NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
2 reportsClear category filterMileage unknown · Mar 30, 2025
Service BrakesSteeringUnknown Or Other
I am writing to formally raise a critical safety concern regarding the performance and behavior of the Crosswind Assist system in my 2020 Mercedes-Benz Sprinter 3500, upfitted by Airstream as a B-Class RV. This vehicle, identified by VIN [XXX] , exhibited behavior that I believe constitutes a significant and potentially dangero…
Read full complaint
I am writing to formally raise a critical safety concern regarding the performance and behavior of the Crosswind Assist system in my 2020 Mercedes-Benz Sprinter 3500, upfitted by Airstream as a B-Class RV. This vehicle, identified by VIN [XXX] , exhibited behavior that I believe constitutes a significant and potentially dangerous flaw in its integrated driver-assistance programming. During a westbound trip from Minnesota to Nevada—traversing high-wind corridors in South Dakota, Wyoming, and Utah—the Crosswind Assist system activated on multiple occasions while overtaking large trucks during gusty wind conditions. The system appeared to override driver input by abruptly applying the brakes and modulating throttle response. On one particular occasion, this intervention forced our vehicle laterally toward a semi-truck in the adjacent lane while simultaneously initiating a hard brake event. This caused not only a near side-impact collision but also a chain reaction behind us, as trailing vehicles panic-braked, narrowly avoiding a rear-end collision. This level of autonomous intervention, especially under highway-speed wind shear, presents what I consider a severe safety risk to occupants and other motorists. No reasonable amount of driver anticipation, route planning, or wind-speed awareness could have prevented the unintended and forceful application of braking and steering commands we experienced. Upon referring to the owner’s manual and engaging in discussions on several Airstream and Sprinter-owner forums, I discovered that other owners have experienced similar incidents. Some users referenced the ability to disable the system through authorized Mercedes-Benz diagnostic software. Based on this information, I scheduled a service appointment at Mercedes-Benz of Farmington, Utah on March 17, service invoice [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11651549
Mileage unknown · Nov 14, 2024
Unknown Or OtherVehicle Speed Control
My van has periodic lack of acceleration or dead pedal. There are no warnings that this will occur. This shows itself when trying to advance from a stopped position. When I push the accelerator the van either does not move at all or barely crawls forward. This can last 15-45 seconds. There are no RPMs from the engine. Onc…
Read full complaint
My van has periodic lack of acceleration or dead pedal. There are no warnings that this will occur. This shows itself when trying to advance from a stopped position. When I push the accelerator the van either does not move at all or barely crawls forward. This can last 15-45 seconds. There are no RPMs from the engine. Once the pedal starts to respond, the issue will resolve. The problem is you need to get to that point where the engine can make rated power. Once you put in in drive, and if you're able to idle away from the parking spot, you may find that when you need power to move up a hill or through an intersection, it just isn't there. You can't wait a minute with your foot to the floor when you're in the middle of an intersection. sometimes it will slowly accelerate. This has caused multiple situations where I thought I was going to die due to being out in cross traffic and failing to be able to move. It happens both in reverse and forward. It happens even though I have warmed up the engine for 5 minutes or more. It seems to happen more at altitude but has also happened at sea level. It doesn't seem to matter if the outdoor temperature is warm or cold. The dealer can not detect a problem. I have read many accounts of this happening on MBZ forums. This must be a known issue with MBZ yet they have failed to solve it. Some think it is a sensor initiation issue after a cold soak. Someone is going to die because of this problem if MBZ is not forced to fix it.
NHTSA ODI #11625256
Official recalls
16Dec 13, 2024
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Consequence & remedy
Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.
Consequence & remedy
Consequence: Reduced stability increases the risk of a crash. Additionally, the third-row seat mountings can fail, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and repair the frame members as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ROHRAH.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Consequence & remedy
Consequence: A detached partition wall can increase the risk of injury.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
Dec 1, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021-2023 Mercedes-Benz Sprinter and 2021 Freightliner Sprinter vehicles. The topcoat paint formula may cause the windows and interior lashing rails to be insufficiently bonded to the vehicle.
Consequence & remedy
Consequence: An insufficiently bonded window can detach during a crash, and objects secured to an insufficiently bonded interior lashing rail can detach, increasing the risk of injury.
Remedy: Dealers will inspect the paint adhesion and repair it as necessary, free of charge. Depending on the extent of any damage, DVUSA may offer to repurchase the vehicle. Interim notification letters, notifying owners of the safety risk, were mailed February 5, 2024. Owner notification letters were mailed November 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LACKHA.
Mar 24, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.
Consequence & remedy
Consequence: A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed May 5, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMBAUS.
Oct 21, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with a manual parking brake and 7-speed automatic transmission. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in vehicle rollaway.
