IllustrationA "POP" WAS HEARD WHEN I WAS DRIVING MY VEHICLE ON I95. I WAS ABLE TO PULL OVER TO THE SIDE CONSIDERING WHEN THE "POP" OCCURRED, MY MINI LOST POWER. AS I WAS PULLED OVER, THE VEHICLE BURST INTO FLAMES. *TR
2005 Mini Cooper S
Owner reports · Recalls · Investigations
More warning signs than most Cooper S years
Owner complaints for the 2005 Mini Cooper S are substantially higher than the model-year median of 23.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper S years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4525–50K
12050–75K
7275–100K
39100–150K
10150K+
301 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 212 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports17 fire reports2 injury reports
Engine And Engine Cooling complaints
8 reportsMY PROBLEM IS WITH A 2005 MINI COOPER S. WHY IS THEIR NOT A RECALL ON THE WATER PUMP? IT HAS BEEN KNOW FOR GOING OUT PREMATURE AND BMW HAS REDESIGNED THE NEW PUMPS WITH A METAL IMPELLER INSTEAD OF PREVIOUS PLASTIC. TALKING TO THE DEALER, THEY MADE ME FEEL FORTUNATE THAT MY WATER PUMP MADE IT TO 50,000 MILES STATING THEY REPLACE …
Read full complaint
MY PROBLEM IS WITH A 2005 MINI COOPER S. WHY IS THEIR NOT A RECALL ON THE WATER PUMP? IT HAS BEEN KNOW FOR GOING OUT PREMATURE AND BMW HAS REDESIGNED THE NEW PUMPS WITH A METAL IMPELLER INSTEAD OF PREVIOUS PLASTIC. TALKING TO THE DEALER, THEY MADE ME FEEL FORTUNATE THAT MY WATER PUMP MADE IT TO 50,000 MILES STATING THEY REPLACE MANY WATER PUMPS IN THE 1ST GENERATION SERIES AROUND 20,000 MILES. I STRONGLY BELIEVE THIS IS DANGEROUS, AS THE FAILURE CAN CAUSE OVERHEATING AND REQUIRES YOU TO SHUT OFF THE CAR, AND SIT ON THE SIDE OF THE ROAD. CARS ARE NOT MADE TO OVER HEAT. THIS GREATLY INCREASES THE CHANCE OF A FIRE. BMW KNOWS THEY HAVE A PROBLEM BUT IS NOT RECALLING THE WATER PUMPS UNTIL 2006-2011. I THINK THE 1ST GENERATION MINIS SHOULD HAVE THE SAME RECALL AS MOST MINIS INCLUDING MINE HAS/HAD A WATER PUMP ISSUE AND WOULD LIKE OVER A THOUSAND DOLLARS TO HAVE IT REPLACED. I HAVE CAUGHT MINE EARLY BUT ONLY BECAUSE I JACK UP MY MINI TO CLEAN THE UNDERBODY ABOUT ONCE A MONTH. MINI COOPERS ARE WELL KNOWN FOR THEIR WATER PUMPS, THERMOSTATS, AND POWER STEERING, FAILING. I AM 18 YEARS OLD AND WOULD LIKE TO USE THIS CAR TO TRAVEL FROM SOUTH CAROLINA TO WISCONSIN IN THE FUTURE, YET IF MY COOLANT SYSTEM (WATER PUMP OR THERMOSTAT) COULD GO OUT AGAIN AT ANY TIME AND COST A FORTUNE TO REPLACE AND LEAVE ME STRANDED ON THE SIDE OF A HIGHWAY. I WILL BE TAKING A PLANE EVERY TIME I TRAVEL A FEW HUNDRED MILES AND RENT A CAR. THIS MUST BE ADDRESSED! I JUST PAID 1200 FOR MINI TO REPLACE A WATER PUMP THAT SHOULD HAVE HAD AT THE LEAST 30-50 THOUSAND MILES MORE. *TR
MY 2005 MINI COOPER S OUT OF NO WHERE BURIED THE NEEDLE ON THE THERMOSTAT AND WAS COMPLETELY OVERHEATED. UNABLE TO DRIVE ANY FURTHER AS I SMELT SMOKE AND POSSIBLY A SWEET SMELL COMING FROM THE ENGINE. HAD IT TOWED TO A MECHANIC AND HAVE NOW SEEN THAT THIS IS AN ITEM THAT HAS BEEN RECALLED ON ALL MINI COOPERS S FROM 2006 TO 2011…
Read full complaint
MY 2005 MINI COOPER S OUT OF NO WHERE BURIED THE NEEDLE ON THE THERMOSTAT AND WAS COMPLETELY OVERHEATED. UNABLE TO DRIVE ANY FURTHER AS I SMELT SMOKE AND POSSIBLY A SWEET SMELL COMING FROM THE ENGINE. HAD IT TOWED TO A MECHANIC AND HAVE NOW SEEN THAT THIS IS AN ITEM THAT HAS BEEN RECALLED ON ALL MINI COOPERS S FROM 2006 TO 2011, I FIND IT HARD TO BELIEVE THAT THE 2005 DOES NOT HAVE THE SAME PUMP ELECTRICAL CIRCUIT BOARD ETC. AS THOSE AND I FEEL THAT MY CAR SHOULD BE ALSO RECALLED FOR THIS ITEM. OBVIOUSLY, I CAN NOT DRIVE IT AND THE PRICE IS OUTRAGEOUS TO FIX IT. *TR
VEHICLE FIRE 5/2/2012. CAR PARKED FOR 4 HRS. RETURNED TO CAR & DROVE IT <50 YARDS FOR ~2 MINUTES (MOVED IT FROM STREET TO PARKING LOT). TURNED IT OFF AND WENT IN STORE. RETURNED ~4 MINUTES LATER, NOTICED SMOKE/EXHAUST SMELL; PRESUMED IT WAS ADJACENT CAR. UNLOCKED CAR. CAR WOULD'T START (NO LIGHTS/ELECTRICAL AT ALL). I THE…
Read full complaint
VEHICLE FIRE 5/2/2012. CAR PARKED FOR 4 HRS. RETURNED TO CAR & DROVE IT <50 YARDS FOR ~2 MINUTES (MOVED IT FROM STREET TO PARKING LOT). TURNED IT OFF AND WENT IN STORE. RETURNED ~4 MINUTES LATER, NOTICED SMOKE/EXHAUST SMELL; PRESUMED IT WAS ADJACENT CAR. UNLOCKED CAR. CAR WOULD'T START (NO LIGHTS/ELECTRICAL AT ALL). I THEN NOTICED WHITE SMOKE COMING FROM HOOD. OPENED HOOD THEN NOTICED FLAME/FIRE INSIDE ENGINE COMPARTMENT. WENT IN STORE, GOT FIRE EXTINGUISHER AND PUT FIRE OUT. INVOICE WAS >$3500 FROM MINI DEALER. THE DEALER'S ASSESSMENT: "VERIFIED POWER STEERING PUMP HAS OVERHEATED TO THE POINT WHERE IT HAS BURNED UP INTERNALLY AS WELL AS EXTERNALLY (MELTING ALL THREE CONNECTORS AND THE WIRING LEADING TO THEM). INSPECTED POWER STEERING COOLING FAN AND VERIFIED COOLING FAN IS SEIZING UP WHICH VERY LIKELY LED TO THE OVERHEATING AND EVENTUAL FAILURE OF THE POWER STEERING PUMP. REMOVED ENGINE COMPARTMENT FUSE BOX TO EXAMINE MEGAFUSE POWERING THE POWER STEERING PUMP, FUSE IS INTACT AND DID NOT BURN UP. INSPECTED POWER STEERING PRESSURE HOSE AND IT APPEARS THE RUBBER SECTION OF THE POWER STEERING PRESSURE LINE WAS SUBJECTED TO THE HEAT/MELTING OF THE MAIN POWER CONNECTOR (IT'S IN VERY CLOSE PROXIMITY TO THE CONNECTOR) AND IT APPEARS THE HOSE HAS TAKEN A LEVEL OF DAMAGE FROM THE HEAT. RECOMMEND REPLACEMENT OF POWER STEERING PUMP, THE WIRING SECTION/CONNECTOR PIGTAIL FROM THE FUSE BOX (THIS IS THE MAIN POWER CONNECTOR), THE ENGINE WIRING HARNESS (CONTAINS TWO OTHER ELECTRICAL CONNECTORS TO THE PUMP WHICH RECEIVED EXTENSIVE DAMAGE), THE POWER STEERING FAN (LIKELY CAUSE OF FAILURE), POWER STEERING PRESSURE LINE (HIGH PRESSURE HYDRAULIC LINE WHICH HAS BEEN EXPOSED TO THE MAIN CONNECTOR MELTING AND SUBSEQUENT HEAT), AND OTHER MISCELLANEOUS ITEMS ASSOCIATED WITH THOSE COMPONENTS (O-RINGS, CRUSH RINGS, HOSE CLAMPS ECT...)" *TR
ENGINE COOLING FAN LOW SPEED STAGE FAILURE. THERE HAS BEEN A RECALL OF COOLING FAN FOR THE SAME MODEL UP TO MODEL YEAR 2004. BUT MY 2005 MINI COOPER S HAS THE SAME PROBLEM. THUS, IT IS APPROPRIATE TO EXTEND THE RECALL TO INCLUDE MODEL YEAR 2005. *JS
OVER HEATING CONSTANTLY NO TECHNICAL PERSON KNOWS OF A REMEDY. OVERFLOW TANK BLOWS OUT WHEN CAR OVERHEATS CONSTANTLY .THIS SEEMS TO BE A PROBLEM SINCE THE BEGINNING NO MATTER WHAT YEAR THE CAR WAS BUILT AND NEVER REMEDIED. WHY NOT A RECALL? NOT KNOWING WHAT OTHER DAMAGE THIS CAUSES TO THE ENGINE. THIS HAS TO BE A RECALL FOR…
Read full complaint
OVER HEATING CONSTANTLY NO TECHNICAL PERSON KNOWS OF A REMEDY. OVERFLOW TANK BLOWS OUT WHEN CAR OVERHEATS CONSTANTLY .THIS SEEMS TO BE A PROBLEM SINCE THE BEGINNING NO MATTER WHAT YEAR THE CAR WAS BUILT AND NEVER REMEDIED. WHY NOT A RECALL? NOT KNOWING WHAT OTHER DAMAGE THIS CAUSES TO THE ENGINE. THIS HAS TO BE A RECALL FOR THE COMPANY TO FIX IT IS A HIT AND MISS FIX??? THIS IS A COSTLY PROCESS AND EVEN IN THE FORUMS ON MINI IT HAS BEEN AN ONGOING ISSUE. FRONT END FAILS ALL AT THE SAME TIME. (CONTROL ARMS, CV JOINTS) STEERING BECOMES HARD TO CONTROL. MINI HELP *TR
TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE PARKED, A FIRE ERUPTED UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A POLICE REPORT WAS AVAILABLE. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE FAILURE MILEAGE WAS 10,000. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.
THE MINI COOPER ENGINE HAS AN INTERNAL THERMOSTAT THAT IS PLASTIC, WHEN MINE CRACKED AND LEAKED I HAD NO SIGNS SHOWING THAT. THE ENGINE ONE DAY GOT HOT, I DROVE ABOUT 5 MILES AND STOPPED. I TOOK IT TO A REPAIR SHOP AND I NEED A NEW ENGINE. THE REPAIR SHOP SAID THIS HAPPENS ALOT. *TR
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
15V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).