVER $1000, WHILE PARTS RUN UNDER $100. I HAVE CONTACTED 1-800-NISSAN1 WITH THIS ISSUE AND THE OPERATOR WAS AWARE OF THIS VERY COMMON, SERIOUS PROBLEM AND AFFIRMED THAT I WOULD BE CONTACTED WITH ANY POSSIBLE COMPENSATION.
NHTSA ODI #10070669
Mileage unknown · Jan 2, 2001
Visibility
REAR WINDOW KEEPS EXPLODING IN A LOT OF PIECES AFTER STARTING UP VEHICLE. *AK
NHTSA ODI #877264
Mileage unknown · Jun 21, 1999
Visibility
WHILE DRIVING AT 55 MPH THE REAR WINDOW BOLTS CAME OUT OF THE WINDOW. *AK
NHTSA ODI #840592
Mileage unknown · May 13, 1999
Electrical SystemSeatsVisibility
BRAKE LIGHTS: THE ELECTRICAL WIRING IS TOO SHORT. MUST BE FIXED AT LEAST 4-5 TIMES PER WEEK OTHERWISE, WHEN BRAKE PEDAL IS PRESSED, BRAKE LIGHT DOESN'T LIGHT UP. SEATS: RATTLE & MOVE EVEN WHEN ENGAGED. WINDSHIELD WASHER MOTOR: DOES NOT WORK AT ALL. MAYBE ONCE EVERY 4-5 MONTHS (IF I'M LUCKY), THEREFORE, HAVE TO POUR WATER ON …
Read full complaint
BRAKE LIGHTS: THE ELECTRICAL WIRING IS TOO SHORT. MUST BE FIXED AT LEAST 4-5 TIMES PER WEEK OTHERWISE, WHEN BRAKE PEDAL IS PRESSED, BRAKE LIGHT DOESN'T LIGHT UP. SEATS: RATTLE & MOVE EVEN WHEN ENGAGED. WINDSHIELD WASHER MOTOR: DOES NOT WORK AT ALL. MAYBE ONCE EVERY 4-5 MONTHS (IF I'M LUCKY), THEREFORE, HAVE TO POUR WATER ON WINDSHIELD ON MY OWN.
NHTSA ODI #706472
Mileage unknown · Mar 11, 1999
Visibility
UPON EVALUATION, THE SOLDER POINTS IN THE MODULE WERE NOT PERMANENT AS HEAT WORE AWAY THE CONTACTS.
NHTSA ODI #704319
Mileage unknown · Feb 26, 1999
Visibility
CONSUMER NOTICE LEAVES BUILDUP IN VENTILATION SYSTEM. DEALER NOTIFIED, AND REFUSED TO ACCEPT RESPONABILITY. SEEKING HELP FROM NHSTA. *AK
NHTSA ODI #835335
Mileage unknown · Dec 15, 1998
VisibilityFireInjury
WHEN OPERATING HEATER IT SMELLS LIKE BURNING LEAVES. ALSO, WHILE OPERATING HEATER A BURST OF FLAMES SHOT FROM THE INSIDE BOTTOM VENT, CAUSING A FIRE THAT BURNED THE CHILD THAT WAS SITTING IN THE PASSENGER'S SEAT. DEALER HAS NOT BEEN CONTACTED.*AK
NHTSA ODI #832276
Mileage unknown · Dec 1, 1998
VisibilityFire
RECALL WORK PERFORMED ON THE INSTALLATION OF A SCREEN ON THE FRESH AIR INTAKE TO PREVENT DEBRIS FROM ENTERING VEHICLE RESULTING IN VEHICLE FIRE, HOWEVER FAILED AFTER REPAIR AND VEHICLE FIRE EXPERIENCED. (ATTORNEY FOR CONSUMER).
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
LEAVES AND OTHER FOREIGN MATERIAL CAN ENTER THROUGH THE COWL PANEL AIR INTAKE DURING OPERATION OF THE FRONT HEATER AND/OR AIR CONDITIONING SYSTEM RESULTING IN A BUILD-UP OF MATERIAL IN THE PLENUM. THIS CAN LEAD TO NOISE, ODORS, OR IN SOME CASES, IGNITION OF THESE MATERIALS.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL HEATER/AIR CONDITIONING SYSTEM INTAKE SCREEN.
FUEL FILLER HOSES MAY HAVE BEEN CUT PRIOR TO INSTALLATION BY A UTILITY KNIFE USED TO OPEN THE SHIPPING BOX.
Consequence & remedy
Consequence: FUEL LEAKAGE CAN RESULT IF THE CUT EXTENDED THROUGH THETHICKNESS OF THE HOSE WALL. LEAKING FUEL CAN RESULT IN A FIRE IF EXPOSEDTO A SOURCE OF IGNITION.
THE SERVICE BRAKE MASTER CYLINDER WAS NOT PROPERLY ASSEMBLED OR COULD HAVE BEEN DAMAGED BY THE EVACUATION AND FILLING OF THE BRAKE SYSTEM AT THE ASSEMBLY PLANT.
Consequence & remedy
Consequence: THIS CAN RESULT IN A PARTIAL BRAKE SYSTEM FAILURE DUE TOINTERNAL MASTER CYLINDER LEAKAGE WHICH CAN CAUSE LOSS OF BRAKING ON TWO OF THEFOUR WHEELS. IF THIS OCCURS, THERE WOULD BE INCREASED BRAKE PEDAL TRAVEL, HIGHERPEDAL EFFORTS AND INCREASED STOPPING DISTANCES.
Remedy: A NEW BRAKE MASTER CYLINDER WILL BE INSTALLED.
ONE OR BOTH OF THE BOLTS SECURING THE AUTOMATIC SEAT BELT RESTRAINT SYSTEM TRACKS TO THE B-PILLARS WERE NOT ADEQUATELY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE AUTOMATIC SEAT BELTSYSTEM TRACK JOINTS HAVING LESS THAN DESIGN STRENGTH, AND INCREASE THE RISK OFINJURY TO THE SEAT OCCUPANT IN THE EVENT OF A COLLISION OR SUDDEN STOP.
Remedy: DEALERS WILL TIGHTEN THE PASSIVE RESTRAINT SYSTEM TRACK MOUNTING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA00015 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
Additional source detail variants (2)
Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.
PE93021 · Backlite Shattering
Opened Apr 1, 1993 · Closed Jul 28, 1993
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
1993 Nissan Quest Problems, Complaints & Recalls | Skip That Year
Illustration