CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.
Consequence & remedy
Consequence: THE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.
Remedy: DEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE.
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSPECT AND REPLACE THE TURBOCHARGER TO PREVENT THE POSSIBILITY OF AN ENGINE COMPARTMENT FIRE. DETROIT DIESEL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR NEW FLYER AT 1-204-982-8400.
ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED.
Consequence & remedy
Consequence: THE HOSE CAN LEAK, CREATING THE RISK OF AN ENGINE FIRE.
Remedy: DEALERS WILL REPLACE THE HOSE. OWNER NOTIFICATION BEGAN JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-228-8984.
VEHICLE DESCRIPTION: TRANSIT BUSES. THERE COULD BE A CASTING DEFECT IN THE LEFT SIDE SPRING TOWER. THE SPRING TOWERS SUPPORT THE VEHICLE STRUCTURE, AND FAILURE OF A TOWER COULD CAUSE A SUDDEN SHIFT IN THE FRONT AXLE.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO LOSS OF CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE SPRING TOWER. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-982-8181.
VEHICLE DESCRIPTION: TRANSIT BUSES. A TETHER STRAP ON THE DRIVER'S SEAT WAS OMITTED. THIS DOES NOT COMPLY WITH THE STRENGTH REQUIREMENTS OF FMVSS NO. 207, SEATING SYSTEMS."
Consequence & remedy
Consequence: THE DRIVER SEAT MAY NOT ADEQUATELY RESTRAIN THE DRIVER IN THE EVENT OF A VEHICLE CRASH.
Remedy: THE OWNER WILL BE PROVIDED WITH PARTS, INSTRUCTIONS AND REPAIR ASSISTANCE AS REQUIRED. THE OWNER WILL INSTALL THE MISSING TETHER STRAPS.
VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH AN AUXILIARY DIESEL POWERED HEATER (PROHEAT BRAVO MODEL 80). AN IMPROPERLY ASSEMBLED FUEL REGULATOR CAN ALLOW AN EXCESS AMOUNT OF FUEL INTO THE COMBUSTION CHAMBER.
Consequence & remedy
Consequence: THIS LEAKAGE CAN LEAD TO A POTENTIAL FOR FLAMES TO ESCAPE FROM THE HEATER EXHAUST.
Remedy: TELEFLEX CANADA, THE MANUFACTURER OF THE HEATER, WILL INSPECT AND, IF NECESSARY, REPLACE ALL DEFECTIVE REGULATORS.
VEHICLE DESCRIPTION: TRANSIT BUSES. THE DAYTIME RUNNING LAMP (DRL) MODULE CAN OVER-HEAT AND SHUT DOWN AFTER AS LITTLE AS 45 MINUTES OF HIGH BEAM USE. THIS WILL CAUSE TOTAL HEADLAMP FAILURE OF BOTH HIGH AND LOW BEAM.
Consequence & remedy
Consequence: IF THE DRL MODULE OVER-HEATS AND THE HEADLAMPS GO OUT, THERE IS A SIGNIFICANT RISK OF A VEHICLE CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH DETAILED REPAIR INSTRUCTIONS AND NEW DRL MODULES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 New Flyer D40LF Problems, Complaints & Recalls | Skip That Year
Illustration