MY HUSBAND USES OUR MERCURY VILLAGER VAN FOR HIS WORK. HE WAS GOING TO A JOB AND WAS TRAVELING WHEN HE STATED THE VAN LOST POWER, THE ENGINE ACTUALLY TURNED ITSELF OFF. HE WAS ABLE TO GET OFF THE ROAD BEFORE HE WAS INVOLVED IN AN ACCIDENT. HE PROCEEDED TO TRY RESTARTING THE VAN. IT DID NOT WORK, SO WE HAD THE VAN TOWED TO OUR HO…
Read full complaint
MY HUSBAND USES OUR MERCURY VILLAGER VAN FOR HIS WORK. HE WAS GOING TO A JOB AND WAS TRAVELING WHEN HE STATED THE VAN LOST POWER, THE ENGINE ACTUALLY TURNED ITSELF OFF. HE WAS ABLE TO GET OFF THE ROAD BEFORE HE WAS INVOLVED IN AN ACCIDENT. HE PROCEEDED TO TRY RESTARTING THE VAN. IT DID NOT WORK, SO WE HAD THE VAN TOWED TO OUR HOME. HE CHECK TO SEE IF THE MOTOR WAS TIED UP BUT IT WAS FINE.HE CHANGED BATTERIES, BECAUSE DURING THE EVENT, THE BATTERY WAS DRAINED. AFTER ABOUT 3 HOURS, THE VAN MIRACULOUSLY STARTED. WE HAVE SPOKEN TO A COUPLE THAT HAD THIS HAPPEN TO THEM. THEY STATED THAT IF THE OIL GETS CLOSE TO 1 QUART BELOW LEVEL, THE SENSORS AUTOMATICALLY SHUT OFF THE ENGINE. THIS IS DANGEROUS. MY HUSBAND COULD OF BEEN IN A SERIOUS ACCIDENT WHEN THE ENGINE TURNED ITSELF OFF. THERE WERE NO ENGINE LIGHTS SIGNIFYING LOW OIL. PLEASE CHECK AND ADVISE. THANK YOU. *TR
NHTSA ODI #10342853
Mileage unknown · Jul 25, 1998
Engine And Engine CoolingService Brakes, HydraulicSteering
VEHICLE DESCRIPTION: MINIVANS. THE FUEL TANK VENT HOSE ALLOWS AIR TO VENT FROM THE FUEL TANK DURING REFUELING. CRACKS HAVE DEVELOPED IN THE VENT HOSE. IF (1) THE FUEL TANK IS OVERFILLED, NOT ALLOWING EXCESS FUEL IN THE VENT HOSE TO FLOW BACK INTO THE TANK, (2) THE VEHICLE IS DRIVEN ONLY A SHORT DISTANCE AFTER REFUELING AND, (3) THERE IS SUBSEQUENTLY SIGNIFICANT HEATING OF THE FUEL TANK, THE FUEL IN THE TANK CAN EXPAND INTO THE VENT HOSE AND LEAK FUEL.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH AUTOMOTIVE BATTERIES SUPPLIED BY GNB TECHNOLOGIES. THESE BATTERIES HAVE A DEFECTIVE NEGATIVE POST THAT CAN CAUSE ACID LEAKAGE AND RELATED CORROSION DAMAGE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A CATASTROPHIC FAILURE OF THE BATTERY WHICH COULD LEAD TO AN ENGINE FIRE OR BATTERY EXPLOSION.
Remedy: DEALERS WILL REPLACE THESE BATTERIES. UNTIL A NEW BATTERY IS OBTAINED, OWNERS SHOULD NOT ATTEMPT TO "JUMP START" THESE BATTERIES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA00014 · Fuel Tank Vent Hose Leakage
Opened May 22, 2000 · Closed Jan 4, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANTS CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUOROCARBON RUBBER HOSES WITH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WERE MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT TO DEGRADATION AND CRACKING.IN A LETTER DATED JANUARY 2, 2001, FORD NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFACTED VEHICLES.FORD WILL BEGIN NOTIFYING CUSTOMERS OF THE AFFECTED VEHICLES ON OR ABOUT THE WEEK OF FEBRUARY 12, 2001 TO RETURN THEIR VEHICLES TO DEALERS FOR REPLACEMENT OF THE FUEL TANK VENT HOSE WITH THE LATEST DESIGN LEVER PART.
1998 Mercury Villager Problems, Complaints & Recalls | Skip That Year
Illustration