NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
74 reportsClear category filter124,000 miles · Feb 23, 2012
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING, THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE VEHICLE AND FOUND THE RADIATOR CRACKED AND THE RADIATOR FLUID HAD LEAKED INTO THE TRANSMISSION, CAUSING THE TRANSMISSION TO FAIL. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING, THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE VEHICLE AND FOUND THE RADIATOR CRACKED AND THE RADIATOR FLUID HAD LEAKED INTO THE TRANSMISSION, CAUSING THE TRANSMISSION TO FAIL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 124,000.
NHTSA ODI #10449033
58,350 miles · Feb 2, 2012
Engine And Engine Cooling
FAILURE OF TIMING CHAIN AND TIMING CHAIN GUIDES. *KB
NHTSA ODI #10446262
98,000 miles · Nov 29, 2011
Engine And Engine CoolingPower Train
A TRANSMISSION LINE FROM THE COOLER RUNS THROUGH THE RADIATOR. THE LINE FAILED ALLOWING FLUID FROM THE RADIATOR TO ENTER THE TRANSMISSION. THIS CAUSED MASSIVE VIBRATIONS AND VEHICLE STALLING WHEN ATTEMPTING TO ACCELERATE ONTO THE FREEWAY OR TO PASS, CREATING A HAZARDOUS SITUATION IN TRAFFIC. *KB
NHTSA ODI #10437695
2,011 miles · Nov 3, 2011
Engine And Engine CoolingFuel System, Gasoline
I PURCHASED THE VEHICLE IN 2007 WITH 40,000 MILES ON IT. IT HAS BEEN SHIMMYING ON THE HIGHWAY SINCE I HIT 60,000 MILES AND IN SPITE OF HAVING MY TIRES RE-ALIGNED AND BALANCED, IT STILL CONTINUES TO ROCK BACK AND FORTH AT SPEEDS OVER 50 MILES AN HOUR. I JUST HIT MY 100,000 MILE MARK ON THE FIRST OF OCTOBER. ON OCTOBER 18TH, I …
Read full complaint
I PURCHASED THE VEHICLE IN 2007 WITH 40,000 MILES ON IT. IT HAS BEEN SHIMMYING ON THE HIGHWAY SINCE I HIT 60,000 MILES AND IN SPITE OF HAVING MY TIRES RE-ALIGNED AND BALANCED, IT STILL CONTINUES TO ROCK BACK AND FORTH AT SPEEDS OVER 50 MILES AN HOUR. I JUST HIT MY 100,000 MILE MARK ON THE FIRST OF OCTOBER. ON OCTOBER 18TH, I WAS AT MY SON'S DAYCARE AND THE TRUCK STARTED IDLING STRANGELY. THE TRUCK WAS PUTTERING AND EXHAUSTING BLACK SMOKE. IT DIED IN THE PARKING LOT AND I TRIED NUMEROUS TIMES TO GET IT STARTED. IT TOOK ABOUT 20 MINUTES OF TRYING BUT I GOT IT RUNNING AGAIN, ONLY TO HAVE IT DIE ON ME IN TRAFFIC. ONCE AGAIN, I GOT IT STARTED AND MANAGED TO GET IT HOME WHERE IT COMPLETELY DIED. WHEN I WAS ABLE TO GET IT TO THE DEALERSHIP (AFTER A LOCAL MECHANIC LOOKED AT IT AND COULDN'T GET IT STARTED) THE DEALERSHIP TOLD ME I HAD AN ENGINE IDLE AIR CONTROL SENSOR THAT WAS RECALLED BY NISSAN. I NEVER RECEIVED THE RECALL NOTICE BUT WAS RELIEVED THAT MY BILL WAS COVERED. LESS THAN A WEEK AFTER THE SENSOR HAD BEEN REPLACED, THE CHECK ENGINE LIGHT CAME ON. I BROUGHT IT BACK TO THE DEALERSHIP AND THEY TOLD ME MY CATALYTIC CONVERTERS HAD BURNED OUT. FROM WHAT I HAVE BEEN ABLE TO RESEARCH ONLINE, THE FAILURE OF MY CATALYTIC CONVERTERS IS DIRECTLY RELATED TO AN OUT OF TUNE ENGINE (TOO MUCH AIR OR FUEL) WHICH WAS CAUSED BY THE SENSOR BEING DEFECTIVE. NISSAN DOESN'T SEE IT THAT WAY AND NOW I'M STUCK WITH A $3500 REPAIR BILL ON A TRUCK I STILL OWE MONEY ON AND HAVE OWNED FOR LESS THAN FOUR YEARS. *TR
