IllustrationPASSENGER SEAT AIRBAG SENSOR FAILED. *TR
2005 Mini Cooper S
Owner reports · Recalls · Investigations
More warning signs than most Cooper S years
Owner complaints for the 2005 Mini Cooper S are substantially higher than the model-year median of 23.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cooper S years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4525–50K
12050–75K
7275–100K
39100–150K
10150K+
301 reports with mileage · 13 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 212 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports17 fire reports2 injury reports
Air Bags complaints
71 reportsTHE AIRBAG SENSOR IN THE PASSENGER SIDE SEAT DOES NOT CORRECTLY DETECT A PERSON SITTING IN IT. WHEN A PASSENGER IS IN THE SEAT, THE AIRBAG SENSOR STAYS "OFF". *TR
VERY DISAPPOINTED TO FIND OUT THAT A VEHICLE I HAVE TAKEN EXCEPTIONAL CARE OF TO AVOID COSTLY REPAIRS HAS ALSO HAD THE OCCUPANCY MAT GO BAD OUT OF THE BLUE.... I WASN'T EVEN DRIVING THE CAR! I HELD OUT HOPE THAT THE REPAIR WOULD BE COVERED UNDER WARRANTY, AND WAS TOLD OFF THE RECORD BY THE SERVICE ADVISOR THAT THIS ISSUE HAS BEE…
Read full complaint
VERY DISAPPOINTED TO FIND OUT THAT A VEHICLE I HAVE TAKEN EXCEPTIONAL CARE OF TO AVOID COSTLY REPAIRS HAS ALSO HAD THE OCCUPANCY MAT GO BAD OUT OF THE BLUE.... I WASN'T EVEN DRIVING THE CAR! I HELD OUT HOPE THAT THE REPAIR WOULD BE COVERED UNDER WARRANTY, AND WAS TOLD OFF THE RECORD BY THE SERVICE ADVISOR THAT THIS ISSUE HAS BEEN ONE OF THE BIGGEST COMPLAINTS HE RECEIVES AND IN HIS OPINION HAS COST MINI A TREMENDOUS AMOUNT OF REPEAT BUSINESS. IT IS VERY HARD TO SWALLOW THE $1400 REPAIR WHEN IT IS EVIDENT THAT THIS IS A MANUFACTURES PROBLEM WHICH WILL COST SOMEONE THEIR LIFE ONE DAY; MAYBE THEN THEY WILL DO THE RIGHT THING AND FIX THEIR PROBLEMS. LIKE TOYOTA; IT TOOK PEOPLE DYING FOR THEM TO ADDRESS THE ACCELERATOR PROBLEM. SAD, VERY SAD. *TR
THE AIRBAG WARNING LIGHT COMES ON INTERMITTENTLY. THE REPAIR SHOP SAYS THE SENSOR UNDER THE PASSENGER SEAT IS BAD. BMW HAS KNOWN ABOUT THIS ISSUE FOR SEVERAL YEARS AND ISSUED A 10 YEAR 150,000 MILE EXTENDED WARRANTY AND RECALL FOR APPROXIMATELY 150,000 VEHICLES OVER MODEL YEARS 2004 - 2006. FOR SOME REASON THEY REFUSE TO INCL…
Read full complaint