Consequence & remedy
Consequence: Vehicle rollaway increases the risk of a crash.
Remedy: Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's numbers for this recall are 22V2790611, 22V2790612, and 22V2790613.
May 20, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence & remedy
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Additional source detail variants (2)
Communication: Auto Crash Notification
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Apr 27, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rearview camera may not display the rearview image due to a software error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperable rearview camera display reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMRUE.
Mar 8, 2022
Daimler Vans USA, LLC. (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter vehicles. The shim on the torsion bar was installed incorrectly during assembly.
Consequence & remedy
Consequence: An incorrectly assembled torsion bar may fail at the connection between the torsion bar and linkage, resulting in a loss of vehicle stability, and increasing the risk of a crash.
Remedy: Dealers will correct the position of the shim and replace the torsion bar linkages, free of charge. Owner notification letters were mailed August 16, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VADREH.
Feb 9, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter vehicles. The gross vehicle weight rating (GVWR) may be improperly stated on the tire and loading label. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims-Other Than Passenger Cars."
Consequence & remedy
Consequence: The operator may overload the vehicle, resulting in excessive tire wear and increasing the risk of a crash.
Remedy: Dealers will inspect and replace, as necessary, the tire and loading information label. Additionally, tires will be inspected for excessive wear and replaced as necessary. All repairs will be conducted free of charge. Interim owner notifications were mailed to owners on March 4, 2022. Owner notification letters were mailed on March 21, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RE58HIN.
Dec 1, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The front axle fender liner and brake hose may be too close, allowing the fender liner to contact and damage the brake hose.
Consequence & remedy
Consequence: A damaged brake hose may leak brake fluid, extending the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Dealers will inspect the condition and clearance of the brake hose, modify the fender liner trim, and replace the brake hose as necessary, free of charge. Owner notification letters were mailed on March 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAURAVE.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The front axle fender liner and brake hose may be too close, allowing the fender liner to contact and damage the brake hose.
Consequence: A damaged brake hose may leak brake fluid, extending the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Dealers will inspect the condition and clearance of the brake hose, modify the fender liner trim, and replace the brake hose as necessary, free of charge. Owner notification letters were mailed on March 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAURAVE.
Structure:body
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The front axle fender liner and brake hose may be too close, allowing the fender liner to contact and damage the brake hose.
Consequence: A damaged brake hose may leak brake fluid, extending the distance needed to stop the vehicle and increasing the risk of a crash.
Remedy: Dealers will inspect the condition and clearance of the brake hose, modify the fender liner trim, and replace the brake hose as necessary, free of charge. Owner notification letters were mailed on March 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAURAVE.
Dec 1, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter vehicles. The spring-loaded rear step bolt fasteners were not properly tightened.
Consequence & remedy
Consequence: Loose bolt fasteners may allow the rear step to separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will tighten the bolt fasteners and replace the console and attaching hardware, free of charge. Owners notification letters were mailed February 11, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HECKTRI.
Oct 6, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter vehicles. A cable duct may drop out of place due to unlatched engagement hooks inside the battery case. This may cause the starter-generator wiring harness to chafe against the transmission carrier, which could result in an electrical short-circuit.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire.
Remedy: Dealers will replace the engagement hooks on the affected cable duct with expanding rivets, free of charge. The recall began on November 2, 2021. Owners may contact DVUSA's customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KABKAN.
Jul 7, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter, Metris, and Freightliner Sprinter vehicles equipped with Automatic Locking Retractor (ALR) seat belt assemblies. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these assemblies fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed on December 21, 2021. Owners may contact DVUSA's customer service at 1-877-762-8267.
Additional source detail variants (3)
Seat Belts:rear/other:retractor
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter, Metris, and Freightliner Sprinter vehicles equipped with Automatic Locking Retractor (ALR) seat belt assemblies. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these assemblies fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed on December 21, 2021. Owners may contact DVUSA's customer service at 1-877-762-8267.
Seat Belts:front:retractor
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter, Metris, and Freightliner Sprinter vehicles equipped with Automatic Locking Retractor (ALR) seat belt assemblies. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these assemblies fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed on December 21, 2021. Owners may contact DVUSA's customer service at 1-877-762-8267.
Seat Belts
Daimler Vans USA, LLC (DVUSA) is recalling certain 2021 Mercedes-Benz Sprinter, Metris, and Freightliner Sprinter vehicles equipped with Automatic Locking Retractor (ALR) seat belt assemblies. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these assemblies fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed on December 21, 2021. Owners may contact DVUSA's customer service at 1-877-762-8267.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence & remedy
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Additional source detail variants (2)
Air Bags:passenger Side Frontal:cushion
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Electrical System
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Additional source detail variants (2)
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Back Over Prevention:display Function
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration