NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
95 reportsClear category filter131,368 miles · Mar 19, 2007
Power Train
TL* - THE CONTACT HAS A 1994 MERCURY SABLE. THE CONTACT STATED THAT HE PURCHASED A VEHICLE ON THE AFTERNOON OF 03/16/2007, AND THE FOLLOWING MORNING 03/17/2007 THE VEHICLE WOULD NOT WORK, AND TRANSMISSION FLUID WAS POURING OUT OF THE VEHICLE. THE CONTACT STATED THAT HE COULD POUR IT IN THE TOP AND WATCH IT COME OUT OF THE BOTT…
Read full complaint
TL* - THE CONTACT HAS A 1994 MERCURY SABLE. THE CONTACT STATED THAT HE PURCHASED A VEHICLE ON THE AFTERNOON OF 03/16/2007, AND THE FOLLOWING MORNING 03/17/2007 THE VEHICLE WOULD NOT WORK, AND TRANSMISSION FLUID WAS POURING OUT OF THE VEHICLE. THE CONTACT STATED THAT HE COULD POUR IT IN THE TOP AND WATCH IT COME OUT OF THE BOTTOM. THE CONTACT WAS TOLD BY THE DEALER THAT THEY WOULD COME AND GET THE VEHICLE REPAIR IT AND CHARGE HIM FOR IT. THE CURRENT AND FAILURE MILEAGE WERE BOTH 131,368 MILES.
NHTSA ODI #10185526
195,000 miles · May 3, 2005
Power TrainSuspension
CONTACT STATED: WHEN SHIFTING FROM REVERSE TO DRIVE ENGINE MAKES A LOUD NOISE. ALSO, THE FRONT SUSPENSION SPRINGS BROKE WHILE DRIVING.*AK
NHTSA ODI #10119465
62,472 miles · Jan 23, 2004
Power Train
PURCHASED 1994 MERCURY SABLE 60,000 ORIGINAL MILES, THE VEHICLE WOULD BE OK COLD WITHIN 5 MILES OF DRIVING THE CAR WOULD SLIP OUT OF GEAR AT STOPS OR IF YOU COASTED, CAN'T PUT IN REVERSE AT AFTER WARM. CONSULTED THE INTERNET AND FOUND HORROR STORIES OF OTHER OWNERS. THE DEALERSHIP SAYS THEY NO NOTHING OF THESE PROBLEMS. *LA
NHTSA ODI #10054740
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolinePower Train
THE KEY INSERT DOES NOT ALIGN, HAVE HAD 2 TRANSMISSIONS IN 5 YEARS. (I KNOW TO CHECK MY FLUIDS) NEW ENGINE, & THE PAINT IS AWFUL. ENGINE, MOTOR, GAS, GASPS AND JERKS WITH ME. HAVE HAD MOTOR MOUNTS REPLACED, NOTHING HELPS. HEATER COIL(?) WENT OUT, I HAVE NO HEAT NOW. WE HAD TO BYPASS. THE REST I HAVE NOT BEEN ABLE TO AFFORD TO RE…
Read full complaint
THE KEY INSERT DOES NOT ALIGN, HAVE HAD 2 TRANSMISSIONS IN 5 YEARS. (I KNOW TO CHECK MY FLUIDS) NEW ENGINE, & THE PAINT IS AWFUL. ENGINE, MOTOR, GAS, GASPS AND JERKS WITH ME. HAVE HAD MOTOR MOUNTS REPLACED, NOTHING HELPS. HEATER COIL(?) WENT OUT, I HAVE NO HEAT NOW. WE HAD TO BYPASS. THE REST I HAVE NOT BEEN ABLE TO AFFORD TO REPAIR. I HATE THIS CAR. I AM WORRIED EVERYTIME I GET IN IT THAT MY MOTHER AND I ARE NOT GOING TO GET HOME. I HAVE HAD THE CAR TOWED SO MANY TIMES, THE MAN WHO DOES THE TOWING KNOWS ME AND MY CAR ON SIGHT. I WILL NOT GO MORE THAN 30 MILES FROMT HE HOUSE. MY MECHANIC EVEN HATES THE CAR. I CALL HIM AN ANGEL, BECAUSE HE HAS KEPT IT RUNNING.
NHTSA ODI #10070159
85,000 miles · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolinePower Train
HATCH GLASS CAME LOOSE STARTED LEAKING(56000) FUEL PUMP STARTED ACTING UP GET HOT AND HANG UP(75000) NO RECALL. STATE FARM SHOWED THEY PAID FOR TOWING ON MANY, FORD PRODUCTS THAT USED THE SAME PUMP STILL NO RECALL. TRANSMISSION SHIFTS DOWN, OR SHIFTS OUT OF GEAR WHILE DRIVING SMITH FORD CONWAY WAS SUPPOSED TO CHECK THE HEADS FOR…
Read full complaint
HATCH GLASS CAME LOOSE STARTED LEAKING(56000) FUEL PUMP STARTED ACTING UP GET HOT AND HANG UP(75000) NO RECALL. STATE FARM SHOWED THEY PAID FOR TOWING ON MANY, FORD PRODUCTS THAT USED THE SAME PUMP STILL NO RECALL. TRANSMISSION SHIFTS DOWN, OR SHIFTS OUT OF GEAR WHILE DRIVING SMITH FORD CONWAY WAS SUPPOSED TO CHECK THE HEADS FOR LEAKS SIX MONTHS LATER THE HEAD GASKET BLEW,AND THE AIR WENT OUT AT THIS TIME I WAS TOLD THE THE DATE THIS CAR WAS ORIGINALLY PUT IN SEVICE MADE IT OUT OF WARRANTY. THIS CAR IS SITTING IN MY GARAGE WITH MOTOR OUT OF IT BECAUSE FORD DIDN'T DO ITS JOB. PAINT PEELED OFF THE INSIDE OF THE DOOR POST.
