TL*THE CONTACT OWNS A 2004 NISSAN MURANO. SINCE THE VEHICLE WAS PURCHASED, THE TIRE PRESSURE MONITORING SYSTEM INDICATED THAT THE TIRES BECAME FLAT WHEN THE TEMPERATURE WAS AT 36 DEGREES OR BELOW. THE LOWER THE TEMPERATURE, THE MORE THE SYSTEM WOULD INDICATE THAT THE PRESSURE WAS LOW ALTHOUGH IT WAS NOT. SHE TOOK THE VEHICLE TO …
Read full complaint
TL*THE CONTACT OWNS A 2004 NISSAN MURANO. SINCE THE VEHICLE WAS PURCHASED, THE TIRE PRESSURE MONITORING SYSTEM INDICATED THAT THE TIRES BECAME FLAT WHEN THE TEMPERATURE WAS AT 36 DEGREES OR BELOW. THE LOWER THE TEMPERATURE, THE MORE THE SYSTEM WOULD INDICATE THAT THE PRESSURE WAS LOW ALTHOUGH IT WAS NOT. SHE TOOK THE VEHICLE TO THE DEALERSHIP AND THEY ADVISED HER ADD AIR TO THE TIRE UNTIL IT REACHED 38 PSI. SHE CALLED THE MANUFACTURER AND WAS TOLD THAT THE ENGINEERS HAD NOT ADDRESSED THE ISSUE AND TO OVER INFLATE THE TIRES. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 46,600. THE FAILURE MILEAGE WAS APPROXIMATELY 6,000.
NHTSA ODI #10316730
29,000 miles · Dec 6, 2008
Fuel System, GasolineTires
DID A THROTTLE BODY CLEANING ON A NISSAN MURANO AND THE CHECK ENGINE LIGHT CAME ON. THE DEALER SAID IT WAS A MONEY MAKER AND MANY SHOP THAT CLEAN THE THROTTLE BODY HAVE TO COME TO THEM FOR THE RE-LEARNING OF THE IDLE AIR CONTROL VALVE. THIS IS CRAZY ,I HAVE DONE THIS ON MY PORSCHE AND MY FORDS AND CHEVY AND HAVE NEVER HAD THIS H…
Read full complaint
DID A THROTTLE BODY CLEANING ON A NISSAN MURANO AND THE CHECK ENGINE LIGHT CAME ON. THE DEALER SAID IT WAS A MONEY MAKER AND MANY SHOP THAT CLEAN THE THROTTLE BODY HAVE TO COME TO THEM FOR THE RE-LEARNING OF THE IDLE AIR CONTROL VALVE. THIS IS CRAZY ,I HAVE DONE THIS ON MY PORSCHE AND MY FORDS AND CHEVY AND HAVE NEVER HAD THIS HAPPEN. NISSAN SHOULD HAVE A WARNING STICKER ON THE THROTTLE BODY TO SEE MANUAL -THE MANUAL SHOULD STATE DO NOT CLEAN OR YOU WILL NEED TO GO TO DEALER TO RE-LEARN THE IDLE AIR CONTROL SYSTEM. *TR
NHTSA ODI #10250950
9,700 miles · Jun 29, 2005
Tires
ON 5-25-05 MY RIGHT REAR TIRE BLEW UP ON MY 6 MONTHS OLD, 9700 MILES NISSAN MURANO GOING UPHILL AT 65 MPH ON INTERSTATE 80. CAAA CAME AND TOOK ME TO A GOODYEAR TIRE DEALER 5 MILES AWAY.THEY DO NOT HAVE THE TIRE. THE DEALER CALLED UP 5 GOODYEAR TIRE DEALERS WITHIN 40 MILES RADIUS AND ALL OF THEM DO NOT HAVE IT BUT CAN GET IT TH…
