Illustration1993 3.8 L BLEW A HEAD GASKET AT 97K. $1200 OUT OF MY POCKET. I DON'T EVEN MAKE THAT MUCH A MONTH. I WILL NEVER BY A FORD AGAIN. *JB
1993 Mercury Cougar
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cougar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 195 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports4 fire reports2 injury reports
Engine And Engine Cooling complaints
105 reports1993 COUGAR HEAD GASKET BLEW AGAIN . *AK
WHILE DRIVING ENGINE CHECK LIGHT CAME ON, THE ENGINE OVERHEATED, AND WHITE SMOKE STARTED COMING OUT THE EXHAUST PIPE. THE ALUMINUM HEAD GASKET BLEW OUT. DEALERSHIP INDICATED THIS WAS A COMMON PROBLEM WITH THIS SIZE ENGINE BECAUSE THE GASKET WRAPPED. *AK
MY 1993 MERCURY COUGAR XR7 HAS BLOWN A HEAD GASKET TWICE (ONE AT 80,000 MILES AND ANOTHER AT 120,000 MILES.) AND AFTER SEARCHING THE INTERNET ENDLESSLY I HAVE FOUND MANY PEOPLE LIKE MYSELF THAT HAD THE SAME PROBLEM ON THE SAME MAKE AND MODEL OF VEHICLE. THIS IS AN OUTRAGE TO MYSELF AND MANY OTHER OWNERS OF THIS TYPE OF VEHICLE A…
Read full complaint
MY 1993 MERCURY COUGAR XR7 HAS BLOWN A HEAD GASKET TWICE (ONE AT 80,000 MILES AND ANOTHER AT 120,000 MILES.) AND AFTER SEARCHING THE INTERNET ENDLESSLY I HAVE FOUND MANY PEOPLE LIKE MYSELF THAT HAD THE SAME PROBLEM ON THE SAME MAKE AND MODEL OF VEHICLE. THIS IS AN OUTRAGE TO MYSELF AND MANY OTHER OWNERS OF THIS TYPE OF VEHICLE AND I HOPE THAT YOU CAN DO SOMETHING TO TRY AND CORRECT THIS PROBLEM. *LA
HEAD GASKET BLEW @ 114,000 MILES ON 93 MERCURY COUGAR 3.8 V-6 ENGINE. TWO REPAIR SHOPS HAVE STATED "EVERYBODY" IN VEHICLE REPAIR BUSINESS KNOWS THE 3.8 ENGINE HAS GASKET PROBLEM TO THE POINT THE GASKETS BLOW IN ONE OF TWO PLACES. I AM ORIGINAL OWNER OF CAR AND IT HAS NEVER BEEN ABUSED. UNDERSTAND THERE WAS A RECALL ON SOME 3.…
Read full complaint
HEAD GASKET BLEW @ 114,000 MILES ON 93 MERCURY COUGAR 3.8 V-6 ENGINE. TWO REPAIR SHOPS HAVE STATED "EVERYBODY" IN VEHICLE REPAIR BUSINESS KNOWS THE 3.8 ENGINE HAS GASKET PROBLEM TO THE POINT THE GASKETS BLOW IN ONE OF TWO PLACES. I AM ORIGINAL OWNER OF CAR AND IT HAS NEVER BEEN ABUSED. UNDERSTAND THERE WAS A RECALL ON SOME 3.8 FORD ENGINES, BUT NOT THE '93 ENGINE. *NLM
CONSUMER STATES IT IS HARD TO START THE VEHICLE AND IT TAKES NUMEROUS TRIES BEFORE THE VEHICLE WILL START. DEALER NOTIFIED.*JB
CONSUMER STATES OF HAVING PROBLEMS WITH EXHAUST SYSTEM. DEALER WAS CONTACTED. TS
CONSUMER STATES OF HAVING PROBLEMS WITH THE THERMOSTAT. DEALER WAS CONTACTED. TS
WHILE DRIVING VEHICLE STARTED OVERHEATING, SMOKE /STEAM CAME FROM THE TAIL PIPE.HAD VEHICLE TOWED. HEAD GASKET HAD BLOWN OUT. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Official recalls
399V275000 · Exterior Lighting:headlights:switch
Oct 12, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FOG LIGHTS, IN WHICH THE HEADLIGHTS MAY GO OUT FOR VARIOUS INTERVALS AND WHICH MAY BE PRECEDED BY FLICKERING OR BLINKING AS A RESULT OF THE CIRCUIT BREAKER OPENING.
Consequence & remedy
Consequence: DRIVER'S COULD EXPERIENCE A LOSS OF VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH WHICH INCORPORATES A CIRCUIT BREAKER OF REVISED DESIGN, AND INSTALL A WIRING HARNESS CONNECTOR, IF NEEDED.
97V159000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Sep 22, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DISTRICT OF COLUMBIA, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MARYLAND, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WISCONSIN, AND WEST VIRGINIA. MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE.
Consequence & remedy
Consequence: THIS FUEL LEAKAGE RESULTS IN DAMPNESS AND FUEL ODOR, AND IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSTALL A PLASTIC CONVOLUTE COVERING AROUND THE FUEL LINES. IF THE LINES SHOW A LEAK, THE LINES WILL BE REPLACED FIRST.
96V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA99005 · Headlight Switch
Opened Jan 20, 1999 · Closed Dec 14, 1999
Status: closed (inferred from source dates) · Exterior Lighting
SUBJECT VEHICLES HAVE A HEADLIGHT SWITCH WITH AN INTERNAL, BIMETAL CIRCUIT BREAKER THAT CAN OPEN DUE TO OVERHEATING DURING HEADLING OPERATION.
RQ97011 · Fuel Line Jumper
Opened Sep 25, 1997 · Closed Nov 16, 1998
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
TO DETERMINE THE SCOPE OF THE ALLEGED FUEL LINE FAILURES OUTSIDE OF THE RECALL GEOGRAPHIC REGION AND IF THE RECALL SHOULD BE EXPANDED NATIONALLY