IllustrationTHE STRUT TOWER IS RUSTING BAD AND IS ABOUT TO BREAK OFF. IT IS EVERY TIME MY WIFE AND KIDS GO SOME WHERE IT COULD BREAK THROW AND CAUSE MASSIVE DAMAGE AND PUT THEIR LIVES IN DANGER. JUST HOPE IT DOES NOT BREAK ON THE HIGHWAY. *JB
1998 Mercury Villager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1998 Mercury Villager do not stand out strongly from the model-year median of 125.
About this comparison →How this year compares
Owner complaints by model year
Compare all Villager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 83 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports0 fire reports3 injury reports
What owners actually said
83 reports1998 MERCURY VILLAGER'S FRONT LEFT WHEEL CAME OFF OF THE VEHICLE. *KB THE WHEEL BOUNCED OVER THE CENTER WALL AND THE VEHICLE DROVE OFF THE RIGHT SIDE OF THE ROAD TO A CONTROLLED STOP. THE FRONT LEFT FENDER WAS DENTED AND SCRAPED AS WELL AS THE LOWER PORTION OF THE DRIVER'S DOOR. THE LEFT FRONT WHEEL LUG NUTS SHEARED OFF, ONE …
Read full complaint
1998 MERCURY VILLAGER'S FRONT LEFT WHEEL CAME OFF OF THE VEHICLE. *KB THE WHEEL BOUNCED OVER THE CENTER WALL AND THE VEHICLE DROVE OFF THE RIGHT SIDE OF THE ROAD TO A CONTROLLED STOP. THE FRONT LEFT FENDER WAS DENTED AND SCRAPED AS WELL AS THE LOWER PORTION OF THE DRIVER'S DOOR. THE LEFT FRONT WHEEL LUG NUTS SHEARED OFF, ONE WAS STILL PARTIALLY INTACT. *NM
1998 MERCURY VILLAGER PARKED. WHEN FAMILY RETURNED TO VAN AND GOT INTO IT, THE FRONT LEFT (DRIVERS) SIDE COIL SPRING SNAPPED. ABLE TO SLOWLY DRIVE VEHICLE TO GARAGE TO REPLACE BOTH SPRINGS. *NM
DT: CONTACT PUT THE VEHICLE IN PARK AND EXITED THE VEHICLE AND IT ROLLED BACKWARDS. THE DOOR PULLED THE CONTACT UNDER THE VEHICLE, AND BOTH SETS OF TIRES RAN HER OVER. SHE SUSTAINED A BROKEN PELVIC BONE, A BROKEN HIP, A BROKEN FEMUR, A BROKEN KNEE, A BROKEN ANKLE, AND A BROKEN BACK FROM L1-5. AS A RESULT, SHE SPENT THE SU…
Read full complaint
DT: CONTACT PUT THE VEHICLE IN PARK AND EXITED THE VEHICLE AND IT ROLLED BACKWARDS. THE DOOR PULLED THE CONTACT UNDER THE VEHICLE, AND BOTH SETS OF TIRES RAN HER OVER. SHE SUSTAINED A BROKEN PELVIC BONE, A BROKEN HIP, A BROKEN FEMUR, A BROKEN KNEE, A BROKEN ANKLE, AND A BROKEN BACK FROM L1-5. AS A RESULT, SHE SPENT THE SUMMER IN A NURSING HOME. THE VEHICLE HAS NOT BEEN TO A MECHANIC FOR THIS PROBLEM.*AK
THE VEHICLE AUTOMATIC DOOR LOCKS AUTOMATICALLY LOCK THE DOORS THIS HAS HAPPENED INNUMERABLE OCCASIONS. THIS BEGAN SHORTLY AFTER PURCHASE OF THE VEHICLE IN 1998, AND CONTINUES TODAY. THE DOORS AR NOT TO LOCK IF THE KEYS ARE IN THE IGNITION, AND THEY DO. THIS HAS OCCURRED WHILE DRIVING THE VEHICLE, WHILE IT IS PARKED, WHEN ENTE…
Read full complaint
THE VEHICLE AUTOMATIC DOOR LOCKS AUTOMATICALLY LOCK THE DOORS THIS HAS HAPPENED INNUMERABLE OCCASIONS. THIS BEGAN SHORTLY AFTER PURCHASE OF THE VEHICLE IN 1998, AND CONTINUES TODAY. THE DOORS AR NOT TO LOCK IF THE KEYS ARE IN THE IGNITION, AND THEY DO. THIS HAS OCCURRED WHILE DRIVING THE VEHICLE, WHILE IT IS PARKED, WHEN ENTERING, AND EXITING THE VEHICLE. THE INTERIOR DOORS DO NOT OVERRIDE THE LOCKS, AND IN AN EMERGENCY, ONE WOULD BE UNABLE TO EXIT THE VEHICLE IF THEY WERE TO LOCK. USUALLY THIS OCCURS MOST OFTEN WHEN THE DOORS ARE BEING CLOSED; AND IF THE BATTERY