NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
61 reportsClear category filter60,000 miles · Feb 10, 2015
Vehicle Speed Control
I WAS DRIVING ALONG THE HIGHWAY AT APPROXIMATELY 45 MPH WHEN SUDDENLY ACCELERATOR SPED UP TO A HIGH RATE OF SPEED. COULD NOT SLOW DOWN WHEN BRAKING. CAR CONTINUED TO ACCELERATE. COULD NOT GET CAR TO SLOW DOWN NO MATTER WHAT I TRIED. HAD TO TURN CAR OFF TO COME TO A STOP. THE LOCAL WICHITA FALLS FORD COMPANY SAYS THERE IS REC…
Read full complaint
I WAS DRIVING ALONG THE HIGHWAY AT APPROXIMATELY 45 MPH WHEN SUDDENLY ACCELERATOR SPED UP TO A HIGH RATE OF SPEED. COULD NOT SLOW DOWN WHEN BRAKING. CAR CONTINUED TO ACCELERATE. COULD NOT GET CAR TO SLOW DOWN NO MATTER WHAT I TRIED. HAD TO TURN CAR OFF TO COME TO A STOP. THE LOCAL WICHITA FALLS FORD COMPANY SAYS THERE IS RECALL FOR THIS PROBLEM, BUT I HAVE READ ALL OVER THE NET THAT IT IS A PROBLEM FORD MOTOR COMPANY SAID THAT IT WOULD FIX. CALLED FORD MOTOR CO. HEADQUARTERS AND THEY SAID THERE IS NO RECALL ISSUED FOR THIS PROBLEM AND THEY WILL NOT FIX IT. I SHOULD NOT HAVE TO PAY FOR THIS WHEN FORD KNOWS IT IS AN ONGOING PROBLEM. I AM 73 YEARS OLD AND DO NOT HAVE MONEY FOR THIS KIND OF REPAIR. *TR
NHTSA ODI #10682557
161,000 miles · Oct 16, 2014
Vehicle Speed Control
GOING TO WORK AND GOING UP A STEEP HILL ON A WINDY 2 LANE HIGHWAY AND TOPPED THE HILL AT APPROXIMATELY 40 MPH AND WHEN I LET OFF THE THROTTLE THE THROTTLE PEDAL RETURNED BUT THE SPEED STAYED AT 40 MPH AND AT 4000 RPM. I PUNCHED AND RELEASED THE THROTTLE PEDAL AND IT WENT TO 6000 RPM AND DIDN'T RETURN. I STEPPED ON THE BRAKES AND…
Read full complaint
GOING TO WORK AND GOING UP A STEEP HILL ON A WINDY 2 LANE HIGHWAY AND TOPPED THE HILL AT APPROXIMATELY 40 MPH AND WHEN I LET OFF THE THROTTLE THE THROTTLE PEDAL RETURNED BUT THE SPEED STAYED AT 40 MPH AND AT 4000 RPM. I PUNCHED AND RELEASED THE THROTTLE PEDAL AND IT WENT TO 6000 RPM AND DIDN'T RETURN. I STEPPED ON THE BRAKES AND SLOWED THE VEHICLE A LITTLE BUT NOT MUCH. I WAS COMING UP ON A TURN AT A HIGH RATE OF SPEED AND HAD TO SHIFT IN TO NEUTRAL AND SHUT THE CAR OFF. I COASTED TO THE SIDE OF THE ROAD AND RAISED THE HOOD. I SEEN THAT WHERE THE THROTTLE CABLE AND THE CRUISE CONTROL CABLE WENT IN TO THE MOUNTING BRACKET THAT THE CRUISE CONTROL CABLE WAS HANGING OUT THE SIDE OF THE GREY PLASTIC HOLDER THAT HOLDS IT INTO THE MOUNTING BRACKET. THE GREY PLASTIC GUIDE HOLDER HAD BROKE AND THE CABLE HAD SLIPPED OUT OF THE HOLDER AND WASN'T ABLE TO GO BACK IN WHEN THE THROTTLE WAS OPEN THUS LEFT THE THROTTLE HALF OPEN. I WAS ABLE TO MANUALLY SLIDE IT BACK INTO THE GREY PLASTIC GUIDE HOLDER AND PUT WIRE ON IT TO SAFELY GET IT HOME. THE HOLDER NEEDS TO EITHER BE METAL OR A BETTER GRADE OF PLASTIC. THE GREY PLASTIC GUIDE HOLDER IS ALSO THE SAME AS THE ONE ON THE THROTTLE CABLE. I'M SURE ITS GOING TO BREAK SOON ALSO. THANK YOU. *TR
NHTSA ODI #10645081
96,000 miles · Jul 9, 2013