Read full complaint
ON 5-25-05 MY RIGHT REAR TIRE BLEW UP ON MY 6 MONTHS OLD, 9700 MILES NISSAN MURANO GOING UPHILL AT 65 MPH ON INTERSTATE 80. CAAA CAME AND TOOK ME TO A GOODYEAR TIRE DEALER 5 MILES AWAY.THEY DO NOT HAVE THE TIRE. THE DEALER CALLED UP 5 GOODYEAR TIRE DEALERS WITHIN 40 MILES RADIUS AND ALL OF THEM DO NOT HAVE IT BUT CAN GET IT THE NEXT DAY AUBURN NISSAN HAS IT AND I GOT IT REPLACED THERE. 5-31-05, I CALLED NISSAN USA CUSTOMER RELATIONS AND THEY TOLD ME TO CALL GOODYEAR GOODYEAY SUPERVISOR SAID THAT I MUST HAVE THE REST OF THE TIRE FOR INSPECTION AND ALSO SAID THAT AUBURN NISSAN IS NOT AGOODYEAR TIRE DEALER. ON 6-13-05 NISSAN USA ASKED ME TO CALL GOODYEAR AGAIN AND THEY SAID THE SAME THING IT IS NOT FAIR THAT I HAVE TO BEAR WITH ALL THESE. 1. MY CAR IS ONLY 6 MONTHS OLD WITH 9700 MILES ON IT 2. MY LAST SERVICE WAS AT DORITO BROS NISSAN ON 3-1-05 3. I AM 120 MILES FROM HOME AND CANNOT WAIT FOR THE NEXT DAY FOR THE NEW TIRE FROM A GOODYEAR TIRE DEALER. 4. 5 GOODYEAR TIRE DEALERS DO NOT HAVE THAT TIRE 5. GOODYEAR INSISTED ON INSPECTING TTHE TIRE AND HOW CAN I GET IT WHEN IT GOT SEPARATED AND ROLL TO THE MIDDLE OF THE DIVIDER. 6. GOODYEAR INSISTED THAT AUBURN NISSAN IS NOT A TIRE DEALER. 7. NISSAN USA SAID THAT IT IS NOT THEIR PROBLEM AND THIS HA TO DO WITH GOODYAER 8. GOODYEAR WAS NOT MY CHOICE 9. NISSAN HAS THE FITTED WHEN I BOUGHT THE CAR 10. NISSAN SHOULD BE RESPONSIBLE TOO OR NEGIOTIATE WITH GOODYEAR PLEASE KINDLY LOOK INTO THIS, THANKS TONY
NISSAN IS RECALLING 362,891 MY 2003-2007 MURANO VEHICLES. THE INTAKE AIR DUCTS, WHICH ARE CONNECTED TO THE INTERMEDIATE RESONATOR IN THE AIR INTAKE SYSTEM OF THE ENGINE, MAY SEPARATE FROM THE RESONATOR WITH ENGINE MOVEMENT. THIS SEPARATION OCCURS DUE TO THE PREMATURE AGING OF THE MATERIAL USED IN THE INTAKE AIR DUCTS WHICH CAUSES EXCESSIVE SHRINKING.
Consequence & remedy
Consequence: ENGINE MAY STALL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE/REPAIR THE APPROPRIATE COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 24, 2009. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON SOME SPORT UTILITY VEHICLES, IN CERTAIN HIGH SPEED FRONTAL CRASHES, THE WEBBING OF A REAR OUTBOARD SEAT BELT MAY CONTACT THE REAR SEAT BACK HINGE WHERE IT CAN BE CUT BY THE SHARP EDGE OF THE METAL PORTION OF THE HINGE.