NHTSA ODI #10434149
90,000 miles · Oct 21, 2011
Engine And Engine CoolingFuel System, Gasoline
MY TRUCK SUFFERS FROM 2 KNOWN PROBLEMS THAT HAS BEEN WIDELY REPORTED AND ARE INVOLVED IN TWO NISSAN TSBS. I HAVE THE FAULTY FUEL SENDING UNIT AND THE WHINING TIMING BELT TENSIONER. I AM NOT GETTING ANY HELP FROM NISSAN AND JUST GET A FLAT 'YOUR WARRANTY HAS EXPIRED' STATEMENT FROM THEM. I FEEL THAT THEY SHOULD FIX THESE PROBLE…
Read full complaint
MY TRUCK SUFFERS FROM 2 KNOWN PROBLEMS THAT HAS BEEN WIDELY REPORTED AND ARE INVOLVED IN TWO NISSAN TSBS. I HAVE THE FAULTY FUEL SENDING UNIT AND THE WHINING TIMING BELT TENSIONER. I AM NOT GETTING ANY HELP FROM NISSAN AND JUST GET A FLAT 'YOUR WARRANTY HAS EXPIRED' STATEMENT FROM THEM. I FEEL THAT THEY SHOULD FIX THESE PROBLEMS OR AT LEAST OFFER A VERY REDUCED RATE FOR THE REPAIR. *TR
NHTSA ODI #10432416
Mileage unknown · Oct 20, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT THE RADIATOR BECAME CLOGGED BY WHAT HAD DEVELOPED INTO A JELLY TYPE OF SUBSTANCE AND DESTROYED THE RADIATOR. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION AND POSSIBLE REPAIRS BUT THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT THE RADIATOR BECAME CLOGGED BY WHAT HAD DEVELOPED INTO A JELLY TYPE OF SUBSTANCE AND DESTROYED THE RADIATOR. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION AND POSSIBLE REPAIRS BUT THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY OF THE FAILURE DESTROYING THE TRANSMISSION AS WELL. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
NHTSA ODI #10432254
78,000 miles · Sep 9, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT HEARD A LOUD RATTLING NOISE COMING FROM THE VEHICLE. THE DEALER DIAGNOSED THE VEHICLE WITH A WORN TIMING CHAIN TENSIONER GUIDE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 78,400 AND THE APPROXIMATE FAILURE MILEAGE WAS 78,000. NO REPAIRS WE…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT HEARD A LOUD RATTLING NOISE COMING FROM THE VEHICLE. THE DEALER DIAGNOSED THE VEHICLE WITH A WORN TIMING CHAIN TENSIONER GUIDE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 78,400 AND THE APPROXIMATE FAILURE MILEAGE WAS 78,000. NO REPAIRS WERE PERFORMED. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10424489
78,000 miles · Aug 29, 2011
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE TRANSMISSION BEGAN TO SLIP AND HESITATE WHEN SHIFTING GEARS. IN ADDITION, THE VEHICLE DECELERATED AND VIBRATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT BELIEVED THAT THERE MAY BE RADIATOR FLUI…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE TRANSMISSION BEGAN TO SLIP AND HESITATE WHEN SHIFTING GEARS. IN ADDITION, THE VEHICLE DECELERATED AND VIBRATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT BELIEVED THAT THERE MAY BE RADIATOR FLUID LEAKING INTO THE TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 78,000. UPDATED 09/21/11 *BF UPDATED 09/30/11
NHTSA ODI #10422406
