NEW FLYER IS RECALLING MODEL YEAR 2002-2006 D60HF DIESEL 60 FOOT HIGH FLOOR TRANSIT BUSES EQUIPPED WITH A LIFT-U WHEELCHAIR LIFT, OR HAVE AFTERMARKET LIFT-U CONTROL BOXES INSTALLED. A DEFECT IN THE CONTROL BOX COULD CAUSE THE OUTBOARD RAMP BARRIER TO FOLD IN TOWARD A LIFT PASSENGER.

Consequence & remedy

Consequence: THE RAMP BARRIER COULD PINCH THE PASSENGER'S FEET.

Remedy: NEW FLYER IS WORKING WITH LIFT-U (PLEASE SEE RECALL 09E-051) AND WILL REPAIR THE TRANSIT BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 26, 2009. OWNERS MAY CONTACT NEW FLYER CUSTOMER SERVICE AT 1-204-934-4876 OR LIFT-U AT 1-209-838-2400.

07V268000 · Steering

Jun 11, 2007

ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.

Consequence & remedy

Consequence: EXCESSIVE PLAY IN THE STEERING SYSTEM COULD DEVELOP AND, IF NOT CORRECTED, CAUSE A LOSS OF STEERING CONTROL WHICH COULD RESULT IN A CRASH.

Remedy: THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.

04V042000 · Wheels

Feb 2, 2004

ON CERTAIN TRANSIT BUSES, THE CENTER AXLE WHEEL END BRAKES MAY NOT RELEASE AFTER BEING PARKED FOR AN EXTENDED PERIOD OF TIME.

Consequence & remedy

Consequence: THE DRIVER COULD LOSE CONTROL OF THE VEHICLE WHEN DRIVING AWAY FROM A PARKED POSITION, WHICH COULD RESULT IN A CRASH.

Remedy: NEW FLYER WILL INSTALL AN ADDITIONAL AIR SYSTEM R14 RELAY VALVE, #4 NOTCH AUTOMATIC SLACK ADJUSTERS, AND TYPE 30 LONG STOKE BRAKE CHAMBERS ON THE CENTER AXLE; THE LOGIC CONTROL MODULE WILL BE REPROGRAMMED, ADD NEW ABS COMPONENTS (SENSORS, SPEED RINGS AND HARNESSES) IF NOT ALREADY EQUIPPED WITH ABS; AND WILL REVISE PLC PROGRAMMING. OWNERS MAY CONTACT NEW FLYER AT 1-204-982-8400.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE07053 · Interior Fires

Opened Oct 29, 2007 · Closed Feb 22, 2008

Status: closed (inferred from source dates) · Electrical System

THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS PRELIMINARY EVALUATIONBASED ON A FLEET REPORT OF 3 THERMAL EVENTS ALLEGEDLYTHE RESULT OF CONDENSATION FROM THE AIR CONDITIONER'S EVAPORATOR DRAIN HOSE SHORTING ELECTRICAL CONNECTIONS AND VARIOUS ELECTRICAL COMPONENTS. THE INVESTIGATION WAS OPENED TO EVALUATE AND DETERMINE THE CAUSE OF THESE THERMAL EVENTS. A TECHNICAL EVALUATIONDETERMINED THAT THE DRAIN LINE FOR THE ROOFTOP EVAPORATOR UNIT CONTACTED THE BALLAST INVERTER FOR THE FLUORESCENT LIGHTING PANEL AND BECAME ABRADED.THE ABRASION OF THE DRAIN LINERESULTED IN LOW PRESSURE AND LOW VOLUMES OF MOISTURE BEING INTRODUCED INTO THE LIGHTING PANEL RESULTING IN ELECTRICAL SHORTS.NEW FLYER DECIDED TO CONDUCT A SAFETY RECALL TO CORRECT THE PROBLEM.THE CORRECTIVE ACTION WILL BE TO INSTALL AN ELBOW ON THE AIR CONDITIONING DRAIN LINE WHERE IT ENTERS THE BUS INTERIOR.THIS ELBOW RELOCATES THE DRAIN LINE TO PROVIDE THE NEEDED CLEARANCE BETWEEN THE LINE AND LIGHTING COMPONENTS.THIS REMEDY RESOLVES THE ISSUE UNDER INVESTIGATION AND, THEREFORE, THIS INVESTIGATION IS CLOSED.

