Electrical SystemEngine And Engine CoolingEquipment
1998 MERCURY MYSTIQUE. ELECTRICAL SUB-HARNESS CONNECTOR PROBLEMS. *SMD THE CONSUMER STATED HE TOOK THE VEHICLE TO HIS MECHANIC, BECAUSE THE AC WASN'T COOLING PROPERLY AND THE VEHICLE WOULD OVER HEAT, WHILE IT WAS ON. THE VEHICLE HAS TWO FANS IN THE FRONT AND THEY FOUND THE COOLING FAN MELTED AND THE SUB-HARNESS CONNECTOR BURN…
Read full complaint
1998 MERCURY MYSTIQUE. ELECTRICAL SUB-HARNESS CONNECTOR PROBLEMS. *SMD THE CONSUMER STATED HE TOOK THE VEHICLE TO HIS MECHANIC, BECAUSE THE AC WASN'T COOLING PROPERLY AND THE VEHICLE WOULD OVER HEAT, WHILE IT WAS ON. THE VEHICLE HAS TWO FANS IN THE FRONT AND THEY FOUND THE COOLING FAN MELTED AND THE SUB-HARNESS CONNECTOR BURNED UP. IN ADDITION, THEY SHOWED THE CONSUMER THE PART OF THE SUB-HARNESS WITH THE INSULATION JUST FALLING OFF THE WIRE. THEY HAD TO REPLACED THE FAN MOTOR UNIT AND HAD TO SPLICE IN A FAN CONNECTOR AND WIRE INTO THE REST OF THE SUB-HARNESS, BECAUSE FOR SAID THE SUB-HARNESS WAS OBSOLETE AND NOT AVAILABLE. WHILE IT FUNCTIONS, THE CHECK ENGINE LIGHT HAS SINCE ILLUMINATED FOR A CAM SHAFT POSITION SENSOR, WHICH THE CONSUMER WAS INFORMED IT WAS RELATED TO THE SUB-HARNESS. ALSO, THE LOWER CONTROL ARMS, BALL JOINTS, FRONT STRUTS, REAR STRUTS AND REAR MOUNTS, NUMEROUS O2 SENSORS, RADIO ANTENNA, RACK AND PINION, DRIVERS SIDE POWER WINDOW AND SWITCH CONTROLLER WERE ALL REPLACED. THE ENGINE AND TRANSMISSION MOUNTS ALSO HAD TO BE REPLACED. *JB
NHTSA ODI #10637913
87,000 miles · Oct 29, 2007
Engine And Engine CoolingSteeringSuspension
I HAVE HAD NUMEROUS FRONT END PROBLEMS. I HAVE HAD TO REPLACE FRONT TIE RODS TWICE IN A YEAR AND A HALF. HAVING PROBLEMS WITH STRUTS .CONTROL ARM BUSHINGS NEED TO CHANGED. ALSO STABILIZERS LINKAGE HAD TO BE CHANGED. HAVE ALSO PUT NEW BALL JOINTS IN. *TR
NHTSA ODI #10207384
Mileage unknown · Jul 24, 2002
Electrical SystemEngine And Engine CoolingSeat BeltsFire
HORN DOES NOT WORK. VEHICLE HAS BEEN CHECKED BY DEALER SEVERAL TIMES. HORN WOULD WORK INTERMITTENTLY, BUT CURRENTLY IT HAS FAILED COMPLETELY.*AK THE REAR SEAT BELTS ARE INOPERATIVE. THE POWER STEERING, ALTERNATOR, AND FRONT BRAKES FAILED. THE CATALYTIC CONVERTER CAUGHT ON FIRE. *JG
NHTSA ODI #8014643
Mileage unknown · Dec 20, 2001
SteeringSuspension
WHEEL BEARINGS WERE DEFECTIVE. STEERING MADE A LOT OF NOISE WHILE CONSUMER WAS DRIVING. TOOOK VEHICLE TO AN INDEPENDENT MECHANIC, INFORMED CONSUMER THAT SPINDLE ON DRIVER'S SIDE WAS DEFECTIVE. SPINDLE ON PASSENGER'S SIDE WAS NOT.*AK
NHTSA ODI #8000994
Mileage unknown · Aug 22, 2001
Steering
POWER STEERING PUMP FAILED AFTER A FEW DAYS OF DRIVING IN VERY HEAVY RAIN. POWER STEERING WAS INTERMITTENT AND THEN GONE COMPLETELY. THE DEALER SAID THE RACK&PINION AND PUMP NEED TO BE REPLACED.*AK
NHTSA ODI #750928
Mileage unknown · Feb 28, 2001
Steering