Consequence & remedy
Consequence: IF THE WEBBING IS COMPLETELY SEPARATED, IT CAN INCREASE THE RISK OF INJURY TO AN OCCUPANT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTORS OVER THE WEBBING OF THE REAR SEAT BELTS. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO THE LOCATION OF THE FORWARD EDGE OF THE FUEL TANK, IN THE EVENT THAT A VEHICLE FRONT TIRE RUNS OVER A SMALL, SHARP OBJECT IN THE ROAD, CATCHES IT AND PROPELS IT TOWARDS THE REAR OF THE VEHICLE, IT MAY STRIKE AND PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: A PUNCTURED TANK COULD INCREASE THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL PROTECTORS IN FRONT OF THE TANK FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN SPORT UTILITY VEHICLES, THERE IS A POSSIBILITY THAT A WIRE BREAKING INSIDE THE ALTERNATOR COULD STOP THE BATTERY FROM CHARGING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CHARGER WARNING AND BRAKE WARNING LAMPS WILL IMMEDIATELY COME ON AND THE BATTERY WILL BEGIN TO DISCHARGE. AFTER A SHORT TIME, THE ENGINE WILL GO INTO A "FALL SAFE" CONDITION WHICH WILL LIMIT VEHICLE SPEED. THE ENGINE WILL STOP RUNNING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE ALTERNATOR WITH A NEW VERSION WHICH HAS BEEN MODIFIED TO PREVENT MOVEMENT OF THE COIL. THE RECALL BEGAN ON AUGUST 1, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
PE08065 · Driver Seat Anchor Failure
Opened Nov 18, 2008 · Closed Jul 2, 2009
Status: closed (inferred from source dates) · Seats
THIS INVESTIGATION CONCERNS STRUCTURAL FAILURE OF THE ANCHOR/BRACKET ON THE LEFT REAR SIDE OF THE DRIVER'S SEAT.THE CONCERN IS THAT SUCH FAILURES MAY ALTER THE DRIVER'S SEATED POSITION SO AS TO REDUCE EFFECTIVENESS OF THE OCCUPANT PROTECTION SYSTEM OR POTENTIALLY COMPROMISE VEHICLE CONTROL.FAILURE OF THE SUBJECT ANCHOR BRACKET RESULTS FROM METAL FATIGUE AND CAUSES REARWARD TILTING OF THE DRIVER'S SEAT.THESE FAILURES USUALLY OCCUR DURING DRIVER INGRESS BUT MAY ALSO OCCUR WHILE THE VEHICLE IS BEING OPERATED.THE SAFETY RELATED CONCERNS DURING ACTUAL VEHICLE USE WERE NOT VALIDATED BY THIS INVESTIGATION.WHILE THE NUMBER OF COMPLAINTS OF THIS PROBLEM IS RELATIVELY HIGH, ONLY THREE VERY MINOR, UNDOCUMENTED INJURIES WERE REPORTED.THE REPORTED INJURIES OCCURRED DURING DRIVER INGRESS, NOT WHILE THE VEHICLE WAS IN MOTION.INVESTIGATION DISCLOSED THAT THE APPARENT RISK OF COMPROMISE TO VEHICLE CONTROL HAS NOT BEEN DEMONSTRATED.INVESTIGATION ALSO DISCLOSED THAT THE APPARENT RISK OF COLLAPSE OF THE DRIVER'S SEAT BACK HAS NOT BEEN DEMONSTRATEDA SAFETY RELATED DEFECT TREND WAS NOT IDENTIFIED AND THIS INVESTIGATION HAS BEEN CLOSED.
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
Fuel System, Other:storage:tank Assembly
ODI OPENED A PRELIMINARY EVALUATION BASED ON FOUR VEHICLE OWNER QUESTIONNAIRES (VOQ'S) INDICATING THAT THE FUEL TANKS WEREPUNCTURED BY ROAD DEBRIS UNDER NORMAL, NON OFF-ROAD DRIVING CONDITIONS.AS OF NOVEMBER 30, 2005, THE COMPLAINT TOTAL INCREASED TO 12.NISSAN SUPPLIED ODI WITH 31 COMPLAINTS OF FUEL TANK PUNCTURES, INCLUDING 26 NOT PREVIOUSLY KNOWN TO ODI FROM THE VOQ RECORDS. IN A LETTER DATED JANUARY 9, 2006, NISSAN NORTH AMERICA, INC. NOTIFIED ODI OF ITS PLAN TO RECALL APPROXIMATELY 209,000 MODEL YEAR 2003 - 2006 NISSAN MURANO VEHICLES BUILT FROM APRIL 24, 2002 (START OF PRODUCTION OF MY 2003) THROUGH NOVEMBER 24, 2005 (INCLUDING A PORTION OF MY 2006 VEHICLES) TO CORRECT A DEFICIENCY IN FUEL TANK SHIELDING FROM ROAD DEBRIS.THIS RECALL HAS BEEN DESIGNATED NHTSA NO. 06V-003.RECALLED VEHICLES WILL BE FITTED WITH PROTECTIVE SHIELDING FOR THE FRONTAL PORTION OF THE FUEL TANK TO REDUCE THE POSSIBILITY OF PUNCTURE BY PROJECTILES FROM THE FRONT WHEELS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