104,000 miles · Aug 11, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE SUDDENLY STALLED. AFTER MULTIPLE ATTEMPTS, THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO FOUR DIFFERENT INDEPENDENT MECHANICS, WHO WERE UNABLE TO DIAGNOSE THE FAILURE. THE DEALER WAS NOTIFI…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE SUDDENLY STALLED. AFTER MULTIPLE ATTEMPTS, THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO FOUR DIFFERENT INDEPENDENT MECHANICS, WHO WERE UNABLE TO DIAGNOSE THE FAILURE. THE DEALER WAS NOTIFIED AND STATED THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER 10V517000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS THEN TAKEN TO THE DEALER FOR THE RECALL REPAIRS. AFTER THE REPAIRS, THE TECHNICIAN WAS UNABLE TO START THE VEHICLE. THE TECHNICIANS STATED THAT THERE WAS AN ELECTRICAL FAILURE AND THE VEHICLE HAD TO BE DIAGNOSED. THE VEHICLE WAS NOT AGAIN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
NHTSA ODI #10418544
50,000 miles · Jul 25, 2011
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT THE TRANSMISSION SHIFTED INTO LIMP MODE AND THE VEHICLE FAILED TO RESPOND WHEN THE ACCELERATOR PEDAL WAS ENGAGED. A LOCAL MECHANIC DIAGNOSED THAT THE RADIATOR AND TRANSMISSION NEEDED TO BE REPLACED. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASS…
Read full complaint
TL* THE CONTACT OWNS A 2006 NISSAN FRONTIER. THE CONTACT STATED THAT THE TRANSMISSION SHIFTED INTO LIMP MODE AND THE VEHICLE FAILED TO RESPOND WHEN THE ACCELERATOR PEDAL WAS ENGAGED. A LOCAL MECHANIC DIAGNOSED THAT THE RADIATOR AND TRANSMISSION NEEDED TO BE REPLACED. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 50,000.
NHTSA ODI #10415041
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2006 AND MODEL YEAR 2008 FRONTIER, XTERRA AND PATHFINDER VEHICLES. THE MOLDED FUEL TANK SHELLS CAN DEFORM, CAUSING THE FUEL SENDER FLOAT ARM TO CONTACT AN EMBOSSMENT MOLDED INTO THE TANK SHELL CAUSING THE INSTRUMENT PANEL FUEL GAUGE TO SHOW THAT THE VEHICLE HAS APPROXIMATELY ONE QUARTER TANK WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL IN TRAFFIC, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL LEVEL SENDING UNIT INSIDE THE FUEL TANK WITH A NEW ONE THAT HAS A MODIFIED FLOAT ARM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Dec 29, 2008
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
Consequence & remedy
Consequence: THIS ISSUE COULD RESULT IN THE NON-DEPLOYMENT OF THE DRIVER AND PASSENGER FRONT AIR BAGS IN A CRASH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT CZS WITH A REDESIGNED SENSOR. THE RECALL BEGAN ON JANUARY 26, 2009. OWNERS IN THE OTHER STATES WILL RECEIVE EXTENDED WARRANTY COVERAGE FOR THE SENSOR TO 10 YEARS. THESE OWNERS WILL BE NOTIFIED OF THE WARRANTY EXTENSION BY MAIL AND WILL RECEIVE A STICKER TO PLACE IN THEIR WARRANTY BOOKLET EXPLAINING THE EXTENDED WARRANTY COVERAGE. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 30, 2006
ON CERTAIN KING CAB TRUCKS, IN A SEVERE SIDE IMPACT CRASH, THERE IS A POSSIBILITY THAT DEFORMATION OF THE VEHICLE'S BODY COULD CAUSE THE FUEL FILLER CAP TETHER TO BE STRETCHED TO THE POINT OF UNSCREWING THE FUEL FILLER CAP.