NHTSA ODI #10070028
133,295 miles · Jan 15, 2004
Power TrainUnknown Or OtherVisibility
I HAVE HAD CONSTANT OVERHEATING PROBLEMS WITH THS CAR. THE PROBLEMS RANGE FROM CRACKED FLUSH/FILL VALVES, TO HOSES,TO WATER PUMP FAILURE. 03/30/2002 TRANSMISSION STARTED SLIPPING. A MECHANIC AT A LOCAL SHOP RECOMMENDED ADDING FLUID. THE PROBLEM CONTINUED AND EACH TIME THE MECHANIC RECOMMENDED ADDING FLUID. NO LEAK WAS DETERM…
Read full complaint
I HAVE HAD CONSTANT OVERHEATING PROBLEMS WITH THS CAR. THE PROBLEMS RANGE FROM CRACKED FLUSH/FILL VALVES, TO HOSES,TO WATER PUMP FAILURE. 03/30/2002 TRANSMISSION STARTED SLIPPING. A MECHANIC AT A LOCAL SHOP RECOMMENDED ADDING FLUID. THE PROBLEM CONTINUED AND EACH TIME THE MECHANIC RECOMMENDED ADDING FLUID. NO LEAK WAS DETERMINED. PROBLEM CONTINUED UNTIL THE TRANSMISSION WENT OUT IN 07/2003.
NHTSA ODI #10069437
Mileage unknown · Aug 26, 2003
Power Train
CONSUMER STATED THAT WHEN STOPPING AT A STOP SIGN, THEN BEGINNING TO TAKE OFF, TRANSMISSION WOULD HESITATE. LATER, IT WOULD KICK IN. IT WAS AS IF THE TRANSMISSION WAS SLIPPING. CONSUMER THEN TOOK VEHICLE TO THE MECHANIC, AND WAS TOLD THAT HE NEEDED A NEW TRANSMISSION. HE HAD IT REPAIRED BY HAVING THE ALUMINUM PISTOLS REPLA…
Read full complaint
CONSUMER STATED THAT WHEN STOPPING AT A STOP SIGN, THEN BEGINNING TO TAKE OFF, TRANSMISSION WOULD HESITATE. LATER, IT WOULD KICK IN. IT WAS AS IF THE TRANSMISSION WAS SLIPPING. CONSUMER THEN TOOK VEHICLE TO THE MECHANIC, AND WAS TOLD THAT HE NEEDED A NEW TRANSMISSION. HE HAD IT REPAIRED BY HAVING THE ALUMINUM PISTOLS REPLACED WITH STEEL PISTOLS. CONSUMER HAD TO PAY $2200.00 TO HAVE TREPAIRS DONE, AND NEEDED HELP. *AK
NHTSA ODI #10037684
79,000 miles · Jul 28, 2003
Power Train
1994 MERCURY SABLE TRANSMISSION AND ENGINE MOUNTS FAILED AT 79000 MILES. ALUMINUM CLUTCH PISTON REPLACED WITH STEEL ONE AT MY COST OF 1800.00. FORD REPLACED THESE FOR FREE IN CANADA ON A PREVIOUS TRANSMISSION MADE IN THE SAME YEAR WHY NOT MINE? WHY CAN'T I FEEL GOOD ABOUT BUYING AMERICAN MADE CARS? FORD!*AK
NHTSA ODI #10029332
Mileage unknown · Jun 17, 2002
Power Train
WHILE DRIVING VEHICLE WILL STALL OUT WITHOUT ANY WARNING. CONTACTED DEALER. PROBLEM CAUSED BY A SHUT TRANSMISSION.*AK
NHTSA ODI #8011940
Mileage unknown · Apr 11, 2002
Engine And Engine CoolingPower Train
DROVE VEHICLE AT 65 MPH FOR ABOUT 70 MILES. AT STOP LIGHT ENGINE BEGAN RUNNING ROUGH AND SMOKE STARTED COMING FROM UNDER VEHICLE. PULLED TO SIDE OF ROAD AND A MODERATE AMOUNT OF ENGINE OIL WAS COMING FROM THE OIL PAN SEAL. HAD CARD TOWED BACK TO FORD DEALERSHIP WHERE PURCHASED. DEALER CLAIMS TRANSMISSION HAD NO FLUID IN IT. VECH…
Read full complaint
DROVE VEHICLE AT 65 MPH FOR ABOUT 70 MILES. AT STOP LIGHT ENGINE BEGAN RUNNING ROUGH AND SMOKE STARTED COMING FROM UNDER VEHICLE. PULLED TO SIDE OF ROAD AND A MODERATE AMOUNT OF ENGINE OIL WAS COMING FROM THE OIL PAN SEAL. HAD CARD TOWED BACK TO FORD DEALERSHIP WHERE PURCHASED. DEALER CLAIMS TRANSMISSION HAD NO FLUID IN IT. VECHICLE WAS JUST SERVICED TWO DAYS BEFORE THIS TRIP AND WORKED FINE. WHEN PULLED OFF CHECKED OIL AND TRANSMISSION. OIL WAS DOWN SOME, BUT NOT ALL. TRANMISSION HAD FLUID INDICATING ABOVE THE OK TO DRIVE MARK. WAS ABLE TO MOVE CAR BACK AND FORWARD FOR TOW TRUCK TO ATTACH. TRANSMISISON REBUILT BY FORD AT 88000 IN 1998 TWO MONTHS AFTER PURCHASE OF VEHICLE. OIL PAN GASKET REPLACE JUNE 0F 2001 AT 117,000 MILES.*AK
NHTSA ODI #760567
Official recalls
4Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
Illustration