NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
135 reports28,000 miles · Oct 20, 2007
StructureVisibility
CLICKING NOISE WHEN TURNING THE AIR FROM HOT TO COLD OR COLD TO HOT. CLICKING NOISE STOPPED AND HEAT NO LONGER WORKS. I HAVE NO DEFROST/DEFOG WHICH CAUSES PROBLEMS WITH VISIBILITY. I AM TAKING THE CAR IN FOR REPAIRS THIS WEEK. PAINT FADED AND CORRODED ON THE HOOD, TRUNK, ROOF, QUARTER PANELS, AND DOOR PANELS IN 2004. I TOOK IT T…
Read full complaint
CLICKING NOISE WHEN TURNING THE AIR FROM HOT TO COLD OR COLD TO HOT. CLICKING NOISE STOPPED AND HEAT NO LONGER WORKS. I HAVE NO DEFROST/DEFOG WHICH CAUSES PROBLEMS WITH VISIBILITY. I AM TAKING THE CAR IN FOR REPAIRS THIS WEEK. PAINT FADED AND CORRODED ON THE HOOD, TRUNK, ROOF, QUARTER PANELS, AND DOOR PANELS IN 2004. I TOOK IT TO THE DEALERSHIP AND WAS TOLD THEY COULDN'T DO ANYTHING ABOUT IT. I HAVE RECENTLY TAKEN IT TO A BODY SHOP AND HAD IT REPAINTED. *TR
NHTSA ODI #10206396
Mileage unknown · Jul 22, 2007
Unknown Or Other
I PURCHASED MY CAR IN 03'. I OWN A 2002 MITSUBISHI GALANT WHICH HAS OXIDATION (FADING PAINT) ON THE ROOF AND SIDE PANELS. THE OXIDATION STARTED IN 04'. THE DEALERSHIP HAS REFUSED TO FIX THE PROBLEM. *JB
NHTSA ODI #10197173
83,072 miles · Jul 7, 2007
Engine And Engine CoolingFuel System, GasolineSuspension
I PURCHASED MY VEHICLE USED FROM A DEALERSHIP HERE LOCALLY, AND HAVE HAD PROBLEMS WITH IT EVER SINCE I BOUGHT IT IN LATE MAY OF 2007, MY BRAKES HAVE STARTED TO SQUEAK, I OVERHEATED DUE TO EITHER A FAULTY WATER PUMP AND/OR THERMOSTAT, AND I HAVE NOTICED THAT THE STEERING PULLED SLIGHTLY TO THE RIGHT, AND I PUT NEW TIRES ON IT AN…
Read full complaint
I PURCHASED MY VEHICLE USED FROM A DEALERSHIP HERE LOCALLY, AND HAVE HAD PROBLEMS WITH IT EVER SINCE I BOUGHT IT IN LATE MAY OF 2007, MY BRAKES HAVE STARTED TO SQUEAK, I OVERHEATED DUE TO EITHER A FAULTY WATER PUMP AND/OR THERMOSTAT, AND I HAVE NOTICED THAT THE STEERING PULLED SLIGHTLY TO THE RIGHT, AND I PUT NEW TIRES ON IT AND IT WAS ALIGNED BEFORE PURCHASED. THE DEALERSHIP I BOUGHT IT FROM MAY ONLY BE ABLE TO RUN A DIAGNOSTICS ON IT, AND MIGHT NOT HAVE THE TOOLS TO FIX IT. THE NEAREST MITSUBISHI DEALERSHIP IS 180 MILES AWAY. WARRANTY COVERS WATER PUMP AND A RENTAL OF UP TO $35 A DAY, BUT IN ORDER TO GET A RENTAL, I HAVE TO GET A DIAGNOSTICS DONE TO MAKE SURE IT IS A COVERED COMPONENT UNDER MY WARRANY I WON'T BE ABLE TO GET A DIAGNOSTICS RAN FOR AT LEAST SEVERAL DAYS, LEAVING ME WITHOUT A VEHICLE. DEALERSHIP REFUSED TO LOAN A CAR OFF OF THE LOT.*AK
NHTSA ODI #10195551
24,139 miles · May 28, 2007
Engine And Engine CoolingService Brakes, Hydraulic
SINCE PURCHASE OF 2002 MITSUBISHI GALANT HAVE HAD NUMEROUS PROBLEMS WITH SQUEAKING BRAKES, ROTORS REPLACED TWICE SINCE PURCHASED 7/05. WAS TOLD BY DEALER THAT SQUEAKING WAS FROM DRIVING HABITS; NOTHING WRONG WITH BRAKES. HAD TO TAKE VEHICLE TO PRIVATE MECHANIC. ALSO, PROBLEMS WITH AIR CONDITIONING. HOT AIR BLOWS OUT BOTTOM VENTS…
Read full complaint
SINCE PURCHASE OF 2002 MITSUBISHI GALANT HAVE HAD NUMEROUS PROBLEMS WITH SQUEAKING BRAKES, ROTORS REPLACED TWICE SINCE PURCHASED 7/05. WAS TOLD BY DEALER THAT SQUEAKING WAS FROM DRIVING HABITS; NOTHING WRONG WITH BRAKES. HAD TO TAKE VEHICLE TO PRIVATE MECHANIC. ALSO, PROBLEMS WITH AIR CONDITIONING. HOT AIR BLOWS OUT BOTTOM VENTS BY FLOOR. AIR DOESN'T GET COLD EITHER. HAVE HAD VEHICLE AIR CONDITIONER CHARGED BOTH LAST SPRING AND ALSO THIS SPRING. WITHIN 2 WEEKS AIR ONLY GETS SEMI-COOL AND FLOOR VENTS BLOW REALLY HOT AIR AT ALL TIMES. THIS VEHICLE IS A DISGRACE. MORE TROUBLE THAN ENJOYMENT. ONLY GOOD THING IS APPEARANCE AND STYLE. MITSUBISHI HAS HAD NUMEROUS COMPLAINTS ABOUT BOTH THE BRAKES AND AIR CONDITIONING ON THEIR 2002 GALANTES. POOR QUALITY AUTOMOBILE. *TR
NHTSA ODI #10191859
Mileage unknown · May 22, 2007
Electrical System
AIR CONDITION/ HEAT (BLUE- RED) DIAL MAKES CLIKING SOUND WHEN TURNING FROM BLUE TO RED AND SOME TIMES DOES NOT ALLOW WARM AIR TO HEAT THE CAR. *AK
NHTSA ODI #10191458
105,000 miles · May 19, 2007
Electrical SystemVisibility
2002 MITSUBISHI GALANT 3.0 V6, HEATER CONTROL MOTOR FAILED AFTER ONLY 5 YEARS OF SERVICE. ALSO, SPEEDOMETER WAS CONSISTANTLY 4 MPH FAS, ALWAYS HAS BEEN. *AK
NHTSA ODI #10191227
85,000 miles · Apr 3, 2007
Engine And Engine CoolingVisibility
ON MY 2002 MITSUBISHI GALANT WITH THE 3.0 LITER ENGINE, THE HEAT OCCASIONALLY FAILS TO PROVIDE WARM AIR. THE FAN WORKS, THE CAR IS AT A NORMAL RUNNING TEMPERATURE, AND ALL HOSES ARE WARM. THE HEATER CONTROL MOTOR IS FAILING. THE PART IS CHEAP BUT YOU HAVE TO REMOVE MOST OF THE DASH BOARD TO REPLACE IT. THE DEALER CHARGES AN UNUS…
Read full complaint
ON MY 2002 MITSUBISHI GALANT WITH THE 3.0 LITER ENGINE, THE HEAT OCCASIONALLY FAILS TO PROVIDE WARM AIR. THE FAN WORKS, THE CAR IS AT A NORMAL RUNNING TEMPERATURE, AND ALL HOSES ARE WARM. THE HEATER CONTROL MOTOR IS FAILING. THE PART IS CHEAP BUT YOU HAVE TO REMOVE MOST OF THE DASH BOARD TO REPLACE IT. THE DEALER CHARGES AN UNUSUALLY LARGE AMOUNT TO FIX IT, ANYWHERE FROM $300 - $600. *JB
NHTSA ODI #10186807
Mileage unknown · Mar 25, 2007
Visibility
HEAT STOPPED WORKING.. CONTROL MOTER FOR THE HEATER CORE.*AK
NHTSA ODI #10186127
Mileage unknown · Mar 22, 2007
Electrical SystemFire
RESPONDED TO A VEHICLE FIRE IN A 2002 MITSUBISHI, GALANT ON MARCH 22, 2007. THERE IS NO POSSIBLE CAUSE OF THIS FIRE BUT FROM THE OUTSTANDING RECALL FOR THE WIRING UNDER THE HOOD, RECALL NUMBER NHTSA 02V147000. IT HAD NOT BEEN DRIVEN FOR THREE HOURS AND THE AREA OF ORIGIN, IS UNDER THE HOOD INVOLVING THE BATTERY AND WIRING.
NHTSA ODI #10185881
Mileage unknown · Jan 9, 2007
SteeringSuspension
MY 2002 MITSUBISHI GALANT STEERING WHEEL AND THE ENTIRE CAR STARTS SHAKING WHEN IT REACHES 60 AND ABOVE MPH. *NM
NHTSA ODI #10178175
NHTSA investigations
2EA08011 · Passenger Door Fire
Opened Jul 1, 2008 · Closed Aug 21, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Visibility; Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Additional source detail variants (5)
Electrical System
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:fuses And Circuit Breakers
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:interior/under Dash
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
PE08014 · Passenger Door Fire
Opened Mar 4, 2008 · Closed Jul 1, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash; Visibility; Visibility:glass, Side/rear; Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Additional source detail variants (6)
Electrical System
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring:interior/under Dash
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:glass, Side/rear
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Illustration