Engine And Engine Cooling. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports9 fire reports13 injury reports

Engine And Engine Cooling complaints

142 reports

Clear category filter

Mileage unknown · Feb 23, 2001

Engine And Engine Cooling

WHILE DRIVING IN THE TRAFFIC ENGINE WILL START LOSING POWER WITHOUT PRIOR WARNING, THEN ENGINE WILL STALL. *AK

NHTSA ODI #881335

Mileage unknown · Feb 5, 2001

Engine And Engine Cooling

DEALER CANNOT FIND OUT WHY ENGINE JUST DIES.*AK AFTER THE VEHICLE STALL, THE FUEL FILTER WAS REPLACED AS A POSSIBLE CAUSE, BUT THE VEHICLE STALL AGAIN AND THE DEALER COULD NOT FIND THE CAUSE. THE MANUFACTURER WAS AWARE OF THE PROBLEM BUT WAS DOING NOTHING TO SOLVE IT. *YH

NHTSA ODI #879849

Mileage unknown · Feb 5, 2001

Engine And Engine Cooling

ENGINE CONSTANTLY OVERHEATED. *AK

NHTSA ODI #879848

Mileage unknown · Feb 5, 2001

Engine And Engine Cooling

DEALER CANNOT FIND OUT WHY AUTO STOPS WHEN ENGINE IS HOT.*AK

NHTSA ODI #879847

Mileage unknown · Feb 4, 2001

Engine And Engine CoolingSeatsStructure

Read full complaint

BOUGHT CAR USED, AS IS. INQUIRED ABOUT RECALLS, ETC. TOLD THERE WERE NONE. SALESMAN SAID HE RAN CARFAX & NOTHING SHOWED UP. ASKED IF ENGINE WAS ORIGINAL ENGINE, ANY MAJOR MECHANICAL PROBLEMS, ETC. WAS TOLD "NO". PURCHASED CAR @ BILL PENNEY TOYOTA. FIRST DAY DOOR HANDLE CAME OFF, UNDERSIDE DRIVER'S SEAT TRACK COVER CAME OFF & SUNROOF CAME OPEN & WOULDN'T SHUT. PANELING FELL OFF. 1ST WEEK THE OIL LIGHT CAME ON - CAR BEGAN USING 2 QTS OF OIL EVERY 2-3 DAYS. TOOK BACK TO DEALERSHIP. TOLD IT HAD A NEW ENGINE & SHOULDN'T BE HAVING PROBLEMS. OIL CONSUMPTION TEST RUN. BEGAN CHECKING CAR'S HISTORY. FOUND PREVIOUS OWNER BOUGHT THE CAR 4-2000 & THE DEALERSHIP BOUGHT IT BACK 6-2000. HEAD GASKET CHANGED 3X. THE DEALERSHIP SENT CAR TO WOODY ANDERSON FORD. HAD A NEW ENGINE PUT IN IT (THEY SAY). BILL PENNEY KEPT CAR 1 WEEK. SAID PROBLEM WAS UNDER A MFG. WARRANTY ON THE ENGINE ALTHOUGH THEY SOLD ME A WARRANTY FOR $1,000 FOR WHAT WAS ALREADY UNDER WARRANTY. THEY SENT CAR TO WOODY ANDERSON FORD; FORD KEPT IT FOR A WEEK. THEN CALLED & TOLD ME TO PICK IT UP; THERE WASN'T ANYTHING WRONG W/IT. HAD TO RENT A CAR. WARRANTY STS THEY PROVIDE ONE. CAR IS NOT FIXED. IT'S A RECURRING PROBLEM FROM ORIGINAL OWNER. ENGINE PUT IN CAR NEVER PUT ON RECORD. 4 VIN #'S HAVE BEEN USED ON PAPERWORK. MET WITH PREVIOUS OWNER. ALL FAULTS I HAD W/CAR SHE HAD AS WELL. DEALERSHIP SAYS MY TOUGH LUCK; MAYBE I LEARNED A LESSON. MFG. WON'T FIX. DENIES PROBLEM. *AK

NHTSA ODI #740400

Mileage unknown · Jan 31, 2001

Engine And Engine Cooling

THERE WAS A RECALL ON HEAD GASKET. AFTER VEHICLE WAS FIXED CONSUMER WAS SENT A LETTER STATING THAT THERE WOULD BE AN EXTENED WARRANTY ON HEAD GASKET.*AK

NHTSA ODI #879471

Mileage unknown · Jan 3, 2001

Engine And Engine Cooling

VEHICLE EXPERIENCES STALLING, DEALER CAN NOT REMEDY THE PROBLEM, POSSIBLE ENGINE FAILURE. *SLC

NHTSA ODI #558708

Mileage unknown · Nov 30, 2000

Engine And Engine Cooling

ACCORDING TO RECALL 00M09 AND A CUSTOMER SERVICE REPRESENTATIVE, THE CONSUMER QUALIFIED FOR $4000 CUSTOMER FOCUS CERTIFICATE TOWARD THE PURCHASE OF A NEW OR LEASED LINCOLN/MERCURY, THE CONSUMER SPOKE WITH THE SERVICE MANAGER WHO STATED THAT HE DID NOT QUALIFY. *SLC

