2020 Nissan Leaf

I am submitting this complaint due to Nissan's lack of action on a critical safety recall that has remained open without a remedy for over a year (NHTSA Recall Number 24V-700 / Nissan Recall Number R24B2). The recall involves a manufacturing defect in the high-voltage battery that can cause overheating and fire during DC fast charging. This is a severe safety risk, not only to owners but also to nearby vehicles and property at charging stations. Nissan’s only response has been to tell owners not to use DC fast charging, which was inadequate as a temporary measure and unacceptable as a long-term solution. Without access to DC fast charging, vehicle usability is severely compromised. Daily commuting is difficult, and long-distance travel is nearly impossible. Level 1 and 2 charging do not provide practical alternatives, and many owners rely on DC fast charging as their only feasible option. This feature is a basic expectation of modern EV ownership, and had I known I would lose it indefinitely, I would never have purchased this vehicle. After a full year, Nissan has provided no remedy, no timeline, and no meaningful communication. Even if a fix were announced today, implementation would take additional weeks or months. This is not a timely response to a major safety and usability issue. As an affected owner, I expect one of the following: (1) Nissan issues and implements a permanent fix within 30 days, (2) provides a free loaner vehicle until a remedy is available, or (3) repurchases the defective vehicles from me and other affected owners. Continuing with no action is unacceptable. As a repeat Nissan customer, this experience has been deeply disappointing and has caused me to lose confidence in the brand.

The contact owns a 2020 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 24V700000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Note: Searching for similar complaints I found them under "Engine", "Electrical", and "Fuel". There are many such complaints! My 2020 Nissan Leaf has been under a recall notice since September of 2024 (12 months ago). Nissan warned the battery may catch fire during level 3 (rapid) charging. Nissan ordered owners not to use rapid chargers until a fix was in place. Such a fix was (and still is) promised by March 2025. That date is 6 months past now and yet their website still proclaims it. This, to me, demonstrates that Nissan is not actively working on the problem. They seem content to have shifted the burden of dealing with the problem onto their customers. Rapid charging is not a luxury, especially with large capacity batteries. Fully charging the car in 2-3 hours instead of 10-12 hours is a key selling point of the vehicle. To remove it amounts to a bait and switch. One year is an extremely generous amount time to allow for a solution. Obviously, they want a software solition to avoid the high cost of replacing the batteries. Obviously, they can't find a software solution. It is time for them to be forced to accept the higher cost consequence of releasing a faulty product. P.S. During a phone conversation with Nissan customer service in late July, I was told (after many denials that anything was wrong with them proclaiming a fix in March 2025 in July 2025) that a fix would be available in November. As their site still says March 2025 I must assume that was a blatant lie to pacify me.

The contact owns a 2020 Nissan Leaf. The contact received notification of NHTSA Campaign Number: 24V700000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2020 Nissan Leaf. The contact stated that while driving 60 MPH, within minutes, the battery percentage indicator began to dramatically reduce from 100 percent down to 20 percent. The message to charge the vehicle immediately was displayed. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The contact expressed dissatisfaction with the dealer’s method of diagnosing the vehicle, because the vehicle was not test-driven. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V700000 (Electrical System); the VIN was included, but parts were not yet available. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 18,000.