IllustrationPASSENGER BAG SYSTEM HAS NOT WORKED FOR OVER TWO YEARS. *TR
2005 Mini Cooper S
Owner reports · Recalls · Investigations
More warning signs than most Cooper S years
Owner complaints for the 2005 Mini Cooper S are substantially higher than the model-year median of 23.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper S years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4525–50K
12050–75K
7275–100K
39100–150K
10150K+
301 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 212 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports17 fire reports2 injury reports
What owners actually said
314 reportsPOWER STEERING PUMP FAILED TO TURN OFF WITH VEHICLE. RESULTED IN BATTERY BEING DRAINED AND ULTIMATELY LOSS OF POWER STEERING. POWER STEERING PUMP, FAN, AND FLUID HAD TO BE REPLACED AS A RESULT OF FAN BECOMING SEIZED, PUMP OVERHEATING AND FAILING. *TR
DASH LIGHT INDICATING A PASSENGER AIRBAG PROBLEM LIGHTS UP. *TR
ABOUT 1 WEEK AFTER I BOUGHT THE CAR, THE PASSENGER AIR BAG OFF LIGHT COMES ON WHEN I HAVE A PASSENGER AND THE AIRBAG MALFUNCTION SIGN COMES ON THE DASH. IN THE MANUAL IT SAYS :IN THE EVENT OF A MALFUNCTION, HAVE THE AIRBAG SYSTEM CHECKED IMMEDIATELY. OTHERWISE, THERE IS A RISK THAT THE SYSTEM WILL NOT FUNCTION AS INTENDED IN RES…
Read full complaint
ABOUT 1 WEEK AFTER I BOUGHT THE CAR, THE PASSENGER AIR BAG OFF LIGHT COMES ON WHEN I HAVE A PASSENGER AND THE AIRBAG MALFUNCTION SIGN COMES ON THE DASH. IN THE MANUAL IT SAYS :IN THE EVENT OF A MALFUNCTION, HAVE THE AIRBAG SYSTEM CHECKED IMMEDIATELY. OTHERWISE, THERE IS A RISK THAT THE SYSTEM WILL NOT FUNCTION AS INTENDED IN RESPONSE TO A SEVERE IMPACT OCCURRING WITHIN THE SYSTEM'S NORMAL TRIGGERING RANGE. I HAVE BUMPER TO BUMPER WARRANTY BUT THEY TOLD ME IT IS NOT A SAFETY ISSUE AND I HAVE TO PAY 100 TO HAVE IT LOOKED AT. I JUST WANT TO MAKE SURE EVERYTHING IS OKAY. BUT I DO NOT HAVE THE MONEY TO DO THAT. *TR
PASSENGER SAFETY INDICATOR LIGHT REMAINS ON. CALLED LOCAL MINI SERVICE CENTER AFTER READING MULTIPLE COMPLAINTS ON THIS ISSUE AND THEY STATED THEY (MINI USA) HAVE/WILL NOT SERVICE/REPAIR THE FAULTY SEAT MODULE. THIS MUST BE CONSIDERED AS A SAFETY ISSUE FOR THE PASSENGER AND SHOULD BE DEALT WITH UNDER AN EXTENDED WARRANTY OR RECA…
Read full complaint
PASSENGER SAFETY INDICATOR LIGHT REMAINS ON. CALLED LOCAL MINI SERVICE CENTER AFTER READING MULTIPLE COMPLAINTS ON THIS ISSUE AND THEY STATED THEY (MINI USA) HAVE/WILL NOT SERVICE/REPAIR THE FAULTY SEAT MODULE. THIS MUST BE CONSIDERED AS A SAFETY ISSUE FOR THE PASSENGER AND SHOULD BE DEALT WITH UNDER AN EXTENDED WARRANTY OR RECALL. *TR
POWER STEERING PUMP FAILED, AND THERE IS A RECALL FOR 2002-2005 COOPERS, BUT FOR SOME REASON OUR VIN IS NOT COVERED, WHY? OBVIOUSLY THE RECALL CAME LONG AFTER THE CARS WERE DELIVERED, DOES OUR REALLY HAVE A DIFFERENT PART NUMBER OF PUMP? WHY ISN'T OUR COVERED BY THE RECALL? *TR
