Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1425–50K
850–75K
875–100K
1100–150K
0150K+
38 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Vehicle Speed Control. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports8 injury reports
What owners actually said
71 reports
108,722 miles · Jan 27, 2015
Seat Belts
SEAT BELTS ON 2000 MERCURY VILLAGER ESTATE HAVE LOCKED UP AND WILL NOT RELEASE. CALLED FORD CUSTOMER RELATIONS REGARDING ISSUE AND THEY ARE STATING THEY HAVE NO KNOW ISSUE OR RECALL WITH SEAT BELTS LOCKING UP. REAR SEAT BELTS ARE THE ONES AFFECTED. FORD CUSTOMER RELATIONS IS STATING IT IS OUT OF WARRANTY SO I WILL BE RESPONSIBL…
Read full complaint
SEAT BELTS ON 2000 MERCURY VILLAGER ESTATE HAVE LOCKED UP AND WILL NOT RELEASE. CALLED FORD CUSTOMER RELATIONS REGARDING ISSUE AND THEY ARE STATING THEY HAVE NO KNOW ISSUE OR RECALL WITH SEAT BELTS LOCKING UP. REAR SEAT BELTS ARE THE ONES AFFECTED. FORD CUSTOMER RELATIONS IS STATING IT IS OUT OF WARRANTY SO I WILL BE RESPONSIBLE FOR FIXING VEHICLE. *TR
NHTSA ODI #10679246
90,000 miles · May 20, 2010
Seat Belts
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) EVENT- EVERY TIME THE FRONT SEAT BELTS ARE USED. FAILURE- SEAT BELTS DO NOT PROBERLY RETRACT AFTER EACH USE. SUBSUQUENT DRIVERS AND PASSENGERS WHO USE THE VEHICLE THEN USE THE SEAT BELTS THINK THEY ARE SAFELY BUCKLED INTO THEIR SEAT---…
Read full complaint
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) EVENT- EVERY TIME THE FRONT SEAT BELTS ARE USED. FAILURE- SEAT BELTS DO NOT PROBERLY RETRACT AFTER EACH USE. SUBSUQUENT DRIVERS AND PASSENGERS WHO USE THE VEHICLE THEN USE THE SEAT BELTS THINK THEY ARE SAFELY BUCKLED INTO THEIR SEAT---BUT GUESS WHAT!?!--- THEY AREN'T BUCKLED SAFELY AT ALL BECAUSE 12-18" OF UNRETRACTED SEATBELT IS STILL STUCK IN THE SPACE BETWEEN THE DOOR AND THE DOOR FRAME! ENGINEERS EVEN HAVE A NAME FOR IT, "LAZY RETRACTION". AUTO MAKERS KNOW ABOUT IT, THE GOVERNMENT KNOWS ABOUT IT, BUT NOBODY DOES ANYTHING ABOUT IT. MY OLD DODGE CARAVAN DID IT AFTER 70,000 MILES AND NOW MY MERCURY VILLAGER/NISSAN QUEST STARTED DOUNG IT AFTER 90,000 MILES. CORRECT FAILURE- LECTURE THE [XXX] OUT OF MY WIFE, KIDS AND ANBODY WHO WILL LISTEN ABOUT THE USE OF [XXX], DEFECTIVE SEATBELTS THAT NO LONGER RETRACT SO THAT THEY DON'T THINK THEY ARE SAFELY BUCKLED WHEN THEY ARE NOT! NOBODY WIL EVER CONVINCE ME THIS HASN'T CAUSED INJURIES AND PROBABLY COST LIVES. *TR
NHTSA ODI #10331352
76,000 miles · Oct 14, 2009
Electrical SystemFire
