IllustrationHEAD LIGHT SWITCH HARD TO APPLY HEAD LIGHT FLICKER ON AND OFF.SOMETIME WILL NOT COME ON AT ALL.CAR WAS IN MOTION,AND STATIONARY
1993 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 195 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports4 fire reports2 injury reports
Exterior Lighting complaints
24 reportsTL* THE CONTACT OWNS A 1993 MERCURY COUGAR. THE CONTACT STATED THAT WHILE AT A STOP, THE HEADLIGHTS BEGAN TO FLICKER WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE WOULD RECUR SPORADICALLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VE…
Read full complaint
TL* THE CONTACT OWNS A 1993 MERCURY COUGAR. THE CONTACT STATED THAT WHILE AT A STOP, THE HEADLIGHTS BEGAN TO FLICKER WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE WOULD RECUR SPORADICALLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 99V275000 (EXTERIOR LIGHTING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 160,000.
TL* THE CONTACT OWNS A 1993 MERCURY COUGAR. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT NOTICED THAT THE HEADLIGHTS BEGAN TO FLICKER. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 99V275000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH) BUT WAS ADVISED BY THE DEALER THAT THE…
Read full complaint
TL* THE CONTACT OWNS A 1993 MERCURY COUGAR. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT NOTICED THAT THE HEADLIGHTS BEGAN TO FLICKER. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 99V275000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH) BUT WAS ADVISED BY THE DEALER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 164,431.
TL*THE CONTACT OWNS A 1993 MERCURY COUGAR. WHILE DRIVING 75 MPH, THE INSTRUMENT PANEL LIGHTS AND THE HEADLIGHTS DIMMED. THE CONTACT ALSO NOTICED SMOKE RISING FROM THE DASHBOARD. THE DEALER STATED THAT THE VEHICLE NEEDED A NEW HEADLIGHT SWITCH AND THEY MADE THE REPAIR. APPROXIMATELY ONE YEAR LATER, THE FAILURE RECURRED. THE …
Read full complaint
TL*THE CONTACT OWNS A 1993 MERCURY COUGAR. WHILE DRIVING 75 MPH, THE INSTRUMENT PANEL LIGHTS AND THE HEADLIGHTS DIMMED. THE CONTACT ALSO NOTICED SMOKE RISING FROM THE DASHBOARD. THE DEALER STATED THAT THE VEHICLE NEEDED A NEW HEADLIGHT SWITCH AND THEY MADE THE REPAIR. APPROXIMATELY ONE YEAR LATER, THE FAILURE RECURRED. THE DEALER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V275000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE FAILURE MILEAGE WAS 4,000 AND CURRENT MILEAGE WAS 189,000.
LIGHTS PERIODICALLY STOPPED WORKING ELIMINATING VISIBILITY. *JB
I WAS DRIVING HOME GOING DOWN A COUNTRY ROAD AND MY HEADLIGHTS QUIT WORKING. I ALMOST WRECKED,AND I ALMOST LOST CONTROL OF MY VEHICLE. I ENDED UP DRIVING IT HOME WITH NOTHING BUT PARKING LIGHTS ON WHICH WAS A GOOD HALF HOUR JOURNEY. *NM
WHILE DRIVING DOWN THE ROAD, AT NIGHT HEADLIGHTS FLICKERED OFF AND ON. CONSUMER CONTACTED THE DEALER AND THE MANUFACTURER. CONSUMER WAS TOLD THAT THIS DEFECT WAS NOT AN OPEN RECALL. PREVIOUS REPLACEMENT OF THE HEADLIGHTS WERE UNDETERMINED BY THE MANUFACTURER. *AK THE CONSUMER WAS TOLD THAT HIS VEHICLE BEING OLD IS TO BLAME F…
Read full complaint
WHILE DRIVING DOWN THE ROAD, AT NIGHT HEADLIGHTS FLICKERED OFF AND ON. CONSUMER CONTACTED THE DEALER AND THE MANUFACTURER. CONSUMER WAS TOLD THAT THIS DEFECT WAS NOT AN OPEN RECALL. PREVIOUS REPLACEMENT OF THE HEADLIGHTS WERE UNDETERMINED BY THE MANUFACTURER. *AK THE CONSUMER WAS TOLD THAT HIS VEHICLE BEING OLD IS TO BLAME FOR FAILURE. THE CONSUMER HAD THE HEADLIGHT SWITCH REPLACED. *TC
HEAD LIGHTS FLICKER OFF AND ON. I HAD TO PLAY WITH THE HEADLIGHT SWITCH TO FINALLY GET THEM BACK ON. AT FIRST THE INSTRUMENT CLUSTER WOULD NOT COME ON, BUT BARELY PULLED ON SWITCH AND THEY CAME ON. PULLED DASH APART AND NOTICED THE SWITCH BRACKET WAS MELTED A LITTLE AND A (BROWN AND GRAY?) WIRE WAS SCORCHED, MELTED, FRAYED.*JB
INTERNAL LIGHTS AND HEADLIGHTS COME ON AND OFF INTERMITTENTLY. DEALERSHIP IS AWARE OF PROBLEM. *AK RECALL 99V275 DEALS WITH THIS SAME PROBLEM, HOWEVER CONSUMER WAS INFORMED BY THE FORD RECALL HOTLINE THAT HER VIN WAS NOT INCLUDED, CONSUMER WILL NOT DRIVE THE VEHICLE AT NIGHT. *JB
LEFT HUB IS STARTING TO GO OUT..THE LOCK IS STUCK ON MY IGNITION SWITCH SO I CANN'T CRANK MY CAR..MOTOR MOUNT BROKE.*AK
Official recalls
399V275000 · Exterior Lighting:headlights:switch
Oct 12, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
97V159000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Sep 22, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.
Consequence & remedy
Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
96V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA99005 · Headlight Switch
Opened Jan 20, 1999 · Closed Dec 14, 1999
Status: closed (inferred from source dates) · Exterior Lighting
SUBJECT VEHICLES HAVE A HEADLIGHT SWITCH WITH AN INTERNAL, BIMETAL CIRCUIT BREAKER THAT CAN OPEN DUE TO OVERHEATING DURING HEADLING OPERATION.
RQ97011 · Fuel Line Jumper
Opened Sep 25, 1997 · Closed Nov 16, 1998
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
TO DETERMINE THE SCOPE OF THE ALLEGED FUEL LINE FAILURES OUTSIDE OF THE RECALL GEOGRAPHIC REGION AND IF THE RECALL SHOULD BE EXPANDED NATIONALLY