Vehicle Speed Control
TL* THE CONTACT OWNS A 2001 MERCURY SABLE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT WAS FORCED TO DEPRESS THE BRAKE PEDAL WITH BOTH FEET AND PLACE THE VEHICLE IN NEUTRAL GEAR IN ORDER TO STOP THE VEHICLE. THE VEHICLE ACCELERATED TO APPROXIMATELY 70 MPH FOR A 16 MILE ST…
Read full complaint
TL* THE CONTACT OWNS A 2001 MERCURY SABLE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT WAS FORCED TO DEPRESS THE BRAKE PEDAL WITH BOTH FEET AND PLACE THE VEHICLE IN NEUTRAL GEAR IN ORDER TO STOP THE VEHICLE. THE VEHICLE ACCELERATED TO APPROXIMATELY 70 MPH FOR A 16 MILE STRETCH. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE TOW TRUCK DRIVER INSPECTED THE VEHICLE AND NOTICED THE CRUISE CONTROL CABLE HAD DISENGAGED CAUSING THE ACCELERATION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000. *TR
NHTSA ODI #10523876
135,000 miles · Mar 15, 2013
Vehicle Speed Control
ACCELERATOR CABLE BROKE OFF FROM GAS PEDAL. *TR
NHTSA ODI #10503207
Mileage unknown · Mar 15, 2013
Vehicle Speed Control
ACCELERATOR CABLE BROKE IN HALF AS I ENTERED I-295 FROM ON RAMP. *TR
NHTSA ODI #10503206
60,000 miles · Mar 13, 2013
Vehicle Speed Control
WITHIN THE LAST WEEK MY 2001 MERCURY SABLE REACHED THE 60,000 MILE MARK. ONCE OVER THAT MARK THE ACCELERATOR PEDAL BEGAN TO STICK EACH TIME I WOULD ACCELERATE THE VEHICLE TOO MUCH. FOR EXAMPLE, MERGING ONTO THE HIGHWAY AND NEEDING TO SPEED UP THE CAR WOULD REV THE ENGINE AS WITHOUT MY FOOT ON THE PEDAL. THIS WOULD CONTINUE AS…
Read full complaint
WITHIN THE LAST WEEK MY 2001 MERCURY SABLE REACHED THE 60,000 MILE MARK. ONCE OVER THAT MARK THE ACCELERATOR PEDAL BEGAN TO STICK EACH TIME I WOULD ACCELERATE THE VEHICLE TOO MUCH. FOR EXAMPLE, MERGING ONTO THE HIGHWAY AND NEEDING TO SPEED UP THE CAR WOULD REV THE ENGINE AS WITHOUT MY FOOT ON THE PEDAL. THIS WOULD CONTINUE AS IF I WAS PRESSING THE ACCELERATOR PEDAL TO THE FLOOR EVEN IF MY FOOT WAS FIRMLY ON THE BRAKE. THE ONLY RESOLUTION TO THIS SUDDEN EXTREME ACCELERATION WOULD BE TO STOMP ON THE ACCELERATOR OVER AND OVER AGAIN. IN ONE INSTANCE THE VEHICLE WOULD NOT STOP EVEN AFTER IT WAS PUT INTO PARK, IT WASN'T UNTIL THE VEHICLE WAS TURNED OFF WHEN IT STOPPED. THIS HAPPENED THREE TIMES BEFORE I BROUGHT THE VEHICLE INTO BE REPAIRED. *TR
NHTSA ODI #10502629
125,000 miles · Jan 2, 2013
Vehicle Speed Control
TL* THE CONTACT OWNS A 2001 MERCURY SABLE. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH AND EXHIBITED AN UNEXPECTED INCREASE IN ACCELERATION. THE BRAKE PEDAL WAS DEPRESSED SEVERAL TIMES BEFORE THE VEHICLE WOULD STOP. THE CRUISE CONTROL WAS NOT ENGAGED WHEN THE FAILURE OCCURRED. THE CONTACT STATED THAT THE VEHICLE WOULD BE TOWED …
Read full complaint