NHTSA ODI #558229

Mileage unknown · Nov 2, 2000

Engine And Engine Cooling

Read full complaint

AFTER DRIVING FROM SOME TIME DURING HOT WEATHER, AND IN HEAVY TRAFFIC WITH SLOW SPEEDS, THE ENGINE LOSES POWER FOR NO APPARENT REASON. THE ENGINE WILL NOT RESTART UNTIL 1/2 TO 1 HOURS COOLDOWN TIME HAD PASSED. I BELEIVE THIS IS RELATED TO THE IMPROPER PLACEMENT OF THE TFI MODULE. MY FAMILY, INCLUDING 2 CHILDREN, WERE STUCK IN THE MIDDLE TURNING LANE IN BUSY TRAFFIC DUE TO THIS FAULTY MODULE. THIS OCCURED TWICE DURING OUR VACATION IN JUNE, BOTH DRIVING TO AND RETURNING FROM SUNRIVER, OREGON. I HAVE NOTIFIED FORD MOTOR COMPANY. THEY HAVE RESPONDED BY SIMPLY SAYING THAT THE GOVERNEMENT HAS NOT ISSUED A RECALL DUE TO THIS ITEM. I WOULD LIKE TO ADVISED YOU THAT THIS IS A DANGEROUS PROBLEM WHICH SHOULD BE CORRECTED.*AK

NHTSA ODI #735641

Mileage unknown · Oct 20, 2000

Engine And Engine Cooling

Read full complaint

I AM A MERCURY SABLE 1994 OWNER. AS I WAS DRIVING TO WORK TODAY, I BEGAN TO HAVE ENGINE TROUBLE. I HAD THE CAR TOWED TO A NEARBY GARAGE. I WAS INFORMED LATER THIS MORNING THAT I HAD BLOWN A HEAD GASKET. THE GARAGE SUGGESTED THAT I TOW THE CAR TO A NEARBY FORD DEALER, NOVATO FORD. REMEMBERING THAT FORD HAD ISSUED A LETTER REGARDING HEAD GASKETS AND BEFORE TOWING TO THE NOVATO FORD DEALERSHIP, I DECIDED TO CALL THE DEALERSHIP. AFTER I EXPLAINED THE SITUATION, THE SERVICE ADVISOR SAID THAT HE ALSO REMEMBERED THIS "HEAD GASKET" SITUATION AND PUT ME ON HOLD. WHEN HE RETURNED HE INFORMED ME THAT SINCE MY MILEAGE WAS OVER 100,000 (CURRENTLY 105,693), I WOULD NOT BE ELIGIBLE FOR THE EXTENDED WARRANTY COVERAGE. I THEN CALLED FORD CUSTOMER SERVICE 800 392-3673 AND REFERENCED THE EXTENDED WARRANTY COVERAGE UNDER SERVICE PROGRAM, #98M01. QUOTING THE LETTER - THE LETTER STATES, "FORD MOTOR COMPANY IS PROVIDING EXTENDED WARRANTY COVERAGE UNDER SERVICE PROGRAM, #98M01, TO OWNERS OF 1994 AND 1995 TAURUS AND SABLE AND 1995 WINDSTAR VEHICLES EQUIPPED WITH A 3.8L FWD ENGINE. REASON FOR THIS PROGRAM: PREMATURE FAILURE OF THE HEAD GASKETS MAY OCCUR AND MAY RESULT IN ENGINE OVERHEATING OR IN EXTREME CASES COULD CAUSE ENGINE FAILURE IF THE OVERHEAT CONDITION IS IGNORED. THE EXTENDED WARRANTY COVERAGE IS FORD MOTOR COMPANY'S COMMITMENT TO CUSTOMER SATISFACTION AND WE ARE TAKING THIS ACTION AS PART OF OUR ONGOING EFFORTS TO MAINTAIN YOUR CONFIDENCE IN OUR PRODUCTS." I WAS INFORMED THAT THERE WAS NOTHING THAT COULD BE DONE. I EXPLAINED THAT I ACQUIRED THE CAR IN 1997 AT 44,000 MILES. UPON RECEIVING THE JUNE 1998 LETTER, I DID GO TO MY LOCAL HILLTOP FORD DEALERSHIP AND ASKED THEM TO CHECK OUT THE HEAD GASKET(S). I WAS TOLD THAT THEY WERE FINE.

NHTSA ODI #734812

Official recalls

98V323000 · Structure:frame And Members

Dec 16, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence & remedy

Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.

98V009000 · Exterior Lighting:headlights:switch

Jan 21, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.

Consequence & remedy

Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.

97V025000 · Vehicle Speed Control

Feb 26, 1997

VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.

Consequence & remedy

Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.

97V019000 · Engine And Engine Cooling:cooling System:fan

Feb 25, 1997

THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.

Consequence & remedy

Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ99017 · Front Suspension Spring

Opened Aug 9, 1999 · Closed Feb 16, 2000

Status: closed (inferred from source dates) · Suspension

There is no summary currently available

EA96024 · Engine Cooling Fan Fires

Opened Sep 30, 1996 · Closed Apr 15, 1997

Status: closed (inferred from source dates) · Engine And Engine Cooling

There is no summary currently available

EA96019 · Headlight Failure

Opened Jul 31, 1996 · Closed Jan 26, 1998

Status: closed (inferred from source dates) · Exterior Lighting

EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.

PE96033 · Engine Cooling Fan Fires

Opened May 2, 1996 · Closed Sep 30, 1996

Status: closed (inferred from source dates) · Engine And Engine Cooling

IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.