IllustrationIN THE LAST 4 YEARS I'VE REPLACED EMISSIONS SYSTEM BRAKES ROTORS AIR CONDITIONING SYSTEM EXHAUST SYSTEM RADIATOR AND TRANSMISSION. CAR WAS VIBRATING SHAKING CUTTING OUT LEAKING EXHAUST FUMES AND EMISSIONS SYSTEM FAILED.
2005 Nissan Pathfinder
Owner reports · Recalls · Investigations
More warning signs than most Pathfinder years
Owner complaints for the 2005 Nissan Pathfinder are substantially higher than the model-year median of 97.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pathfinder years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
5625–50K
20650–75K
29075–100K
318100–150K
60150K+
956 reports with mileage · 94 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 585 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 290 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 186 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports6 fire reports7 injury reports
Fuel/propulsion System complaints
31 reportsI HAS TO REPLACE THE 2 GASKETS ON THE OIL GALLEY GASKET IN THE TIMING COVER. IT COAT ME OVER 1000 DOLLARS AND I HAD A 2005 NISSAN XTERRA THAT HAD 5HE SAME PROBLEM AND IT COST BE THOUSANDS TO FIX AND I HAD TO JUNK IT BECAUSE IT SMOKED SO MUCH THEN VALVE TRAIN GOT F RIED..
TL* THE CONTACT OWNS A 2005 NISSAN PATHFINDER. THE CONTACT STATED THAT THE DIGITAL FUEL GAUGE DISPLAYED THE INCORRECT FUEL MILEAGE. AS A RESULT, THE VEHICLE COMPLETELY SHUT OFF DUE TO NO FUEL BEING INSIDE THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN PATHFINDER. THE CONTACT STATED THAT THE DIGITAL FUEL GAUGE DISPLAYED THE INCORRECT FUEL MILEAGE. AS A RESULT, THE VEHICLE COMPLETELY SHUT OFF DUE TO NO FUEL BEING INSIDE THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.
MY NISSAN CRANKS BUT DON'T START, DON'T KNOW WAS WRONG.
FUEL GAUGE IS FAULTY. FUEL LEVEL WILL READ 1/2 FULL AND YET APPROACH EMPTY. THE VEHICLE HAS RUN OUT OF GAS FOUR TIMES, PUTTING THE DRIVER AND OCCUPANTS IN A DANGEROUS POSITION.
FUEL TANK SENDING UNIT, SHOWS FUEL TANK EMPTY WHEN IS FULL
TL* THE CONTACT OWNS A 2005 NISSAN PATHFINDER. AFTER THE CONTACT PLACED FUEL IN THE VEHICLE, THE CONTACT RESTARTED THE ENGINE AND NOTICED THAT THE FUEL GAUGE INDICATOR ON THE INSTRUMENT PANEL SHOWED EMPTY THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SENSOR N…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN PATHFINDER. AFTER THE CONTACT PLACED FUEL IN THE VEHICLE, THE CONTACT RESTARTED THE ENGINE AND NOTICED THAT THE FUEL GAUGE INDICATOR ON THE INSTRUMENT PANEL SHOWED EMPTY THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY AND THE CONTACT NEEDED TO PAY FOR THE REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 92,377. UPDATED 07/11/17*LJ *AS
FAULTY FUEL GAUGE SENSOR: DTE GAUGE DOES NOT RESET. ENGINE CHECK LIGHT
TL* THE CONTACT OWNS A 2005 NISSAN PATHFINDER. WHILE DRIVING 50 MPH, THE FUEL GAGE INDICATOR FAILED TO DISPLAY THE CORRECT FUEL LEVEL. THE VEHICLE SLOWED DOWN AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER DIAGNOSED THAT THE FUEL SYSTEM STORAGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT INC…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN PATHFINDER. WHILE DRIVING 50 MPH, THE FUEL GAGE INDICATOR FAILED TO DISPLAY THE CORRECT FUEL LEVEL. THE VEHICLE SLOWED DOWN AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER DIAGNOSED THAT THE FUEL SYSTEM STORAGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V075000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.