TL* THE CONTACT OWNS A 2001 MERCURY SABLE. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH AND EXHIBITED AN UNEXPECTED INCREASE IN ACCELERATION. THE BRAKE PEDAL WAS DEPRESSED SEVERAL TIMES BEFORE THE VEHICLE WOULD STOP. THE CRUISE CONTROL WAS NOT ENGAGED WHEN THE FAILURE OCCURRED. THE CONTACT STATED THAT THE VEHICLE WOULD BE TOWED TO AN INDEPENDENT AUTO SHOP FOR INSPECTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
NHTSA ODI #10490680
120,000 miles · Oct 30, 2012
Fuel/propulsion SystemVehicle Speed Control
AFTER GETTING UP TO CRUISING SPEED ON THE HIGHWAY MY CAR WOULD CONTINUE TO ACCELERATE EVEN WHEN I STOPPED GIVING IT GAS. I DISCONNECTED THE CRUISE CONTROL CABLE AND THIS FIXED THE PROBLEM, BUT NOW I CAN'T USE MY CRUISE CONTROL. *TR
NHTSA ODI #10482608
126,000 miles · Oct 26, 2012
Vehicle Speed Control
WITHOUT APPLYING PRESSURE TO ACCELERATOR, THE CAR ACCELERATED UNCONTROLLABLY. NEEDED TO APPLY BRAKES COMPLETELY AND PUT TRANS IN NEUTRAL TO STOP CAR. *TR
NHTSA ODI #10482406
90,000 miles · Oct 26, 2012
EngineService BrakesVehicle Speed ControlCrashFire
MY 2001 MERCURY SABLE ACCELERATED AS I ENTERED THE HIGHWAY. THE CAR WOULD NOT STOP EVEN WHEN I APPLIED THE BRAKE. I CALLED 911. THE 911 OPERATOR SUGGESTED THAT I APPLY THE PARKING BRAKE WHICH I DID. I WENT ABOUT 15 MILES RIDING THE SHOULDER GOING BETWEEN 60-70 MILES PER HOUR. I EVENTUALLY EXITED THE HIGHWAY BUT COULD NOT STOP EV…
Read full complaint
MY 2001 MERCURY SABLE ACCELERATED AS I ENTERED THE HIGHWAY. THE CAR WOULD NOT STOP EVEN WHEN I APPLIED THE BRAKE. I CALLED 911. THE 911 OPERATOR SUGGESTED THAT I APPLY THE PARKING BRAKE WHICH I DID. I WENT ABOUT 15 MILES RIDING THE SHOULDER GOING BETWEEN 60-70 MILES PER HOUR. I EVENTUALLY EXITED THE HIGHWAY BUT COULD NOT STOP EVEN AT THE END OF THE EXIT RAMP. I MADE A RIGHT HAND TURN. AT THIS POINT I HAD REDUCED MY SPEED TO APPROXIMATELY 30 MILES PER HOUR. THE CAR EVENTUALLY LANDED IN A DITCH. AT THAT POINT, I ENDED MY CALL WITH 911. I LOOKED TO MY LEFT AND FOUND FOUR MEN YELLING TO ME TO GET OUT OF THE CAR. I THEN LEARNED THAT THE CAR WAS ON FIRE. I EXITED THE CAR. THE FOUR MEN PUT THE FIRE OUT WITH A FIRE EXTINGUISHER. THE CAR WAS TOWED TO A MERCURY DEALERSHIP WHERE IT IS DOCUMENTED THAT IT WAS IN FACT THE SPEED CONTROL CABLE THAT CAUSED THE CAR TO ACCELERATE. AGAIN, BETWEEN THE 911 CALL, THE INFORMATION ON FILE WITH THE MERCURY DEALER AND THE INSURANCE CLAIM, THE CAUSE OF THE INCIDENT IS DOCUMENTED. *TR
NHTSA ODI #10482375
Official recalls
8Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Mar 2, 2004
CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.
Consequence & remedy
Consequence: IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.
Remedy: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 2, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. SIMULTANEOUS APPLICATION OF BOTH THE BRAKE AND ACCELERATOR PEDALS COULD RESULT IN AN INCREASE IN ENGINE RPM.
Consequence & remedy
Consequence: THIS COULD RESULT IN A CUSTOMER EXPERIENCING AN "UNINTENDED VEHICLE SPEED INCREASE" OR A PERCEIVED "UNABLE TO STOP" CONDITION.
Remedy: OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BETWEEN THEM TO GREATER THAN 50 MM. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Apr 27, 2001
VEHICLE DESCRIPTION: PASSENGER CARS. THE SEAT BELT BUCKLE TONGUE MAY NOT FULLY EJECT FROM THE BUCKLE ASSEMBLY WHEN THE RELEASE BUTTON IS PUSHED SLOWLY. THIS CONDITION COULD ALSO RESULT IN A PARTIAL LATCH OF THE TONGUE IN THE BUCKLE.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE VEHICLE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy: DEALERS WILL REPLACE THE DRIVER AND RIGHT FRONT PASSENGER SEAT BELT BUCKLES. OWNER NOTIFICATION BEGAN MAY 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Mar 12, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS. IF THE GREASE FROM THE ADJUSTABLE PEDAL ASSEMBLY ENTERS THE STOP LAMP SWITCH, IT CAN CONTAMINATE THE CONTACTS LEADING TO CARBON BUILD UP, AND POTENTIALLY, A SHORT CIRCUIT.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD LEAD TO EITHER THE BRAKE LAMPS STAYING ON, OR TO A LOSS OF BRAKE LAMP FUNCTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH AND WIPE DOWN THE ADJUSTABLE PEDAL ASSEMBLY TO REMOVE EXCESS GREASE. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Aug 24, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE CHILD SAFETY SEAT ANCHOR LATCH (ISO-FIX ANCHOR) FASTENERS DO NOT HAVE ADEQUATE RESIDUAL TORQUE. THE ANCHORS ARE SECURED TO THE FLOOR PAN WITH A REINFORCEMENT PLATE THAT HAS TWO STUDS THAT EXTEND UPWARD THROUGH THE FLOOR PAN AND THE ISO-FIX ANCHOR. THE SEALER ON THE FLOOR PAN COULD CAUSE A SOFT JOINT AND, EVEN IF THE NUTS ARE PROPERLY TORQUED, ROAD VIBRATIONS COULD CAUSE THE NUT TO WORK ITS WAY COMPLETELY OFF THE STUD.
Consequence & remedy
Consequence: THE ANCHOR MAY NOT HOLD THE CHILD SAFETY SEAT IN POSITION DURING AN ACCIDENT, INCREASING THE RISK OF INJURY TO THE OCCUPANT OF THE CHILD SAFETY SEAT.
Remedy: DEALERS WILL REMOVE AND RE-INSTALL THE BRACKET NUT USING A TORQUE RETENTION MATERIAL (RED LOCTITE). OWNER NOTIFICATION BEGAN SEPTEMBER 11, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8PE12033 · Speed Control Cable Damage
Opened Oct 24, 2012 · Closed Jun 26, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Additional source detail variants (3)
Vehicle Speed Control:cables
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
EA06002 · Rear Coil Spring Fracture
Opened Jan 24, 2006 · Closed Feb 5, 2007
Status: closed (inferred from source dates) · Suspension:rear; Suspension:rear:springs; Suspension:rear:springs:coil Springs
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Suspension:rear
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Suspension:rear:springs:coil Springs
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Suspension:rear:springs
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05054 · Rear Coil Spring Fracture
Opened Sep 27, 2005 · Closed Jan 24, 2006
Status: closed (inferred from source dates) · Suspension:rear:springs; Suspension:rear:springs:coil Springs
THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINANTS ALLEGE THAT THE ADJACENT TIRE WAS PUNCTURED AS RESULT OF A REAR COIL SPRING FRACTURE. ADDITIONALLY, AN ANALYSIS OF THE COMPLAINT DATA RECEIVED BY ODI FROM FORD REVEALS THE FOLLOWING: THERE WERE A TOTAL OF 553 UNIQUE VEHICLE COMPLAINTS OF COIL SPRING FRACTURE. 30% OF THE COMPLAINTS ALLEGE THAT THE REAR COIL SPRING FRACTURE RESULTED IN THE ADJACENT TIRE BEING PUNCTURED. AN ENGINEERING ANALYSIS (EA06-002) IS BEING OPENED TO FURTHER EXAMINE THE POTENTIAL SAFETY IMPLICATIONS OF THE REAR COIL SPRING FRACTURES AS RELATED TO TIRE PUNCTURES.
Additional source detail variants (2)
Suspension:rear:springs:coil Springs
THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINANTS ALLEGE THAT THE ADJACENT TIRE WAS PUNCTURED AS RESULT OF A REAR COIL SPRING FRACTURE. ADDITIONALLY, AN ANALYSIS OF THE COMPLAINT DATA RECEIVED BY ODI FROM FORD REVEALS THE FOLLOWING: THERE WERE A TOTAL OF 553 UNIQUE VEHICLE COMPLAINTS OF COIL SPRING FRACTURE. 30% OF THE COMPLAINTS ALLEGE THAT THE REAR COIL SPRING FRACTURE RESULTED IN THE ADJACENT TIRE BEING PUNCTURED. AN ENGINEERING ANALYSIS (EA06-002) IS BEING OPENED TO FURTHER EXAMINE THE POTENTIAL SAFETY IMPLICATIONS OF THE REAR COIL SPRING FRACTURES AS RELATED TO TIRE PUNCTURES.