IS UNHOOKED, AND RECONNECTED, IT MAY REMEDY THE SITUATION FOR SEVERAL DAYS. THE REAR AUTOMATIC WINDOWS GO OUT WHEN YOU PRESS THE BUTTONS TO MAKE THEM GO IN, AND THE REAR WIPER STAYS DOWN AS IF THE WINDOW IS UNLOCKED. THAT CAN BE REMEDIED BY UNLOCKING THE WINDOW, AND RELATCHING IT, IT USUALLY STAYS UP FOR 2-3 DAYS. WHEN YOU ATTEMPT TO RETRACT THE REAR WINDOWS, THEY WILL NOT GO IN AUTOMATICALLY. I HAVE CONTACTED PUTNAM LINCOLN MERCURY IN FORT SMITH, ARKANSAS, AND I DO NOT HAVE THE MONEY TO COMPLETE THESE REPAIRS WHICH COULD POSSIBLY CAUSE INJURY OR DEATH IF THE DOORS LOCKED SOMEONE IN. IN OTHER NEWS, THE GAS PEDAL IS STICKING ALSO, THIS HAPPENS WHEN YOU TAKE OFF IN THE VEHICLE, AND HAPPENS EVERY TIME. THIS HAS ALSO BEEN REPORTED TO THE DEALERSHIP. *NM
DT: 1998 MERCURY VILLAGER. THE CONSUMER STATES ALL OF THE DOORS ARE LOCKING ON THEIR OWN. THIS HAS HAPPENED A COUPLE OF TIMES. THE VEHICLE HAS NOT BEEN INSPECTED BY THE DEALERSHIP TO SEE WHY THIS WAS OCCURRING. HE HAS NOT YET CONTACTED MERCURY. THIS STARTED ON AUGUST 15, 2005. THIS ALMOST LOCKED THE CONSUMER'S CHILD IN T…
Read full complaint
DT: 1998 MERCURY VILLAGER. THE CONSUMER STATES ALL OF THE DOORS ARE LOCKING ON THEIR OWN. THIS HAS HAPPENED A COUPLE OF TIMES. THE VEHICLE HAS NOT BEEN INSPECTED BY THE DEALERSHIP TO SEE WHY THIS WAS OCCURRING. HE HAS NOT YET CONTACTED MERCURY. THIS STARTED ON AUGUST 15, 2005. THIS ALMOST LOCKED THE CONSUMER'S CHILD IN THE CAR. THIS WA SA KEYLESS ENTRY LOCKING SYSTEM.*AK
A DEFECT IN THE KEYLESS ENTRY SYSTEM OF 1998 MODEL YEAR MERCURY VILLAGER MINIVANS CAUSES UNCONTROLLED LOCKING AND UNLOCKING OF THE VEHICLE DOORS. COMPANY IS AWARE OF THE DEFECT AND A TECHNICAL MEMORANDUM EXISTS REGARDING THIS PROBLEM BUT THE COMPANY REFUSES TO TAKE RESPONSIBILITY FOR REPAIR OF THE DEFECT.*AK
I HAVE OWNED A 1996 AND 1998 MERCURY VILLAGER. BOTH VEHICLES HAD A FAILURE OF THE DRIVER'S SIDE CV BOOT WITH THE EVENTUAL FAILURE OF THE TRANS AXLE CV JOINT. EACH TIME THE TRANSAXLE HAD TO BE REPLACED.*AK
CONSUMER'S 4 YEAR OLD CHILD WAS ABLE TO SHIFT THE LEVER OUT OF THE PARK GEAR WHILE VEHICLE WAS PARKED ON AN INCLINE. VEHICLE ROLLED ACROSS SEVERAL STREETS BEFORE CRASHING INTO A NEIGHBOR'S TRUCK PARKED IN DRIVEWAY. DEALERSHIP INDICATED THAT THE STEERING PIN BROKE. *AK
CONSUMER TOOK VEHICLE TO DEALERSHIP BECAUSE OF A NOISE THAT WAS BEING HEARD WHEN APPLYING THE BRAKES. DEALER MAINTAINED THAT THE BRAKES WERE FINE, YET THE NOISE CONTINUED. IT COULD BE HEARD WHEN VEHICLE WAS GOING AT 35 MPH. *AK
Official recalls
200V419002 · Fuel System, Gasoline:storage:tank Assembly
Jan 2, 2001
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE VENT HOSE.
97V184001 · Electrical SYSTEM:12V/24V/48V Battery
Oct 29, 1997
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH AUTOMOTIVE BATTERIES SUPPLIED BY GNB TECHNOLOGIES. THESE BATTERIES HAVE A DEFECTIVE NEGATIVE POST THAT CAN CAUSE ACID LEAKAGE AND RELATED CORROSION DAMAGE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A CATASTROPHIC FAILURE OF THE BATTERY WHICH COULD LEAD TO AN ENGINE FIRE OR BATTERY EXPLOSION.
Remedy: DEALERS WILL REPLACE THESE BATTERIES. UNTIL A NEW BATTERY IS OBTAINED, OWNERS SHOULD NOT ATTEMPT TO "JUMP START" THESE BATTERIES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.