IllustrationTRANSMISSION WENT OUT. THERE MAY HAVE BEEN A SERVICE BULLETIN? NOT THAT MANY MILES. *TR UPDATED 12/04/12*LJ
2002 Mitsubishi Galant
Owner reports · Recalls · Investigations
More warning signs than most Galant years
Owner complaints for the 2002 Mitsubishi Galant are substantially higher than the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all Galant years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
1725–50K
1450–75K
1475–100K
16100–150K
1150K+
77 reports with mileage · 58 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports10 fire reports15 injury reports
Power Train complaints
3 reportsWHILE THE 2002 GALANT WAS IN PARK AND ENGINE OFF , VEHICLE WAS PARKED IN STEEP DRIVEWAY I WAS FASTENING BABY INTO CARSEAT ON REAR PASSENGER SIDE OTHER CHILD BUMPED GEAR SHIFT INTO REVERSE AND CAR ENGAGED . I WAS DRAGGED WITH VEHICLE DOWN DRIVEWAY ACROSS STREET INTO A YARD AND INTO A TREE WHERE VEHICLE CAME TO REST AFTER CRASHIN…
Read full complaint
WHILE THE 2002 GALANT WAS IN PARK AND ENGINE OFF , VEHICLE WAS PARKED IN STEEP DRIVEWAY I WAS FASTENING BABY INTO CARSEAT ON REAR PASSENGER SIDE OTHER CHILD BUMPED GEAR SHIFT INTO REVERSE AND CAR ENGAGED . I WAS DRAGGED WITH VEHICLE DOWN DRIVEWAY ACROSS STREET INTO A YARD AND INTO A TREE WHERE VEHICLE CAME TO REST AFTER CRASHING INTO TREE. THE GALANTS SHIFT LOCK DOES NOT WORK THE BRAKE SHOULD HAVE TO BE DEPRESSED TO SHIFT AND NOT AT ALL IF ENGINE IS OFF. THIS NEEDS TO BE INVESTIGATED AS THIS COULD WELL HAVE BEEN FATAL. LUCKILY I RECEIVED ONLY A BROKEN FOOT AND CUTS. *TR
SEVERE STEERING VIBRATIONS AT HIGHWAY SPEEDS 60MPH & ABOVE. THE DEALER HAS, SO FAR, REPLACED FRONT RIGHT TRANSAXLE, BALANCED TIRES 4-TIMES, AND REPLACED OEM GOODYEAR EAGLE LS TIRES (205/55/16) WITH BRIDGESTONE POTENZA TIRES (205/55/16). HOWEVER, THE FRONT TIRES REPEATEDLY GET OUT OF BALANCE EVERY NOW AND THEN, AND SEVERE STEERI…
Read full complaint
SEVERE STEERING VIBRATIONS AT HIGHWAY SPEEDS 60MPH & ABOVE. THE DEALER HAS, SO FAR, REPLACED FRONT RIGHT TRANSAXLE, BALANCED TIRES 4-TIMES, AND REPLACED OEM GOODYEAR EAGLE LS TIRES (205/55/16) WITH BRIDGESTONE POTENZA TIRES (205/55/16). HOWEVER, THE FRONT TIRES REPEATEDLY GET OUT OF BALANCE EVERY NOW AND THEN, AND SEVERE STEERING VIBRATIONS CONTINUE AT 60MPH HIGHWAY SPEED, WHICH IS CREATING A POTENTIAL LIFE-THREATENING SAFETY HAZARD EVERY TIME THE VEHICLE IS DRIVEN OVER 60-65 MPH SPEEDS.*AK
Official recalls
204V428000 · Equipment:other:labels
Sep 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.
02V147000 · Electrical System:wiring:front Underhood
May 29, 2002
ON CERTAIN PASSENGER VEHICLES, ROUTING OF THE VEHICLE'S FRONT HARNESS CAN ALLOW IT TO COME IN CONTACT WITH A ROUGH EDGE, ALLOWING ABRASION. THIS COULD RESULT IN GROUNDED CIRCUITS.
Consequence & remedy
Consequence: THERE COULD BE A LOSS OF STOP OR TURN SIGNAL LAMP OPERATION OR ENGINE HESITATION.
Remedy: DEALERS WILL INSTALL A PROTECTOR, ELIMINATING ANY HARNESS CONTACT. OWNER NOTIFICATION BEGAN JULY 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08011 · Passenger Door Fire
Opened Jul 1, 2008 · Closed Aug 21, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Visibility; Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Additional source detail variants (5)
Electrical System
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:fuses And Circuit Breakers
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Electrical System:wiring:interior/under Dash
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
Visibility:power Window Devices And Controls
IN RESPONSE TO THIS INVESTIGATION, MITSUBISHI MOTORS NORTH AMERICA (MMNA) INITIATED A SPECIAL PROGRAM ON JULY 31, 2009, TO EXTEND THE WARRANTY COVERAGE ON MODEL YEAR (MY) 2001-2003 GALANT VEHICLE PASSENGER SIDE WINDOW SWITCHES TO 10 YEARS OR 120,000 MILES, WHICHEVER COMES FIRST.NOTIFICATION OF THIS SPECIAL COVERAGE PROGRAM TO ALL REGISTERED VEHICLE OWNERS IS SCHEDULED TO BEGIN IN LATE-SEPTEMBER 2009.OWNERS WHO HAVE EXPERIENCED A PROBLEM WITH THE POWER WINDOW SWITCH (BLOWN FUSE, INTERMITTENT OPERATION OR POWER WINDOW MALFUNCTION) OR WHO SPILLED LIQUIDS OR BEVERAGES ONTO THE FRONT PASSENGER DOOR WINDOW SWITCH WILL BE ENTITLED TO HAVE THE SWITCH REPLACED AND ANY RELATED REPAIRS PERFORMED AT NO CHARGE.THE AGENCY IS AWARE OF 35 ALLEGED FRONT PASSENGER DOOR PANEL HEAT, SMOKE OR FIRE INCIDENTS, INCLUDING THREE REPORTED MINOR BURNS OR BRUISES.THERE ARE NO REPORTED CRASHES OR FATALITIES.THERE ARE 307 WARRANTY CLAIMS OF SWITCH MALFUNCTIONS OR SHORT CIRCUITS WITHOUT ANY REPORTED HEAT, SMOKE OR FIRE.MMNA INSPECTION AND ANALYSIS OF FIRE-DAMAGED DOOR PANELS/SWITCHES FOUND EVIDENCE OF SPILLED LIQUIDS WITH HIGH SUGAR CONTENT ON THE POWER WINDOW SWITCHES.MMNA CLAIMS THE RESIDUE OF THESE LIQUIDS LED TO A SHORTING/SMOKE/ FIRE CONDITION INSIDE THE SWITCH/DOOR PANEL ASSEMBLY.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION.
PE08014 · Passenger Door Fire
Opened Mar 4, 2008 · Closed Jul 1, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash; Visibility; Visibility:glass, Side/rear; Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Additional source detail variants (6)
Electrical System
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring:interior/under Dash
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Electrical System:wiring
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:glass, Side/rear
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.
Visibility:power Window Devices And Controls
COMPLAINTS ALLEGE THAT A FIRE ERUPTED IN THE FRONT PASSENGER DOOR.IN MITSUBISHI'S RESPONSE TO ODI'S MARCH 12, 2008 INFORMATION REQUEST, MITSUBISHI ASSERTS THAT THE ALLEGED DEFECT MAY OCCUR WHEN LARGE AMOUNTS OF LIQUIDS, MORE THAN 100CC (3.4 OZ), LIKE A SOFT DRINK WERE SPILLED DIRECTLY OVER THE POWER WINDOW SWITCH AREA, ALL AT ONCE AND AT ONE TIME.MITSUBISHI FOUND THAT AS THE LIQUID DRIES OFF, ELECTROLYTES AND CARBONIZED PARTICLES ACCUMULATE BETWEEN THE TERMINALS IN THE POWER WINDOW SWITCH AND BECOME A CONDUCTIVE MATERIAL.AS A RESULT, THE SWITCH MAY START TO HEAT UP AND MELT OR IGNITE THE PLASTIC COMPONENTS.HOWEVER, MITSUBISHI ALSO ASSERTS THAT THE ALLEGED DEFECT IS VERY RARE AND THAT BURNING DAMAGE WILL NOT OCCUR UNLESS LIQUIDS ENTER INTO THE POWER WINDOW SWITCH.ODI UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS, EA08-011, TO FURTHER EVALUATE THIS ISSUE.