Suspension:rear:springs
THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINANTS ALLEGE THAT THE ADJACENT TIRE WAS PUNCTURED AS RESULT OF A REAR COIL SPRING FRACTURE. ADDITIONALLY, AN ANALYSIS OF THE COMPLAINT DATA RECEIVED BY ODI FROM FORD REVEALS THE FOLLOWING: THERE WERE A TOTAL OF 553 UNIQUE VEHICLE COMPLAINTS OF COIL SPRING FRACTURE. 30% OF THE COMPLAINTS ALLEGE THAT THE REAR COIL SPRING FRACTURE RESULTED IN THE ADJACENT TIRE BEING PUNCTURED. AN ENGINEERING ANALYSIS (EA06-002) IS BEING OPENED TO FURTHER EXAMINE THE POTENTIAL SAFETY IMPLICATIONS OF THE REAR COIL SPRING FRACTURES AS RELATED TO TIRE PUNCTURES.
RP03001 · Brake/accelerator Pedal Application
Opened Oct 31, 2003 · Closed Mar 23, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:pedals And Linkages
MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE.PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL (02V-266) OF 369,000 MY 2000-2002 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE BRAKE AND ACCELERATOR PEDALS TO INSURE THAT THE SEPARATION BETWEEN THE PEDALS WAS AT LEAST 50MM..A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING RECALL 02V-266 DID NOT IDENTIFY ANY RECALL REMEDY COMPLAINTS OTHER THAN THE PETITIONER'S.MS. RODMAN?S VEHICLE WAS INSPECTED BY ODI USING FORD?S SPECIAL TOOL AND HER VEHICLE WAS FOUND TO EXCEED 50MM.ALSO, THE LATERAL MOVEMENT OF THE PEDALS WAS FOUND NOT TO BE EXCESSIVE RELATIVE TO OTHER COMPARABLE TAURUS AND SABLE VEHICLES.THEREFORE, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER REQUIRING FORD TO PROVIDE A DIFFERENT REMEDY FOR THIS DEFECT.IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE FEDERAL REGISTER NOTICE DATED MARCH 23, 2004 (VOL 69, NO 56, PAGES 13619-13620).
RQ03008 · Brake Light Switch Failure
Opened Oct 23, 2003 · Closed Mar 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Additional source detail variants (5)
Exterior Lighting:brake Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:brake Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
EA03010 · Frontal Air Bag NON-DEPLOYMENT In Crash
Opened Jul 2, 2003 · Closed Jun 23, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
THIS INVESTIGATION IDENTIFIED A TOTAL OF 427 REPORTS ALLEGING NON-DEPLOYMENT OF THE FRONTAL AIR BAGS.OF THE 427 REPORTS, TWO INCIDENTS (FATAL CRASHES) HAVE BEEN IDENTIFIED AS SEVERE FRONTAL CRASHES IN WHICH THE FRONTAL AIR BAGS DID NOT DEPLOY.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE03002 · Frontal Air Bag NON-DEPLOYMENT In Crash
Opened Jan 6, 2003 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
FORD MOTOR COMPANY HAS IDENTIFIED 260 REPORTS ALLEGING FRONTAL AIR BAG NON-DEPLOYMENT FOR ANY (SEVERITY) FRONTAL OR NEAR-FRONTAL CRASH ON MODEL YEAR 2000-2001 FORD TAURUS AND MERCURY SABLE VEHICLES.ADDITIONAL CRASH REPORTS ARE CONTAINED IN NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE SINGLE ODI REPORT LISTED IN THE REPORT SUMMARY IS NHTSA'S SPECIAL CRASH INVESTIGATION'S CASE NO. CA00-020 THAT INVOLVED A HIGH-SPEED CRASH NON-DEPLOYMENT INVOLVING A DRIVER FATALITY AND FRONT PASSENGER INJURY.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-010) AND ODI WILL COLLECT ADDITIONAL INFORMATION ON CERTAIN CRASH REPORTS AND CONDUCT FURTHER STUDY OF THIS ISSUE.
PE02035 · Brake/accel Pedal Separation
Opened Mar 15, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration