Power Train. Review the 220 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 174 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 82 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports2 fire reports10 injury reports

Wheels complaints

2 reports

Clear category filter

34,183 miles · Feb 2, 2012

SuspensionWheels

Read full complaint

I PURCHASED MY TRUCK FROM THE NISSAN DEALER IN 2006 AND RECENTLY NOTICED THAT THE FRONT TIRES WERE WORN RATHER BADLY. I THOUGHT THIS WAS UNUSUAL SINCE I HAD LESS THAN 35,000 MILES ON THE TRUCK. I TOOK MY TRUCK TO SEARS AND ASKED THEM TO ALIGN THE WHEELS AND ROTATE THE TIRES. SEARS COULD NOT DO THE ALIGNMENT BECAUSE THEY WOULD HAVE TO ORDER AND INSTALL SOME PARTS THAT WERE NOT ON THE TRUCK AT MANUFACTURING. I CALLED NISSAN NORTH AMERICA TO FIND OUT IF THIS WAS NECESSARY AND WAS TOLD THAT FOR CERTAIN MAKE OF VEHICLES THIS WAS TRUE. I WOULD HAVE TO PAY FOR THE PARTS AND LABOR TO MAKE IT POSSIBLE TO ALIGN THE WHEELS TO RECOMMENDED SPECIFICATIONS. ACCORDING TO SEARS, SINCE THE CAMBERS AND CASTERS WERE NOT WITHIN RECOMMENDED SPECIFICATION, TIRE WEAR, HANDLING AND SAFETY PROBLEMS MAY RESULT. I FEEL THAT THE NECESSARY PARTS SHOULD HAVE BEEN INSTALLED DURING MANUFACTURING TO AVOID ANY POSSIBLE ACCIDENTS DUE TO PREMATURE TIRE WEAR. THE NISSAN DEALER SHOULD INSTALL THE NECESSARY PARTS FOR FREE AND NISSAN SHOULD NOTIFY ANY VEHICLE OWNERS AFFECTED BY THIS DEFICIENCY WHICH MIGHT CAUSE HANDLING AND SAFETY PROBLEMS. *KB

NHTSA ODI #10446335

16,700 miles · Oct 2, 2007

Wheels

Read full complaint

1. THE EVENT WAS DRIVING NORTHWEST OUT OF TUPELO, MISSISSIPPI, APPROXIMATELY 60 MPH ON ROUTE 78 WHICH IS A 4 LANE DIVIDED HIGHWAY. 2. THE DRIVERS SIDE FRONT WHEEL CAME OFF. I WAS ABLE TO MANEUVER THE VEHICLE OUT OF TRAFFIC & ONTO THE RIGHT SHOULDER OF THE ROAD WITHOUT COLLISION OR INJURY TO OURSELVES OR OTHERS. UPON INSPECTION THE WHEEL HAD SPLIT IN HALF AND SOME OF THE LUG BOLTS HAD ACTUALLY SHEARED OFF. THE VEHICLE IS A NEW NISSAN FRONTIER PICKUP TRUCK WHICH WAS PURCHASED NEW IN JANUARY, 2007. IT HAD LESS THAN 17,000 MILES ON IT AND HAD RECEIVED ROUTINE REQUIRED MAINTENANCE SERVICE PERFORMED BY NISSAN DEALERS/SERVICE DEPARTMENTS. THE LAST SERVICE WAS PERFORMED AT APPROXIMATELY 15,000 MILES AND INCLUDED TIRE ROTATION. 3. NISSAN CONSUMER AFFAIRS WAS CONTACTED, CONDUCTED AN INVESTIGATION & DETERMINED THAT THERE WAS NOT MECHANICAL FAILURE. THEY DID NOT ANSWER THE QUESTION OF WHAT WAS THE CAUSE OF THE FAILURE & COULD NOT HAVE HAD TIME TO DO METALLURGICAL TESTS ON THE COMPONENTS. THE VEHICLE WAS TOWED TO THE NISSAN DEALER IN TUPELO, MISSISSIPPI, AND THEY WERE ADVISED TO SAVE ALL OLD PARTS. I WAS ABLE TO FIND ONE HALF OF THE SPLIT WHEEL WHICH IS IN THE POSSESSION OF THE DEALER AT THIS TIME. NISSAN HAS SAID THIS IS NOT COVERED UNDER WARRANTY AND WILL NOT ACCEPT RESPONSIBILITY FOR EXPENSE OF PARTS & REPAIRS. *TR

NHTSA ODI #10204733

Official recalls

10V517000 · Engine And Engine Cooling

Oct 28, 2010

NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.

Consequence & remedy

Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

10V075000 · Fuel System, Gasoline:storage:auxillary Tank

Mar 3, 2010

NISSAN IS RECALLING CERTAIN MODEL YEAR 2006 AND MODEL YEAR 2008 FRONTIER, XTERRA AND PATHFINDER VEHICLES. THE MOLDED FUEL TANK SHELLS CAN DEFORM, CAUSING THE FUEL SENDER FLOAT ARM TO CONTACT AN EMBOSSMENT MOLDED INTO THE TANK SHELL CAUSING THE INSTRUMENT PANEL FUEL GAUGE TO SHOW THAT THE VEHICLE HAS APPROXIMATELY ONE QUARTER TANK WHEN THE FUEL TANK IS EMPTY.

Consequence & remedy

Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL IN TRAFFIC, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE FUEL LEVEL SENDING UNIT INSIDE THE FUEL TANK WITH A NEW ONE THAT HAS A MODIFIED FLOAT ARM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

08V690000 · Air Bags:frontal

Dec 29, 2008

NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.

Consequence & remedy

Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

06V092000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

Mar 30, 2006

ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.

Consequence & remedy

Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP26003 · Fuel Smell And Loss Of Motive Power

Opened Mar 30, 2026 · No close date supplied

Status: open (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline

The Office of Defects Investigation (ODI) received a Petition dated February 5, 2026, requesting an investigation into model year (MY) 2006 Nissan Frontier vehicles. The Petitioner alleges that the vehicle poses an imminent fire hazard due to “[a] powerful and persistent odor of raw gasoline” that he says “emanates from the vehicle” and “indicat[es] a breach in fuel system integrity.” He further alleges that the vehicles can experience sudden engine stalling “during startup and operation,” which he believes could cause collisions or loss of vehicle control. The Petitioner further alleges these symptoms are identical to conditions addressed in previous NHTSA recalls (10V-517, 07V-435, and 10V-075) and that the issues persist in the 2006 MY Nissan fleet despite these past actions. ODI is opening this Defect Petition to evaluate the Petitioner’s allegations and determine whether to grant or deny the Petition. The Petition can be viewed at NHTSA.gov under NHTSA Number 11718552.

Additional source detail variants (2)

Engine And Engine Cooling

Fuel System, Gasoline

DP12004 · Transmission Failures

Opened Jun 11, 2012 · Closed Oct 22, 2016

Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter

On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.

Additional source detail variants (5)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Power Train:automatic Transmission:cooling Unit And Lines

Power Train:automatic Transmission

Power Train:automatic Transmission:torque Converter

Power Train