2007 Mitsubishi Outlander

LEFT FRONT OF VEHICLE IS VIBRATING/ JERKING STEERING WHEEL SIDE TO SIDE WITH WHAT SOUNDS LIKE SOMETHING RUBBING HARD ENOUGH TO JERK CAR SIDE TO SIDE. MAKING A BANGING NOISE WHEN TURNING AS THOUGH FRONT SUSPENSION IS BROKEN. I SEE THERE IS A RECALL FOR THIS ISSUE. I PURCHASED THE OUTLANDER FROM A DEALERSHIP USED AND WAS TOLD FIXING THE RECALLS WASN'T THEIR PROBLEM AFTER SIGNING PAPERWORK. UNKNOWN HISTORY AS I WAS LIED TO ABOUT ISSUES AND SALESMAN WAS FIRED. I BELIEVE THIS IS A RECALL ISSUE.

MECHANIC SAID MY AXLE BOOT LOCK AND STRUT SPRING BROKE AND I NEED A NEW PASSENGER FRONT AXLE COIL SPRING. LOUD BANG WOKE US UP WHILE CAR WAS IN DRIVEWAY. RELATED TO RECALL NHTSA CAMPAIGN ID: 16V458000? ALSO POWER STEERING LEAKING EVERY TIME WE FILL IT, THAT ALSO MIGHT HAVE A RECALL FROM WHAT I SAW. MITSUBISHI DEALER SAID THERE ARE NO RECALLS FOR MY CAR BUT SEEING SIMILARITIES WITH WHAT IS WRONG WITH MY CAR. CAR WAS JUST SITTING IN MY DRIVEWAY WHEN IT ANPPED

TL* THE CONTACT OWNS A 2007 MITSUBISHI OUTLANDER. WHILE DRIVING APPROXIMATELY 15 MPH, THE FRONT DRIVER AND PASSENGER SIDE SUSPENSION COLLAPSED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME WAS RUSTED AND CAUSED THE ENGINE CRADLE TO FRACTURE. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V458000 (SUSPENSION). THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. *TT *AS

MY SON ONLY WEEKS AGO WAS GIVEN HIS MOTHER'S 2007 OUTLANDER AS AN UPGRADE TO HIS FORMER VEHICLE. DAYS AGO, HE FOUND PIECES OF THE SUB FRAME BREAKING OFF UNDERNEATH AFTER HEARING AN ODD NOISE DURING OPERATION. THIS VEHICLE WAS PURCHASED NEW IN 2007 IN OMAHA, NE. MITSUBISHI'S RECALL FOR SUB FRAME CORROSION DOES NOT INCLUDE VEHICLES PURCHASED IN NEBRASKA AS IT ISN'T IN THE NARROWLY DEFINED "SALT BELT" (ALTHOUGH IOWA IS INCLUDED). IF YOU HAVE NEVER BEEN TO OMAHA, NE DURING THE WINTER YOU WOULD KNOW THAT THE CITY PUTS AS MUCH SALT AND SALT BRINE ON THE ROADS AS ANYWHERE ELSE IN THE NATION--WINTER WEATHER, I.E. SNOW AND ICE-- IN OMAHA IS SEVERE. VEHICLES THAT ARE OPERATED REGULARLY IN THE OMAHA AREA RUST PREMATURELY AND THAT IS A FACT. THIS VEHICLE IS NOW UNSAFE TO DRIVE AND THE VALUE IS PROBABLY NEAR ZERO BUT MITSUBISHI WILL NOT COVER THE COST TO REPAIR. THE NHTSA SHOULD EXTEND THE SUB FRAME RECALL TO OTHER STATES WHERE THE USE OF ROAD SALT IS EXTENSIVE I.E. NEBRASKA, COLORADO, UTAH, ETC...THIS IS A TRAVESTY AND SHOULD BE RECTIFIED IMMEDIATELY BEFORE SOMEONE IS SEVERELY INJURED OR KILLED DRIVING THESE VEHICLES.