PE05018 · Seat Bracket Failure

Opened Apr 21, 2005 · Closed Aug 5, 2005

Status: closed (inferred from source dates) · Seats

THIS INVESTIGATION WAS OPENED AFTER NOTIFICATION FROM A NEW YORK CITY BUS FLEET OF A MARCH 25, 2004 INCIDENT WHERE A SEAT COLLASPED ON A TRANSIT BUS SENDING TWO PASSENGERS TO THE FLOOR, RESULTING IN ONE INJURY.AN INSPECTION REVEALED THAT THERE ARE TWO SEAT DESIGNS INSTALLED IN THE BUSES.SEAT DESIGN ?A? SUFFERED THE FAILURE WHERE THE PASSENGERS FELL TO THE FLOOR.AN EXAMINATION OF THIS SEAT DESIGN REVEALED THAT THE SEATS WERE NOT PROPERLY SECURED TO THE WALL MOUNTING BRACKETS AND THEREFORE LOST THEIR RIGIDITY AND STABLILTY ALLOWING THE COLLAPSE.THIS PROBLEM IS DEEMED TO BE MAINTENANCE RELATED.FLEET PERSONNEL FURTHER STATED THAT AFTER EXAMINING THE REMAINING BUSES IN THE FLEET, 259 SEAT BRACKETS ON 223 BUSES WERE DISCOVERED TO HAVE SOME QUANTITY OF FRAME CRACKS.THE CRACKED SEAT DESIGN IS DESIGNATED AS SEAT FRAME ?B.?THE MAJORITY OF THE CRACKED SEATS (?B?) ARE LOCATED JUST FORWARD OF THE EXIT DOOR ON THE CURB SIDE OF THE BUS.THESE BUSES ARE A RELATIVELY LOW POPULATION VEHICLE, HAVING BEEN BUILT ONLY IN 1998 AND 2002 MODEL YEARS.THE BUSES ARE DIFFERENT FROM MOST IN THAT THEY WERE SPECIFIED WITH ?HIGH FLOORS.? (SUMMARY CONTINUED ON PAGE 2)

PE04003 · Brakes Fail To Release, Bus JACK-KNIFES

Opened Jan 8, 2004 · Closed Apr 30, 2004

Status: closed (inferred from source dates) · Service Brakes, Air

THIS INVESTIGATION WAS PROMPTED BY A TRANSIT FLEET, WHICH INFORMED ODI IN NOVEMBER, 2003, THAT THEY WERE EXPERIENCING BRAKE PROBLEMS ON THEIR HIGH FLOOR ARTICULATING STYLE BUSES.IN THE LETTER, THE FLEET STATED THAT THEY HAD EXPERIENCED OVER 50 INCIDENTS WHERE THE REAR BRAKES FAILED TO RELEASE DURING MORNING PULLOUT FROM THEIR PARKING LOCATION.THEY ALLEGED THAT THERE HAD BEEN THREE CRASHES RESULTING IN PROPERTY DAMGE AS THE RESULT OF THIS STICKING BRAKE PHENOMENON.THE CRASHES ORIGINATE WHEN THE MIDDLE AXLE BRAKES FAIL TO RELEASE AND THE REAR ENGINE VEHICLE PUSHES THE MIDDLE AXLE RESULTING IN A JACK-KNIFE CONDITION OF THE ARTICULATED BUS. AS A RESULT OF ODI'SINVESTIGATION, NEW FLYER HAS AGREED TO INITIATE A SAFETY RECALL AND CORRECT THIS CONDITION ON ALL AFFECTED BUSES.THE ACTION TAKEN BY NEW FLYER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION. A COPY OF THE RECALLIS ATTACHED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.