THE AIRBAG WARNING LIGHT COMES ON INTERMITTENTLY. THE REPAIR SHOP SAYS THE SENSOR UNDER THE PASSENGER SEAT IS BAD. BMW HAS KNOWN ABOUT THIS ISSUE FOR SEVERAL YEARS AND ISSUED A 10 YEAR 150,000 MILE EXTENDED WARRANTY AND RECALL FOR APPROXIMATELY 150,000 VEHICLES OVER MODEL YEARS 2004 - 2006. FOR SOME REASON THEY REFUSE TO INCLUDE THE 2005 MINI COOPER S IN THE EXTENDED WARRANTY AND WANT ~$2,000 TO REPLACE THE ENTIRE SEAT BOTTOM FOR THE DEFECTIVE SENSOR. THIS IS A SAFETY ISSUE CAUSED BY A KNOWN AND ADMITTED DEFECTIVE PART. MINI SHOULD ISSUE A RECALL AND REPLACE THE DEFECTIVE SENSOR UNDER EXTENDED WARRANTY AS THEIR PARENT COMPANY BMW HAS DONE FOR VARIOUS MODELS AFFECTED BY THE SAME DEFECT. *TR
THE PASSENGER AIRBAG SRS FLOOR MAT SENSOR IS DAMAGED AND MAY CAUSE THE PASSENGER AIRBAG TO NOT DEPLOY IN THE CASE OF AN ACCIDENT. THE SRS AIRBAG LIGHT IS ILLUMINATED. *TR
TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING APPROXIMATELY 35 MPH, THE PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE FAILURE OCCURRED WHENEVER THE ENGINE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FRONT PASSENGER SEAT SENSOR PAD WAS FAULT…
Read full complaint
TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING APPROXIMATELY 35 MPH, THE PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE FAILURE OCCURRED WHENEVER THE ENGINE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FRONT PASSENGER SEAT SENSOR PAD WAS FAULTY AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM IN WHICH THERE WAS NO RESOLUTION. THE APPROXIMATE FAILURE MILEAGE WAS 41,000.
2005 MINI COOPER WARNING LIGHTS INDICATED THE PASSENGER SIDE AIR BAG TURNED OFF WHILE AN ADULT PASSENGER WAS IN THE PASSENGER SEAT. ISSUE STARTED DURING A COLD NY WINTER AFTER 5 YRS OF FAULT FREE OPERATION. NORMALLY THE PASSENGER SEAT WILL SENSE THE WEIGHT OF A PASSENGER AND AUTOMATICALLY ADJUST THE FORCE OF A DEPLOYING AIRBAG.…
Read full complaint
2005 MINI COOPER WARNING LIGHTS INDICATED THE PASSENGER SIDE AIR BAG TURNED OFF WHILE AN ADULT PASSENGER WAS IN THE PASSENGER SEAT. ISSUE STARTED DURING A COLD NY WINTER AFTER 5 YRS OF FAULT FREE OPERATION. NORMALLY THE PASSENGER SEAT WILL SENSE THE WEIGHT OF A PASSENGER AND AUTOMATICALLY ADJUST THE FORCE OF A DEPLOYING AIRBAG. DEALER REPORTED FAULTY SEAT MAT SENSOR WITH A REPLACEMENT COST OF $1300 WHICH IS NOT COVERED BY WARRANTY. AFTER EXTENSIVE INTERNET SEARCH FOR SIMILAR PROBLEMS, THESE SENSOR MATS FAIL AT A REGULAR RATE, AND ARE NOT COVERED BY ANY RECALL. DUE TO THE HIGH COST AND REPEATED FAILURE THESE REPAIRS ARE NOT BEING PERFORMED. *TR
THE AIRBAG LIGHT FOR THE PASSENGER SEAT COMES ON INTERMITTENTLY WHEN SOMEONE IS SITTING IN THE SEAT. ALSO, THE LIGHT WHICH INDICATES THE PASSENGER SIDE AIRBAG IS OFF COMES ON WHEN SOMEONE IS SITTING IN THE PASSENGER SEAT. CERTAINLY, THIS IS A SAFETY ISSUE AND WE BELIEVE BMW/MINI SHOULD FIX THIS AT NO CHARGE. *TR
PASSENGER AIRBAG SYSTEM FAILURE--PASSENGER AIRBAG OFF LIGHT ILLUMINATED AND WON'T GO OUT. ACCORDING TO WEB-FORUMS, PART FAILED IS A SEAT SENSOR. DEALER WANTS CLOSE TO $2K TO REPLACE IT, BUT IT FAILED A LONG LONG LONG TIME AGO. I WOULD THINK IT SHOULD LAST LONGER THAN 2 OR 3 YEARS. CAN FIND TONS OF THE SAME PROBLEMS AT HTTP:/…
Read full complaint
PASSENGER AIRBAG SYSTEM FAILURE--PASSENGER AIRBAG OFF LIGHT ILLUMINATED AND WON'T GO OUT. ACCORDING TO WEB-FORUMS, PART FAILED IS A SEAT SENSOR. DEALER WANTS CLOSE TO $2K TO REPLACE IT, BUT IT FAILED A LONG LONG LONG TIME AGO. I WOULD THINK IT SHOULD LAST LONGER THAN 2 OR 3 YEARS. CAN FIND TONS OF THE SAME PROBLEMS AT HTTP://WWW.NORTHAMERICANMOTORING.COM/FORUMS/STOCK-PROBLEMS-ISSUES-9-2.HTML. *TR
THE AIRBAG LIGHT ON THE DASH CAME ON WHILE DRIVING. THERE WAS NO ACCIDENT OR INCIDENT THAT PROMPTED THE LIGHT TO COME ON. APPARENTLY, MINIS PRODUCED THREE MONTHS AFTER THIS VEHICLE ARE INCLUDED IN A RECALL OR "EXTENDED WARRANTY" BY THE MANUFACTURER FOR AIRBAG SENSOR LIGHTS, BUT NOT THIS SPECIFIC VEHICLE. BASED ON DISCUSSIONS WIT…
Read full complaint
THE AIRBAG LIGHT ON THE DASH CAME ON WHILE DRIVING. THERE WAS NO ACCIDENT OR INCIDENT THAT PROMPTED THE LIGHT TO COME ON. APPARENTLY, MINIS PRODUCED THREE MONTHS AFTER THIS VEHICLE ARE INCLUDED IN A RECALL OR "EXTENDED WARRANTY" BY THE MANUFACTURER FOR AIRBAG SENSOR LIGHTS, BUT NOT THIS SPECIFIC VEHICLE. BASED ON DISCUSSIONS WITH DEALER SERVICE, IT COULD BE A VERY COSTLY REPAIR, ESTIMATED AT $1200. IT SEEMS VERY STRANGE THAT VEHICLES MANUFACTURED SO CLOSE TO THE COVERED TIME PERIOD ARE ALSO HAVING ISSUES. PERHAPS MINI NEEDS TO CONSIDER EXPANDING THE SCOPE OF THE AIRBAG SENSOR EXTENDED WARRANTY.
Official recalls
215V660000 · Steering:electric Power Assist System
Oct 15, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
15V205000 · Air Bags:frontal
Apr 6, 2015
BMW of North America, LLC (BMW) is recalling certain model year 2005-2006 MINI Cooper and Cooper S vehicles manufactured January 5, 2005, to November 28, 2006, and 2005-2008 MINI Cooper Convertible and Cooper S Convertible vehicles manufactured January 5, 2005, to July 31, 2008. Due to manufacturing, installation, and exposure issues, the front passenger seat occupant detection mat may not function properly and, as a result, the front passenger air bag may not deploy in a crash.
Consequence & remedy
Consequence: An improperly functioning mat may cause the passenger frontal air bag to be inactive when the seat is occupied, and in the event of a crash, the air bag will not deploy, increasing the passenger's risk of injury.
Remedy: MINI will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. The recall began on October 12, 2015. Owners may contact MINI customer service at 1-866-825-1525.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11005 · Loss Of Power Steering Assist
Opened May 4, 2011 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Additional source detail variants (4)
Steering
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist:pump
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
Steering:hydraulic Power Assist System
The Office of Defects Investigation (ODI) originally opened the investigation of loss of power steering assist in model year (MY) 2004 and 2005 Mini Cooper as Preliminary Evaluation PE10-038.The investigation was upgraded to Engineering Analysis EA11-005 in May, 2011.During EA11-005 the scope was expanded to include MY 2002 and 2003 vehicles that use the same steering system.The subject vehicles now include MY 2002, the first year BMW sold MINI in the U.S., through mid-MY 2005 covering approximately 109,000 vehicles.The subject vehicles use an electrically driven pump to provide hydraulic pressure to a conventional rack-and-pinion steering gear.A pump, the electric motor, and an electronic control unit (ECU) are housed in a single component BMW calls a Power Pack.The investigation focused on contaminant-induced failure of the ECU resulting in a loss of assist without warning.When assist is lost mechanical steering is retained however increased steering effort is required to keep the vehicle on an intended path.Some consumers reported that restarting the vehicle (cycling the ignition switch) would often reinstate the steering assist.Additionally, and by design, assist can also reinstate during the drive cycle in limited circumstances.The unexpected loss of assist, and/or possibly the reinstatement of assist while driving, may contribute to a loss of vehicle control in certain driving situations.During MY 2005 production BMW introduced a revised Power Pack design (the ECU incorporated a conformal coating of the circuit board) which resulted in a significant reduction in failures.ODI identified 20 reports describing crashes consistent with a loss of power assist event possibly caused by a failure of the Power Pack.Two reports alleged an injury however both were minor in nature and did not require emergency treatment (a subsequent doctor's visit occurred in one case).Ten of these reports described low speed crashes with minimal, or in most cases no property or vehicle damage (e.g., striking a movable barrier in a parking lot).Additionally 27 other reports alleged or indicated that a crash occurred due to a Power Pack failure however in reviewing these reports, ODI either 1) was unable to confirm that a crash actually occurred (8 reports), or 2) determined that the crash circumstances (e.g., adverse road/weather conditions) or cause (e.g., the crash was caused by steering linkage failure) were not attributable to a Power Pack failure (19 reports).Throughout the investigation BMW maintained that loss of assist in the subject vehicles did not constitute a safety related defect, noting that the subject vehicles are smaller, light weight vehicles that can be reasonably controlled when assist is lost.In May 2013 BMW launched a 13 year/150,000 mile extended warranty coverage utilizing the redesigned Power Pack as a replacement part.ODI continued its investigation.In July 2014 BMW provided ODI a status of the ongoing extended warranty program, and in May 2015 ODI requested an update of complaint data.Following a review of the provided data, ODI informed BMW of its assessment that loss of steering assist failures were not adequately resolved by an extended warranty program.On October 12, 2015 BMW notified NHTSA that it would conduct a safety recall (15V-660) on approximately 86,000 subject vehicles not previously remedied with the new design Power Pack through regular or extended warranty programs.The recall covers MY 2002-2005 MINI Cooper, MY 2002-2005 MINI Cooper S, and MY 2005 MINI Cooper/Cooper S convertibles manufactured through Feb 9, 2005.Vehicles produced after this date are not included si
PE10038 · Loss Of Power Steering Assist
Opened Sep 24, 2010 · Closed May 10, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Additional source detail variants (4)
Steering
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:electric Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist:pump
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).
Steering:hydraulic Power Assist System
ODI has received 339 complaints alleging an unexpected loss of power steering assist while driving the vehicle.When the power steering assist stops working, drivers experienced difficulty in steering and/or controlling the vehicle.According to BMW drivers may experience either a temporary or permanent loss of power steering assist.BMW further advised that a temporary loss of power steering assist may be due to a malfunctioning cooling fan or an under-voltage condition in the power steering system.A permanent loss of power steering assist may be due to an error in the internal electronics, and may also result in the continuous running of the power steering pump.The VOQ complaints allege 5 minor crashes and 3 fires.The crashes are described as hit the curb.The fires are described as melted wires. There were no property damage claims.ODI has received similar complaints for other model year Mini.Additional information is required to evaluate the frequency, consequence, and scope of this issue.Accordingly the investigation has been upgraded to an Engineering Analysis (see EA11-005).