FUEL RELAY SWITCH ON MY MITSUIBISHI ECLIPSE 1997 GS HAS FAILED ON SEVERAL OCCASIONS. IN ORDER TO GET MY CAR TO START, I HAVE TO GO UNDER THE HOOD, "WIGGLE" THE RELAY SWITCH AND LIGHTLY TAP ON THE TOP OF IT. THIS FUEL RELAY HAS BEEN REPLACED BY DEALER AND THE PROBLEM CONTINUES TO OCCUR, EVEN CAUSING THE CAR TO GO DEAD DURING TR…
Read full complaint
FUEL RELAY SWITCH ON MY MITSUIBISHI ECLIPSE 1997 GS HAS FAILED ON SEVERAL OCCASIONS. IN ORDER TO GET MY CAR TO START, I HAVE TO GO UNDER THE HOOD, "WIGGLE" THE RELAY SWITCH AND LIGHTLY TAP ON THE TOP OF IT. THIS FUEL RELAY HAS BEEN REPLACED BY DEALER AND THE PROBLEM CONTINUES TO OCCUR, EVEN CAUSING THE CAR TO GO DEAD DURING TRAVEL. DEALERSHIP CLAIMS THEY DO NOT KNOW WHY IT OCCURS. (20+ OCCURRENCES) ENORMOUS AMOUNTS OF "BLUISH" GAS FUMES COMING FROM THE TAIL PIPE, REGARDLESS OF IDLE OR IN MOTION. (ALWAYS OCCURRING) SUNROOF STICKS (5-10 OCCURRENCES) BOTH DRIVER AND PASSENGER WINDOWS RATTLE WHEN CAR IS IN MOTION AND AS THE DOOR IS BEING SHUT (CONTINUOUS OCCURRENCE) CLUTCH FAILURE, HARD SHIFTING (1 OCCURRENCE). *JB
NHTSA ODI #10107645
Mileage unknown · Apr 16, 2001
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
VEHICLE WILL STALL WHILE DRIVING REGARDLESS OF SPEED AND WITHOUT WARNING. DEALER HAS REPLACED FUELPUMP/ IGNITION SWITCH AND COMPUTER, BUT DEFECT STILL OCCURS.*AK
NHTSA ODI #885963
Mileage unknown · Mar 27, 2001
Fuel System, Gasoline
VEHICLE HAS A BAD GASOLINE SMELL. CONTACTED DEALER, AND DEALER SAID THERE IS NOTHING THEY CAN DO.*AK
NHTSA ODI #884273
Mileage unknown · Nov 9, 2000
Fuel System, GasolinePower TrainCrashInjury
WHILE DRIVING AT APPROXIMATELY 30MP RIGHT FRONT AXLE BROKE DUE TO POOR METAL, CAUSING LOSS OF CONTROL AND GAS TANK TO RUPTURE. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.
THE HEADREST GUIDE BRACKET WAS IMPROPERLY WELDED TO THE SEAT BACK FRAME ON THE PASSENGER SIDE SEAT BACK ASSEMBLIES ONLY.
Consequence & remedy
Consequence: THE HEADREST SUPPORT BRACKET CAN BREAK, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE PASSENGER SEAT BACK ASSEMBLY WITH A NEW ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ98007 · Transfer Case Leakage
Opened May 11, 1998 · Closed Aug 28, 1998
Status: closed (inferred from source dates) · Power Train:automatic Transmission
THE TRANSFER CASE OF THE ALL WHEEL DRIVE (AWD), MITSUBISHI GALANT, ALLEGEDLY LEAKS OIL CAUSING ONE OR MORE WHEELS TO LOCKUP; OR THE INABILITY TO TRANSMIT ENGINE POWER TO THE DRIVE WHEELS.THE VEHICLES HAVE THE SAME TRANSFER CASE DESIGN AS THE ECLIPSE VEHICLES WHICH HAVE BEEN RECALLED FOR THE SAME ALLEGED DEFECT.
Additional source detail variants (2)
Power Train:automatic Transmission
THE TRANSFER CASE OF THE ALL WHEEL DRIVE (AWD), MITSUBISHI GALANT, ALLEGEDLY LEAKS OIL CAUSING ONE OR MORE WHEELS TO LOCKUP; OR THE INABILITY TO TRANSMIT ENGINE POWER TO THE DRIVE WHEELS.THE VEHICLES HAVE THE SAME TRANSFER CASE DESIGN AS THE ECLIPSE VEHICLES WHICH HAVE BEEN RECALLED FOR THE SAME ALLEGED DEFECT.
Power Train:automatic Transmission
THE TRANSFER CASE OF THE ALL WHEEL DRIVE (AWD), MITSUBISHI GALANT, ALLEGEDLY LEAKS OIL CAUSING ONE OR MORE WHEELS TO LOCKUP; OR THE INABILITY TO TRANSMIT ENGINE POWER TO THE DRIVE WHEELS.THE VEHICLES HAVE THE SAME TRANSFER CASE DESIGN AS THE ECLIPSE VEHICLES WHICH HAVE BEEN RECALLED FOR THE SAME ALLEGED DEFECT.
1997 Mitsubishi Eclipse Problems, Complaints & Recalls | Skip That Year
Illustration