NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
48 reportsClear category filter181,978 miles · Jan 19, 2008
Power Train
IN EARLY JANUARY 2008, MY MERCURY SABLE 3.0 WAGON, BEGAN TO HAVE TRANSMISSION (AX4S) PROBLEMS OF ERADICT UPSHIFTING AND DOWNSHIFTING WHEN ACCELERATING FROM A STOP AND CLIMBING A HILL. IN ADDITION WHEN I CHECKED THE FLUID LEVEL WHEN THE MOTOR IS HOT IT APPEARS LOW IN ATF FLUID, BUT WHEN THE MOTOR HAS COOLED THE TRANSMISSION FLUI…
Read full complaint
IN EARLY JANUARY 2008, MY MERCURY SABLE 3.0 WAGON, BEGAN TO HAVE TRANSMISSION (AX4S) PROBLEMS OF ERADICT UPSHIFTING AND DOWNSHIFTING WHEN ACCELERATING FROM A STOP AND CLIMBING A HILL. IN ADDITION WHEN I CHECKED THE FLUID LEVEL WHEN THE MOTOR IS HOT IT APPEARS LOW IN ATF FLUID, BUT WHEN THE MOTOR HAS COOLED THE TRANSMISSION FLUID STICK INDICATES THE TRANSMISSION FULL AT THE RIGHT LEVEL. I HAVE BECOME AWARE THAT THE AX4S HAS A HISTORY OF "INADEQUATE INTERNAL LUBRICATION OF CRITICAL PARTS AND A WEAK FORWARD CLUTCH PISTON THAT CRACKS AND LEAKS PRESSURE" THAT LEADS TO COMPLETE FAILURE OF THE TRANSMISSION. MY CAR IS NO LONGER OPERATIONAL DUE TO TRANSMISSION FAILURE. THE ESTIMATED COST ON AVERAGE FROM TRANSMISSION REPAIR SHOPS IN MY AREA IS 2200.00. I WOULD LIKE TO KEEP THE CAR AND REALIZE NOW THAT THIS PARTICULAR TRANSMISSION HAS NUMEROUS COMPLAINTS OF FAILURE AND FORD IS AWARE OF THE FACTORY DEFECTS BUILT INTO THE TRANSMISSION. I WOULD LIKE FORD TO REPAIR MY TRANSMISSION AT THERE EXPENSE SINCE THEY HAVE BEEN AWARE OF THESE PROBLEM FOR YEARS YET CONTINUED TO MANUFACTURE AND INSTALL THIS TRANSMISSION INTO THERE VEHICLES BEING SOLD TO THE PUBLIC. *TR
NHTSA ODI #10215438
84,572 miles · Apr 29, 2004
Power Train
WHILE DRIVING AT 5 MPH AND WITHOUT ANY WARNING THE AUTOMATIC TRANSMISSION FAILED. TOWED VEHICLE TO THE DEALER AND THE TECHNICIAN DETERMINED THE VEHICLE NEEDED A NEW TRANSMISSION. *AK *JB
NHTSA ODI #10059796
135,000 miles · Jan 15, 2004
Engine And Engine CoolingPower Train
FORD 3.8L HEAD GASKET FAILURE TRANSMISSION FAILURE
NHTSA ODI #10069430
Mileage unknown · Aug 29, 2002
Engine And Engine CoolingPower TrainVisibility
CAR HAS STALLED SINCE FIRST DAY WHEN STOPPING AND UPON ACCELERATION ENGINE STALLS AND WON'T CRANK,ALSO HAD BROKEN MOTOR MOUNTS,POWER WINDOWS NOT WORKING,TACHOMETER NOT WORKING,WINDSHIELD WIPER WAS MISING WHEN BOUGHT. *AK
NHTSA ODI #766419
Mileage unknown · Feb 28, 2002
Engine And Engine CoolingPower Train
ANTIFREEZE LEAK DUE TO BLOWN HEAD GASKET. *AK THERE WAS A RECALL ON BLOWER HEAD GASKET AT ONE TIME, BUT THE DEALER POINTED OUT THAT THE RECALL TIME WAS OVER. THE CONSUMER REPLACED A MOTION SENSOR ON THE TRANSMISSION WHICH WAS ALSO WAS ON RECALL A LONG TIME AGO. *YH
NHTSA ODI #8004731
Mileage unknown · Jul 12, 2001
Engine And Engine CoolingExterior LightingPower Train
WHENEVER VEHICLE WAS IN OVERDRIVE, IT WOULD JERK AND THEN STALL OUT WHEN TURNING CORNERS. THIS CAUSED POWER STEERING TO LOCK UP. TOOK VEHICLE TO DEALERSHIP, AND WAS INFORMED NOTHING COULD BE DONE ABOUT IT. VEHICLE WAS NOT RECALLED.*AK CONSUMER WAS INFORMED THAT HIS VEHICLES VIN WAS NOT INCLUDED IN RECALL, SO CONSUMER HAD …
Read full complaint
WHENEVER VEHICLE WAS IN OVERDRIVE, IT WOULD JERK AND THEN STALL OUT WHEN TURNING CORNERS. THIS CAUSED POWER STEERING TO LOCK UP. TOOK VEHICLE TO DEALERSHIP, AND WAS INFORMED NOTHING COULD BE DONE ABOUT IT. VEHICLE WAS NOT RECALLED.*AK CONSUMER WAS INFORMED THAT HIS VEHICLES VIN WAS NOT INCLUDED IN RECALL, SO CONSUMER HAD THE HEAD GASKET AND THERMOSTAT REPLACED AND PAID FOR REPAIRS. TRANSMISSION IS NOW GOING OUT. RIGHT OUTER TIE ROD END REPLACED, WAS CAUSING A SQUEAKING NOISE WHEN TURNING STEERING WHEEL. WINDSHIELD WASHER PUMP FAILED AND CAUSED A LEAK. HEADLIGHT SWITCH FAILED. *SLC
NHTSA ODI #892615
Mileage unknown · Jun 11, 2001
Engine And Engine CoolingEquipmentExterior Lighting
ENGINE AND RADIATOR REPLACED, VEHICLE ALSO EXPERIENCED OIL LEAK. *SLC
NHTSA ODI #561532
Mileage unknown · Jun 6, 2001