LEFT A FRIENDS HOUSE DROVE 1/3 OF A MILE VAN WAS ON FIRE PULLED OVER TO SIDE OF RODE WAS SMOKING/ TOTALING ENGULFED IN FLAMES AFTER ABOUT 10-15 MINUTES THE VAN WAS A TOTAL LOSS. IT WAS A 2000 VILLAGER COULD THIS BE THE SAME AS THE WINDSTAR.? THE CAR HAD BEEN SITTING IDLE IN DRIVE WAY FOR APP. 3HRS BEFORE THIS INCIDENT.. *TR
NHTSA ODI #10287334
40,000 miles · Jun 24, 2008
Engine And Engine Cooling
THE A/C STOPPED WORKING. *TR
NHTSA ODI #10232143
8,000 miles · Jun 24, 2008
Air BagsCrashInjury
I WAS INVOLVED IN AN ACCIDENT WHILE TRAVELING AT ABOUT 45 MPH. I HIT ANOTHER VEHICLE THAT PULLED OUT IN FRONT OF ME. NO AIR BAGS DEPLOYED. *TR
NHTSA ODI #10232141
Mileage unknown · Jun 4, 2007
Structure
WE HAVE VERY LITTLE MILEAGE ON OUR MERCURY VILLAGER SPORT VAN AND THE PAINT IS CHIPPING. APPARENTLY, THIS SHOULD NOT BE HAPPENING. IT ACTUALLY NEEDS A COMPLETE PAINT JOB. WE HAVE NEVER HAD A VEHICLE DO THIS. IT WILL RUST IF THIS IS NOT TAKEN CARE OF. WE ONLY HAVE APP. 68,000 MILES ON A 2000 YEAR CAR. *TR
NHTSA ODI #10192356
88,168 miles · Feb 18, 2007
Vehicle Speed Control
STICKY ACCELERATOR PEDAL ON 2000 MERCURY VILLAGER. STICKS ABOUT HALF THE TIME CAUSING ABRUPT SURGE INTO TRAFFIC AND DISLODGING OF OCCUPANTS. *NM
NHTSA ODI #10182895
Mileage unknown · Feb 1, 2007
SuspensionVehicle Speed Control
TL*- THE CONTACT STATED THAT HER 2000 MERCURY VILLAGER HAS ACCELERATION PROBLEMS. WHEN AT A COMPLETE STOP OR AT A LOW SPEED, WHEN SHE TRIED TO ACCELERATE, THE VEHICLE WILL NOT ACCELERATE AS EXPECTED. THE CONTACT STATED THAT SHE HAS TO PUT THE FOOT COMPLETELY TO THE FLOOR FOR THE VEHICLE TO ACCELERATE. SHE HAS REPLACED THE THR…
Read full complaint
TL*- THE CONTACT STATED THAT HER 2000 MERCURY VILLAGER HAS ACCELERATION PROBLEMS. WHEN AT A COMPLETE STOP OR AT A LOW SPEED, WHEN SHE TRIED TO ACCELERATE, THE VEHICLE WILL NOT ACCELERATE AS EXPECTED. THE CONTACT STATED THAT SHE HAS TO PUT THE FOOT COMPLETELY TO THE FLOOR FOR THE VEHICLE TO ACCELERATE. SHE HAS REPLACED THE THROTTLE BODY TWICE SINCE SHE OWNED THE VEHICLE. SHE STATED THAT SHE HAD SEVERAL CLOSE CALLS, ALMOST RESULTING IN SEVERAL CRASHES. ALSO, THE STABILIZING LINK WAS CAUSING PROBLEMS WITH THE STEERING. WHEN SHE TURNED LEFT OR RIGHT THERE WAS A NOISE COMING FROM THE FRONT END OF THE DRIVER SIDE WHEEL. IF SHE HIT A HOLE THE VEHICLE MADE A LOUD CLUNKY NOISE. THE CONTACT HAD THE STABILIZER BAR REPAIRED 2/1/07, AND SHE HAS HAD THREE TIRES REPLACED. THE CONTACT STATED THAT DEALERSHIP SAID THE STABILIZER BAR WAS THE CAUSE OF THE TIRES WEARING OUT SO QUICKLY. THERE HAVE BEEN 6 OCCURENCES OF THIS FAILURE. *AK
NHTSA ODI #10181341
45,000 miles · Jan 13, 2007
Electrical SystemVehicle Speed Control
2000 MERCURY VILLAGER HAS COMMON PROBLEM OF GAS PEDAL STICKING AND SPEEDOMETER OUTAGE. BOTH OF THESE ARE SAFETY ISSUES AND NEED TO BE CORRECTED. *JB
NHTSA ODI #10178643
7,000 miles · Nov 13, 2006
Vehicle Speed Control
DT*: THE CONTACT STATED THE ACCELERATOR PEDAL STUCK WHEN DEPRESSED, AND WHEN IT UNSTUCK, THE ADDED PRESSURE CAUSED THE VAN TO LURCH FORWARD. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO DETERMINED THERE WAS NOT ENOUGH LUBRICANT ON THE ACCELERATOR PARTS. THE PROBLEM PERSISTED AF…
Read full complaint
DT*: THE CONTACT STATED THE ACCELERATOR PEDAL STUCK WHEN DEPRESSED, AND WHEN IT UNSTUCK, THE ADDED PRESSURE CAUSED THE VAN TO LURCH FORWARD. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO DETERMINED THERE WAS NOT ENOUGH LUBRICANT ON THE ACCELERATOR PARTS. THE PROBLEM PERSISTED AFTER VISITING THE SERVICE DEALER. UPDATED 12/5/2006 - THIS HAS BEEN A PROBLEM SINCE THE VEHICLE WAS PURCHASED NEW. *NM
VEHICLE DESCRIPTION: MINI VANS. ONE OR MORE OF THE FIVE BOLTS THAT MOUNT THE RACK AND PINION STEERING GEAR TO THE VEHICLE MAY HAVE BEEN INCORRECTLY TIGHTENED.
Consequence & remedy
Consequence: THERE COULD BE A LOOSENESS IN THE STEERING, WHICH MAY BE ACCOMPANIED BY NOISE OR VIBRATION.
Remedy: DEALERS WILL INSPECT THE VEHICLES AND, IF THE BOLTS ARE MISSING, WILL REPLACE THE STEERING GEAR MOUNTING BOLTS. ALL BOLTS WILL BE TIGHTENED TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04020 · Failing Headlights
Opened Feb 26, 2004 · Closed Jun 24, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights
NISSAN AND FORD FOUND THAT THE ORIGINAL EQUIPMENT HEADLIGHT STAINLESS STEEL BULB TERMINALS MAY OVER TIME CAUSE ELEVATED CONTACT RESISTANCE AND OVERHEAT THE ELECTRICAL CONNECTOR HOUSING.THIS CAN RESULT IN A HEADLIGHT FLICKERING, BULB OUTAGE AND HEAT DEFORMATION TO THE HEADLIGHT CONNECTOR.IN APRIL 1999, THE SUPPLIER OF THE HEADLIGHT FOR NISSAN AND FORD CHANGED TO A BULB USING THE STAINLESS STEEL TERMINALS THAT DID NOT MEET ORIGINAL SPECIFICATIONS.ON JULY 17, 2000, THE SUPPLIER BEGAN USING A BULB MEETING THE VEHICLE MANUFACTURER'S SPECIFICATIONS.THIS PROBLEM CAN AFFECT INDEPENDENTLY EITHER HEADLIGHT BUT DOES NOT CAUSE SIMULTANEOUS FAILURE OF BOTH HEADLIGHTS. THE PROBLEM ALSO DOES NOT AFFECT FRONT PARKING LAMPS.AS A RESULT, THE COMPLAINTS TYPICAL REPORT SINGLE FAILURE OF ONE HEADLIGHT.THERE ARE NO CRASHES OR LOSS OF VEHICLE CONTROL REPORTED.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2000 Mercury Villager Problems, Complaints & Recalls | Skip That Year
Illustration