The factory upgrade 21 inch spoke wheels with Pirelli P-Zero low profile tires are averaging a blow out every 800 miles. 5 flats and 2 sidewall blisters in the last 10,000 miles. Pirelli P-Zero 255/35/R21 Front and 285/30/R21 Rear are all four available for inspection if you tell me to save them before I replace them. There have…
Read full complaint
The factory upgrade 21 inch spoke wheels with Pirelli P-Zero low profile tires are averaging a blow out every 800 miles. 5 flats and 2 sidewall blisters in the last 10,000 miles. Pirelli P-Zero 255/35/R21 Front and 285/30/R21 Rear are all four available for inspection if you tell me to save them before I replace them. There have been thousands of complaints and law suits re this issue just in the last 5 years on mercedes cars with low profile tires; to Mercedes, Pirelli, through legal discovery, to enthusiasts forums, and to NHTSA My first blowout was at 30 mph hitting a 1 1/2" deep pothole full of rain water. That one blew out the front right and blistered the sideall of the right rear at once. Then one of the new replacements blew on hitting a storm drain set 1" into the pavement on the way home from the dealership. I've been driving 60 years, and never had a single pothole blowout before now. Sidewall tears release all or most of the air at once creating an extremely dangerous situation. Somebody will lose control and hurt or kill someone, or behurt while stopped in an unsafe spot. Since the car can't be towed and has no spare, it is exteremely costly and inconvenient to replace a tire. It has cost me thousands so far, and left my disabled wife and me stranded beside the highway. Car is on a flat and one and a blister on a second tire right now in driveway. Best fix is to go to a square wheel/tire fitment using 19" x 8.5" wheels with 35 offset 66.6 mm bore on all four, all season radials. To keep outside diamter the same for the computer, 255/45/R19 /AS/ XL W and with acoustic tuning or dampening to match the quiet factory tires on these cars. 20" wheels is no good, because to maintain diameter would require the same too short 35 sidewall profile on two of the tires. Staggered 19 inch wheels will work, but the square fitment allows for tire rotaion and for the carrying of a spare. Maybe make that optional for replacement recall.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2022 S 500, Maybach S 580 4MATIC, 2021-2023 S 580 4MATIC, 2022 S 680 4MATIC, and 2023 S 580e 4MATIC vehicles. The front brake hoses may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2025030007.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2024 GLE, GLS, C-Class, E-Class, S-Class, SL, GLC, CLS, AMG GT, and G-Class vehicles. Please refer to MBUSA's recall report for specific vehicle details. The fuel pump may shutdown, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power can increase the risk of a crash.
Remedy: Dealers will replace the fuel pump, free of charge. Owner notification letters were mailed on June 28, 2024. Owner notification letters will be mailed in phases, on February 23, 2024, April 19, 2024, June 28, 2024, August 9, 2024, October 1, 2024, and December 2, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of NHTSA recall number 23V-445.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2023 C-Class, E-Class, S-Class, CLS, SL, GT, GLC, GLE, GLS, and G-Class vehicles. Please refer to MBUSA's recall report for specific vehicle details. The fuel pump may shutdown, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power can increase the risk of a crash.
Remedy: Dealers will replace the fuel pump, free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2023070012.
Mercedes-Benz USA, LLC (MBUSA) is recalling one 2022 S 500 vehicle. The dashboard may be insufficiently attached, which can result in an improper front passenger air bag deployment in the event of a crash.
Consequence & remedy
Consequence: Improper deployment of an air bag can increase the risk of injury.
Remedy: Dealers will replace a portion of the dashboard, free of charge. The owner notification letter was mailed January 20, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2023010001.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022 S580Z, S500V, and S580V vehicles. The sub frame weld for the thrust arm on the rear axle carrier may have been improperly welded, causing the thrust arm to break and detach.
Consequence & remedy
Consequence: A detached thrust arm can cause a sudden loss of vehicle control, or cause the vehicle to pull to one side during emergency braking, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will inspect the sub frame weld on the rear axle carrier and replace the rear axle carrier as necessary, free of charge. Owner notification letters were mailed April 8, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for the recall is 2022030028.
Additional source detail variants (2)
Suspension:subframe/mounting Bracket
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022 S580Z, S500V, and S580V vehicles. The sub frame weld for the thrust arm on the rear axle carrier may have been improperly welded, causing the thrust arm to break and detach.
Consequence: A detached thrust arm can cause a sudden loss of vehicle control, or cause the vehicle to pull to one side during emergency braking, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will inspect the sub frame weld on the rear axle carrier and replace the rear axle carrier as necessary, free of charge. Owner notification letters were mailed April 8, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for the recall is 2022030028.
Power Train:axle Assembly
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022 S580Z, S500V, and S580V vehicles. The sub frame weld for the thrust arm on the rear axle carrier may have been improperly welded, causing the thrust arm to break and detach.
Consequence: A detached thrust arm can cause a sudden loss of vehicle control, or cause the vehicle to pull to one side during emergency braking, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicles until the remedy has been performed. Dealers will inspect the sub frame weld on the rear axle carrier and replace the rear axle carrier as necessary, free of charge. Owner notification letters were mailed April 8, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for the recall is 2022030028.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2022 C-Class, E-Class, S-Class, SL, EClass Coupe/Convertible, CLS, AMG GT 4-doors Coupe, and EQS vehicles with a heated leather steering wheel. Due to a software error in the hand detection control unit, the hands-off detection might not detect when the driver's hands are away from the steering wheel when using the Active Distance Assist DISTRONIC system.
Consequence & remedy
Consequence: Deactivated hands-off detection will prevent DISTRONIC system features from functioning, including warnings to grab the steering wheel and calling first responders as part of the Active Emergency Stop Assist, which can increase the risk of a crash or injury.
Remedy: Dealers will update the hand detection control unit software for the DISTRONIC system, free of charge. Owner notification letters were mailed May 6, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2022040010.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022 EQS450, S500, and S580 vehicles. The communication module software may restrict or disable the emergency call system (eCall).
Consequence & remedy
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting emergency services through the call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 23, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2022010006.
Additional source detail variants (2)
Electrical System:software
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022 EQS450, S500, and S580 vehicles. The communication module software may restrict or disable the emergency call system (eCall).
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting emergency services through the call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 23, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2022010006.
Communication: Auto Crash Notification
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022 EQS450, S500, and S580 vehicles. The communication module software may restrict or disable the emergency call system (eCall).
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting emergency services through the call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 23, 2022. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2022010006.
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021 S580, 2022 EQS450, EQS580, and S500 vehicles with an active and connected Mercedes me connect account. The MBUX infotainment system might allow activation of the television and internet display while driving, causing a distraction for the driver.
Consequence & remedy
Consequence: Driver distraction can increase the risk of a crash.
Remedy: MBUSA has updated their computer server to correct the issue for most vehicles, free of charge. For vehicles that were not able to be updated remotely, dealers will provide the software update, free of charge. Owner notification letters were mailed January 25, 2022. Owners may contact MBUSA customer service at 1-800-367-6372.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2022 MERCEDES-BENZ S 500 Problems, Complaints & Recalls | Skip That Year
Illustration