MY DAUGHTER TOOK OUR BABY TO THE DAYCARE AND WAS ON THE HIGHWAY IN THE BITTER COLD IN OHIO AS SHE RAN OUT GAS. SHE CALLED AAA WHO SHOWED 2 HOURS LATER. IN THE MEANTIME SHE WAS WITHOUT ANY HEAT ON THE HIGHWAY IN12 TEMP. ALTHOUGH THE GAUGE SHOWED 1/2 OF TANK OF GAS, THE CAR WAS EMPTY. I BOUGHT THE CAR WITH MY TO NJ COUNTING THE MI…
Read full complaint
MY DAUGHTER TOOK OUR BABY TO THE DAYCARE AND WAS ON THE HIGHWAY IN THE BITTER COLD IN OHIO AS SHE RAN OUT GAS. SHE CALLED AAA WHO SHOWED 2 HOURS LATER. IN THE MEANTIME SHE WAS WITHOUT ANY HEAT ON THE HIGHWAY IN12 TEMP. ALTHOUGH THE GAUGE SHOWED 1/2 OF TANK OF GAS, THE CAR WAS EMPTY. I BOUGHT THE CAR WITH MY TO NJ COUNTING THE MILES SO I WOULD NOT RAN OUT OF GAS. I HAD IT FIXED AT THE WINDSOR NISSAN. THEY DID AN EXCELLENT JOB. THE PROBLEM IS THAT I PAID $500+ FOR A PROBLEM THAT WAS RECALLED. THIS HAS BEEN PUBLISHED EVEN BY THE US DEPARTMENT OF TRANSPORTATION. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMIN. WROTE A LETTER (I CAN PROVIDE) ON MARCH 3 2010, INFORMING NISSAN OF THE DANGER OF THIS ISSUE. THE REF NUMBER IS 10V-075 SUBJECT FUEL SYSTEM GASOLINE STORAGE AUXILIARY TANK. THE LETTER GOES TO EXPLAIN THE ISSUE WHICH COVERS MY CAR AND SAYS "THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL IN TRAFFIC, INCREASING THE RISK OF A CRASH. ANOTHER REF NUMBER REGARDING THE NISSAN FUEL GASOLINE SYSTEM NUMBER- 10V-075000, AND ANOTHER SERVICE BULLETIN NTB-07-069C, ALL WITH THE SAME ISSUE ABOUT THE GAUGE BEING FAULTY AND READING THAT THE CAR HAS GAS WHEN IT DOESN'T. MY DAUGHTER WAS LUCKY THAT SHE HAD JUST DROPPED OFF THE BABY AND WHEN THE CAR RAN OUT OF GAS SHE WAS ABLE TO PULL TO THE SIDE WITHOUT ANY ACCIDENT. HOWEVER, BEING PUT THROUGH THE EXPERIENCE OF BEING IN OHIO IN WINTER WITHOUT HEAT IN A COLD CAR FOR 2 HOURS IS UNFORGIVABLE!! ALTHOUGH, I CALLED HEADQUARTER SEVERAL TIMES, THEY ACTED LIKE THEY DID NOT NOT ANYTHING ABOUT THIS ISSUE AND REFUSED TO REFUND MY MONEY BACK. I HAVE ALL THE SERVICES BULLETIN AND WILL BE MORE THEN HAPPY TO SHARE, ALTHOUGH NISSAN CAN CALL US DEPARTMENT OF TRANSPORTATION. THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION.PRODUCT_OR_SERVICE: HAD WORK DONE TO FUEL SYSTEM. I FILLED A COMPLAINT WITH THE BBB#91355526 FOR NOTHING. PLS HELP!!
Official recalls
210V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V690000 · Air Bags:frontal
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.