TOOK MY 2007 MITSUBISHI OUTLANDER XLS V-6 TO DEALERSHIP FOR SEVERAL RECALLS INCLUDING RECALL NO. 16V-458 / SR-16-003 ON MAY 05, 2018. I PICKED UP MY VEHICLE AND WAS TOLD IT DID NOT REQUIRE THE CROSS MEMBER REPLACEMENT AND THE ANTI CORROSION SPRAY WAS PERFORMED. AROUND 7:00 PM EDT SATURDAY, MARCH 23, 2019 WHILE ENTERING A EXIT LANE ON US 119 NORTHBOUND AT THE GREEN ROAD EXIT, MY CAR MADE A LOUD GRINDING SOUND AND STARTING PULLING VERY HARD TO THE LEFT AND CAME TO AN ABRUPT STOP AFTER APPROXIMATELY 10-15 FEET. FORTUNATELY, I WAS ENTERING THE TURN LANE AND WAS SLOWING DOWN OR IT COULD HAVE EASILY FORCE ME INTO THE MEDIUM DIVIDER OR EVEN INTO ONCOMING TRAFFIC. I COULD NOT MOVE THE VEHICLE FORWARD AND PUT MY EMERGENCY FLASHERS ON TO AVOID BEING REAR ENDED BY ONCOMING TRAFFIC. I WAS VERY CONCERNED AS I HAD MY 3 YEAR OLD GRAND DAUGHTER WITH ME AND IT IS A VERY CONGESTED AREA. I TRIED TO EXIT THE VEHICLE TO SEE IF I COULD DETERMINE WHAT WAS WRONG. THE DRIVER DOOR HAD TO BE FORCED OPEN AS I LATER DISCOVERED AFTER EXITING THE VEHICLE THAT THE FROM LEFT FENDER HAD BEEN PUSHED BACK INTO THE DOOR AREA BY THE FRONT TIRE. AFTER A QUICK INSPECTION IT APPEARED THE CONTROL ARM BROKE. AFTER REMOVING THE TIRE, IT WAS EVIDENT THAT THE CROSS MEMBER HAD SEPARATED FROM THE VEHICLE DUE TO EXTREME CORROSION CAUSING THE LOSS OF CONTROL AND ABRUPT STOP. THIS IS THE EXACT PROBLEM I HAD TAKEN IT INTO THE DEALERSHIP FOR THE RECALL AND WAS TOLD MINE DID NOT NEED REPLACED. I AM ATTACHING PICTURES OF THE VEHICLE TO SHOW THE MISSING AND BROKEN CROSS MEMBER. THERE IS NO WAY THIS CORRODED TO THE FAILURE POINT SINCE THE RECALL REPAIR WAS ALLEGEDLY COMPLETED. FURTHER MORE, IF TREATING THE AREA WAS SUPPOSEDLY SUFFICIENT TO PREVENT FURTHER CORROSION (AS OPPOSED TO THE REPLACEMENT OF THE CROSS MEMBER), THIS FAILURE SHOULD NOT HAVE TAKEN PLACE. THEREFORE, EVERY CROSS MEMBER SHOULD BE REPLACED!

ON JANUARY 2, 2018 OUR LOCAL OVERNIGHT TEMPERATURE WAS A NEGATIVE (-)20 DEGREES F. THAT MORNING WHILE STILL IN MY DRIVEWAY, BOTH FRONT COIL SPRINGS BROKE AND THE RIGHT FRONT COIL SPRING PENETRATED THE INNER SIDEWALL OF THE 18" TIRE AND THIS RESULTED IN THE TIRE BECOMING TWO DISTINCT PIECES. IF THIS HAD HAPPENED WHILE DRIVING ON THE ROAD, IT COULD HAVE RESULTED IN A SERIOUS AND POSSIBLE DEADLY ACCIDENT. UPON CONTACTING MY DEALER, I WAS TOLD THAT UPON SEARCHING THE MITSUBISHI DATABASE, THAT A TSB 14-33-002 WAS NO LONGER POSTED AT THE DEALER INTERNET ACCESS POINT, APPARENTLY IT HAD BEEN PURGED FROM THE SYSTEM. I LEARNED OF TSB-14-33-002 BY OTHER SEARCHING ONLINE. MITSUBISHI WOULD NOT COVER THE FAILURE, DESPITE IT'S SERIOUSNESS TO PUBLIC SAFETY. I AM CONCERNED THAT 2007 MITSUBISHI OUTLANDERS HAVE A METALLURGY PROBLEM OR FAULTY MANUFACTURER'S DESIGN, AND SHOULD BE THE SUBJECT OF A NATIONAL SAFETY RECALL - AT LEAST IN COLDER CLIMATE STATES THAT USE CALCIUM CHLORIDE OR SALT ON THEIR ROADS. I HAVE THE CAR CURRENTLY IN A HEATED GARAGE AWAITING AN INSPECTION BY NHTSA OR MITSUBISHI. MY COMPLAINT IN WRITING TO MITSUBISHI REMAINS UNANSWERED. I SUGGEST THAT IF THESE VEHICLE SUFFER FAILED FRONT COIL SPRINGS AND ARE INVOLVED IN AN ACCIDENT, THAT THE BROKEN COIL SPRING WILL BE CONSIDERED A RESULT OF THE ACCIDENT RATHER THAN THE CAUSE OF THE ACCIDENT. IF THERE IS A CHAIN COLLISION INVOLVING OTHER VEHICLES, THEN AGAIN THE DRIVER MAY BE BLAMED AS THE CAUSE, WHEN IN REALITY THE FAILED SPRING WAS THE CAUSE. SUGGESTION: NHTSA MIGHT CHECK FOR ALL SUB-ZERO TEMPERATURE ACCIDENTS INVOLVING 2007 OUTLANDERS AND DETERMINE IF THEY SUFFERED BROKEN FRONT COIL SPRINGS AND A TORN UP FRONT TIRE. PHOTOS ATTACHED TO THIS REPORT. ADDITIONAL PHOTOS CAN BE TAKEN ONCE THE REPLACEMENT $260. SPRINGS ARRIVE AND WE REPLACE THEM, DOCUMENTING OUR FINDINGS. I AM WILLING TO SUBMIT FOR METALLURGY TESTS.