WHEEL THAT BELT MAKES MOVE AROUND AND MAKES POWER STREEING PUMP WORK FAILED. HAS NOT CONTACTED DEALER YET.*AK
NHTSA ODI #881789
Mileage unknown · Sep 21, 2000
Engine And Engine CoolingSteering
WHEN ROAD IS WET AND CHANGING LANE ENGINE WOULD STALL AND VEHICLE STEERING WOULD LOCK UP WITHOUT ANY INDICATION. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #871138
Mileage unknown · Sep 30, 1999
Steering
WHEN DRIVING UNDER WET CONDITIONS POWER STEERING GOES OUT, MAKING THE STEERING STIFF. IF CONSUMER IS IN THE MIDDLE OF A TURN SHE HAS TO MANUALLY RETURN THE STEERING. DEALER HAS BEEN CONTACTED. *AK *MJS
NHTSA ODI #846272
Mileage unknown · Sep 23, 1999
Power TrainService Brakes, HydraulicSteering
WHEN DRIVING AT VARIOUS SPEEDS DURING RAINY AND WET CONDITIONS,THE POWER STEERING FAILS DURING THE ENACTMENT OF A TURN. THE DEALERSHIP "CANNOT DIAGNOSE"THIS DANGEROUS OCCURANCE.
NHTSA ODI #711894
Mileage unknown · Dec 22, 1998
Steering
THE STEERING HAS NEVER BEEN ABLE TO HOLD AN ALIGNMENT. I HAD AN CHECK ENGINE LIGHT GO ON AND HAD TWO SERVICE TRIES BEFORE IT WAS FIXED. I HAVE HAD A ROTTEN EGG SMELL AND ENGINE PINGING FOR THE LAST 6,000 MILES. I ONLY HAVE 10,500 ON IT NOW. THE DEALER WILL NOT EVEN TRY TO FIX IT. I'M TRYING TO GET A HOLD OF THE DISTRICT REP TO T…
Read full complaint
THE STEERING HAS NEVER BEEN ABLE TO HOLD AN ALIGNMENT. I HAD AN CHECK ENGINE LIGHT GO ON AND HAD TWO SERVICE TRIES BEFORE IT WAS FIXED. I HAVE HAD A ROTTEN EGG SMELL AND ENGINE PINGING FOR THE LAST 6,000 MILES. I ONLY HAVE 10,500 ON IT NOW. THE DEALER WILL NOT EVEN TRY TO FIX IT. I'M TRYING TO GET A HOLD OF THE DISTRICT REP TO TRY TO SWITCH TO ANOTHER VEHICLE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.
Consequence & remedy
Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.
Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.
Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
EA00025 · Fuel Expulsion During Refueling
Opened Oct 4, 2000 · Closed Jan 25, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00027 · Fuel Expulsion During Refueling
Opened Jul 10, 2000 · Closed Oct 4, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
SQ98002 · Fuel Gauge Does Not Read Below 1/4
Opened Jan 27, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FORD'S SERVICE BULLETIN DATED DECEMBER 8, 1997, POINTS OUT THAT THE FUEL GAUGE WILL NOT READ ABOVE 3/4 TANK OR BELOW 1/4 TANK OF FUEL.THE ERRONEOUS FUEL GAUGE READING WILL INDICATE SIGNIFICANTLY MORE FUEL RESERVE THAN ACTUALLY PRESENT IN THE FUEL TANK.ODI HAS ONE COMPLAINT WHERE THE DRIVER ALLEGED THAT HIS VEHICLE RAN OUT OF GAS DUE TO A FALSE FUEL GAUGE READING.THIS INVESTIGATION WASTO ASCERTAIN FACTS CONCERNING THE PROBLEM EXPERIENCE, SCOPE, AND RATIONAL FOR ELECTING NOT TO CONDUCT A SAFETY COMPAIGN.
1998 Mercury Mystique Problems, Complaints & Recalls | Skip That Year
Illustration