Electrical System
ODI RECEIVED 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE ON MY 2003-2004 MURANO (SUBJECT) VEHICLES.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.BASED ON THESE COMPLAINTS, ODI OPENED PE04-077 AND LATER UPGRADED TO EA05-006 FOR THE SUBJECT VEHICLES.DURING EA05-006, ADDITIONAL FAILURE DATA WERE IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE.ON JULY 12, 2005, NISSAN NOTIFIED NHTSA OF A SAFETY DEFECT ON MY 2003-2005 MURANO VEHICLES PRODUCED FROM APRIL 8, 2002 AND SEPTEMBER 24, 2004 (RECALL 05V-319).THE NOTIFICATION STATED THAT AN OPEN CIRCUIT IN THE ALTERNATOR CAN OCCUR DUE TO WIRE FATIGUE CAUSED BY MOVEMENT OF THE ROTOR COIL DURING RAPID CHANGES IN ENGINE SPEED IN VEHICLES EQUIPPED WITH A CONTINUOUSLY VARIABLE TRANSMISSION (CVT).HIGHER ENGINE COMPARTMENT TEMPERATURE IN THE MURANO COMPARED TO OTHER NISSAN MODELS MAY ALSO BE A CONTRIBUTING FACTOR TO THE WIRE FATIGUE.NISSAN ALSO REPORTED THAT WHEN THIS HAPPENS, THE CHARGE WARNING AND BRAKE WARNING LAMPS WILL ILLUMINATE AND THE BATTERY WILL BEGIN TO DISCHARGE.AFTER A SHORT TIME, THE ENGINE WILL THEN ENTER A FAIL SAFE MODE THAT LIMITS VEHICLE SPEED.VERY SHORTLY AFTER REACHING THIS CONDITION, THE ENGINE WILL STOP.NHTSA'S TESTING, HOWEVER, SHOWED THAT ALTHOUGH THE WARNING LAMPS ILLUMINATE, THE VEHICLE SPEED IS LIMITED TO ONLY 4-7 MPH RATHER THAN WHAT NHTSA CONSIDERS A FAIL SAFE MODE. NISSAN WILL INSTRUCT OWNERS TO RETURN THEIR VEHICLES TO ANY NISSAN DEALER FOR AN ALTERNATOR INSPECTION AND REPLACEMENT, IF REQUIRED.NOTE:SOME VEHICLES MAY HAVE HAD THE NEWLY DESIGNED ALTERNATOR PREVIOUSLY INSTALLED UNDER WARRANTY.CONSEQUENTLY, THIS INVESTIGATION IS CLOSED.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY AND TAKE FURTHER ACTION IF WARRANTED.
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Additional source detail variants (2)
Electrical System:alternator/generator/regulator
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
Electrical System
ODI OPENED PE04-077 BASED ON 14 REPORTS OF ALLEGED ENGINE STALLING DUE TO ALTERNATOR FAILURE.ALL OF THE COMPLAINTS REPORTED THAT THE VEHICLE COULD NOT BE RESTARTED AFTER THE STALL OCCURRED.DURING PE04-077, ADDITIONAL FAILURE DATA WAS IDENTIFIED AS NOTED IN THE FAILURE REPORT SUMMARY ABOVE . DURING THE INVESTIGATION, NISSAN IDENTIFIED THAT THERE HAD BEEN ALTERNATOR WARRANTY REPLACEMENTS DUE TO AN OPEN CIRCUIT IN THE ROTOR COIL CAUSED BY WIRE FATIGUE. ODI?S ANALYSIS SHOWS FAILURE RATES THAT ARE OF CONCERN TO ODI AND INDICATES THAT THE ALLEGED DEFECT IS CONTINUING TO OCCUR IN THE SUBJECT VEHICLES.ODI'S ANALYSIS ALSO SHOWS THAT NEARLY ALL OF THE ALTERNATOR WARRANTY CLAIMS SUBMITTED RESULTED IN ENGINE STALLS AND AT LEAST 25% OF THE ENGINE STALLS RESULTED IN A NO RESTART CONDITION.HOWEVER, IN 71% OF THE WARRANTY DATA SUBMITTED, ODI HAS NOT BEEN ABLE TO DETERMINE IF THE CONSUMER COULD RESTART THE VEHICLE.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER INVESTIGATE THIS CONCERN, TO ASSESS THE POTENTIAL SAFETY-RELATED CONSEQUENCES, AND TO DETERMINE THE SCOPE OF THE AFFECTED POPULATION.
2004 Nissan Murano Problems, Complaints & Recalls | Skip That Year
Illustration