ABOUT TWO WEEKS PRIOR TO THE FIRE, MY BACK BUMPER WAS HIT BY SOMEONE,NOTHING TOO SERIOUS JUST THE TAIL LIGHT BROKEN. THEIR INSURANCE HAD MY CAR FIXED AT WORLD TOYOTA COLLISION CENTER IN ATLANTA GEORGIA. ON SATURDAY MORNING, I PICKED UP MY CAR. I NOTICED CLICKING NOISE COMING OUT FROM INSIDE THE CAR AND THE STEERING WHEEL BECOMIN…
Read full complaint
ABOUT TWO WEEKS PRIOR TO THE FIRE, MY BACK BUMPER WAS HIT BY SOMEONE,NOTHING TOO SERIOUS JUST THE TAIL LIGHT BROKEN. THEIR INSURANCE HAD MY CAR FIXED AT WORLD TOYOTA COLLISION CENTER IN ATLANTA GEORGIA. ON SATURDAY MORNING, I PICKED UP MY CAR. I NOTICED CLICKING NOISE COMING OUT FROM INSIDE THE CAR AND THE STEERING WHEEL BECOMING RIGID AS SOON AS I STARTED DRIVING. I PULLED TO THE CLOSEST GAS STATION (WAS IN NEED OF GAS AS WELL). WHITE SMOKE CAME OUT FROM THE FRONT RIGHT AFTER I PARKED. MY HUSBAND LIFTED UP THE HOOD TRYING TO SEE WHERE THE SMOKE IS FROM. NOT EVEN TWO MINUTES LATER, THERE WAS FLAME, YES, ACTUAL FIRE UNDERNEATH THE ENGINE COMPARTMENT. FORTUNATELY, THERE WERE TWO OFFICERS NEXT TO US AT THAT TIME SO THEY USED FIRE EXTINGUISHER TO TAKE THE FIRE DOWN. I'M EXTREMELY FRIGHTENED AND DISAPPOINTED AT MINI COOPER. VERY DANGEROUS CAR. *TR
POWER STEERING ABRUPTLY STOPPED WORKING WHILE CORNERING CAUSING DRIVER TO USE HEAVY MANUAL FORCE TO CORNER THE VEHICLE THRU A TRICKY VIADUCT TRAIN BRIDGE PASSAGEWAY. WHILE MIDWAY INTO THE TURN, THE POWER STEERING ABRUPTLY "KICKED BACK ON" CAUSING THE STEERING WHEEL TO TURN VIOLENTLY ACROSS LANE AND NEARLY INTO CORNER OF CEMENT …
Read full complaint
POWER STEERING ABRUPTLY STOPPED WORKING WHILE CORNERING CAUSING DRIVER TO USE HEAVY MANUAL FORCE TO CORNER THE VEHICLE THRU A TRICKY VIADUCT TRAIN BRIDGE PASSAGEWAY. WHILE MIDWAY INTO THE TURN, THE POWER STEERING ABRUPTLY "KICKED BACK ON" CAUSING THE STEERING WHEEL TO TURN VIOLENTLY ACROSS LANE AND NEARLY INTO CORNER OF CEMENT WALL HOLDING UP OVERHEAD TRAIN BRIDGE. OTHER CARS WERE MISSED, AND DRIVER STOPPED CAR WITH FRONT BUMPER SLIGHTLY TOUCHING VIADUCT CEMENT WALL. WIFE AND 7 YEAR OLD CHILD WERE ON THE IMPACT SIDE OF VEHICLE. VEHICLE WAS CHECKED BY AN INDEPENDENT MECHANIC WHICH NOTED THE EHPS POWER STEERING PUMP IS FAILING. HE CLEANED THE POWER STEERING PUMP AND INSTALLED A NEW COOLING FAN ON THE POWER STEERING PUMP. THE PUMP WAS OVERHEATED AND PACKED WITH METAL DEBRIS. INDEPENDENT MECHANIC ADVISED ME TO RETURN TO MINI AS POTENTIAL RECALL ISSUE WHICH HAS BEEN WIDELY REPORTED BUT REFUTED BY MINI. POWER STEERING PUMP STILL HAS SIGNIFICANT NOISE AND IS SCHEDULED FOR REVIEW BY A MINI DEALER. *TR
A "POP" WAS HEARD WHEN I WAS DRIVING MY VEHICLE ON I95. I WAS ABLE TO PULL OVER TO THE SIDE CONSIDERING WHEN THE "POP" OCCURRED, MY MINI LOST POWER. AS I WAS PULLED OVER, THE VEHICLE BURST INTO FLAMES. *TR
POWER STEERING SYSTEM FIRE. *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
15V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).