Consequence & remedy
Consequence: THIS MAY RESULT IN A FUEL SPILL WHICH IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL CAP TETHER PIN ASSEMBLY WITH A MODIFIED ONE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP26003 · Fuel Smell And Loss Of Motive Power
Opened Mar 30, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling; Fuel System, Gasoline
The Office of Defects Investigation (ODI) received a Petition dated February 5, 2026, requesting an investigation into model year (MY) 2006 Nissan Frontier vehicles. The Petitioner alleges that the vehicle poses an imminent fire hazard due to “[a] powerful and persistent odor of raw gasoline” that he says “emanates from the vehicle” and “indicat[es] a breach in fuel system integrity.” He further alleges that the vehicles can experience sudden engine stalling “during startup and operation,” which he believes could cause collisions or loss of vehicle control. The Petitioner further alleges these symptoms are identical to conditions addressed in previous NHTSA recalls (10V-517, 07V-435, and 10V-075) and that the issues persist in the 2006 MY Nissan fleet despite these past actions. ODI is opening this Defect Petition to evaluate the Petitioner’s allegations and determine whether to grant or deny the Petition. The Petition can be viewed at NHTSA.gov under NHTSA Number 11718552.
Additional source detail variants (2)
Engine And Engine Cooling
The Office of Defects Investigation (ODI) received a Petition dated February 5, 2026, requesting an investigation into model year (MY) 2006 Nissan Frontier vehicles. The Petitioner alleges that the vehicle poses an imminent fire hazard due to “[a] powerful and persistent odor of raw gasoline” that he says “emanates from the vehicle” and “indicat[es] a breach in fuel system integrity.” He further alleges that the vehicles can experience sudden engine stalling “during startup and operation,” which he believes could cause collisions or loss of vehicle control. The Petitioner further alleges these symptoms are identical to conditions addressed in previous NHTSA recalls (10V-517, 07V-435, and 10V-075) and that the issues persist in the 2006 MY Nissan fleet despite these past actions. ODI is opening this Defect Petition to evaluate the Petitioner’s allegations and determine whether to grant or deny the Petition. The Petition can be viewed at NHTSA.gov under NHTSA Number 11718552.
Fuel System, Gasoline
The Office of Defects Investigation (ODI) received a Petition dated February 5, 2026, requesting an investigation into model year (MY) 2006 Nissan Frontier vehicles. The Petitioner alleges that the vehicle poses an imminent fire hazard due to “[a] powerful and persistent odor of raw gasoline” that he says “emanates from the vehicle” and “indicat[es] a breach in fuel system integrity.” He further alleges that the vehicles can experience sudden engine stalling “during startup and operation,” which he believes could cause collisions or loss of vehicle control. The Petitioner further alleges these symptoms are identical to conditions addressed in previous NHTSA recalls (10V-517, 07V-435, and 10V-075) and that the issues persist in the 2006 MY Nissan fleet despite these past actions. ODI is opening this Defect Petition to evaluate the Petitioner’s allegations and determine whether to grant or deny the Petition. The Petition can be viewed at NHTSA.gov under NHTSA Number 11718552.
DP12004 · Transmission Failures
Opened Jun 11, 2012 · Closed Oct 22, 2016
Status: closed (inferred from source dates) · Power Train; Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Power Train:automatic Transmission:cooling Unit And Lines; Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Additional source detail variants (5)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:cooling Unit And Lines
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train:automatic Transmission:torque Converter
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Power Train
On February 29, 2012 the National Highway Traffic Safety Administration (NHTSA) received a letter petitioning the agency to conduct a defect investigation into MY 2005-2010 Nissan Pathfinder, Frontier, and Xterra vehicles [the subject vehicles] for automatic transmission failures related to failed transmission coolers.NHTSA conducted a comprehensive review of data related to this subject. Our report, documenting this review, is available in the document file for this defect petition.It will also be published in the Federal Register. Of the 2,505 referenced complaints, 638 relate to a potential hazard (unable to maintain speed, no motive power, engine stall) and 1,867 concern customer satisfaction issues including, but not limited to, repair cost, vehicle shudder and shake, and engine overheating.Taking into account the allocation of agency resources and priorities and the likelihood that additional investigation would result in a finding that an unreasonable risk to highway safety exists, we conclude that further investigation is not warranted and deny the petition.ODI Complaint ID numbers are referenced on the next page.
Illustration