Engine And Engine CoolingPower Train
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #746514
Mileage unknown · May 30, 2001
Engine And Engine CoolingPower Train
AUTOMATIC TRANSMISSION IS JUMPING AND HAS DIFFICULTY SHIFTING INTO HIGHER GEARS. CONSUMER WAS ORIGINALLY INFORMED THAT THIS DEFECT WAS DUE TO BROKEN MOTOR MOUNTS. CONSUMER HAD MOTOR MOUNTS REPLACED. HOWEVER, TRANSMISSION PROBLEMS HAVE REMAINED.*AK CONSUMER WAS ADVISED THAT PROBLEM WAS A SPEED SENSOR, IT WAS REPAIRED .*JB
NHTSA ODI #889369
Mileage unknown · May 15, 2001
Engine And Engine CoolingEquipmentPower Train
THE TRANSMISSION IS JUST ONE OF THE PROBLEMS WE HAVE HAD WITH THIS CAR.THE AIR CONDITIONING NEVER WORKED VERY WELL. DECEMBER 1998 THE AIR CONDITIONING QUIT WORKING COMPLETELY. THE CRUISE CONTROL QUIT WORKING IN 1996. ONE OF THE POWER WINDOWS QUIT WORKING IN 1997. THE HEADLINER NEAR THE BACK WINDSHIELD STARTED HANGING DOWN IN 199…
Read full complaint
THE TRANSMISSION IS JUST ONE OF THE PROBLEMS WE HAVE HAD WITH THIS CAR.THE AIR CONDITIONING NEVER WORKED VERY WELL. DECEMBER 1998 THE AIR CONDITIONING QUIT WORKING COMPLETELY. THE CRUISE CONTROL QUIT WORKING IN 1996. ONE OF THE POWER WINDOWS QUIT WORKING IN 1997. THE HEADLINER NEAR THE BACK WINDSHIELD STARTED HANGING DOWN IN 1998. OUR LATEST PROBLEM IS A BLOWN HEAD GASKET. WE HAD THE TRANSMISSION REPAIRED 11/1/98 AT A COST TO US OF $1,788.00. PLUS IT COST US OVER $100.00 TO HAVE THE CAR TOWED. THE FORD COMPANY HASN'T DONE ANYTHING TO HELP US.
NHTSA ODI #745389
Official recalls
6Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
May 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF NEW YORK, MICHIGAN, OHIO, ILLINOIS, WISCONSIN, PENNSYLVANIA, MASSACHUSETTS, INDIANA, NEW JERSEY, MAINE, CONNECTICUT, NEW HAMPSHIRE, RHODE ISLAND, VERMONT, MINNESOTA, IOWA, MISSOURI, KENTUCKY, MARYLAND, DELAWARE, AND WEST VIRGINIA. THE FRONT COIL SPRINGS CAN FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL CRACKS IN THE SPRINGS.
Consequence & remedy
Consequence: THE FRONT TIRE COULD DEFLATE DUE TO A BROKEN FRONT COIL SPRING CONTACTING THE TIRE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING CATCHER BRACKET WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Jan 4, 1993
ANTI-LOCK BRAKE SYSTEM CONTROLLERS DESIGNED FOR REAR WHEEL DRIVE CARS MAY HAVE BEEN INSTALLED ON THESE FRONT WHEEL DRIVE CARS..
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED BRAKING ABILITY AND POSSIBLEVEHICLE ACCIDENT.
Remedy: REPLACE THE REAR WHEEL DRIVE ABS CONTROLLER WITH A FRONT WHEEL DRIVE ABS CONTROLLER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
11RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99023 · Windshield Wiper
Opened Aug 6, 1999 · Closed Jun 12, 2001
Status: closed (inferred from source dates) · Visibility
ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the owner alleges havingto leave the roadway or roll down the window and manually restart the sweeping motion of the wiper arms.Other complaints allege that the wiper sweeps too slowly at the maximum speed setting resulting in inadequate vision during heavy precipition.Some complaints allge repeated wiper system malfunctions despirt having their vehicles serviced at Ford dealerships of replacement of the multi-function switch and/or wiper motor.Ford provided its response to an Information Request Letter indicating that the same wiper motor is used on the MY 1987-1993 Taurus and Sable; however, warranty and complaint data show that the MY 1993 is over represented and may warrant particular attention.An Engineering Ananlysis is necessary to determine if a potential safety defect exists.
PE99015 · Windshield Wiper
Opened Feb 24, 1999 · Closed Aug 6, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
PE96018 · Headlights Failure
Opened Mar 5, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Exterior Lighting:headlights
There is no summary currently available
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration