Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports2 fire reports3 injury reports

Lane Departure complaints

5 reports

Clear category filter

Mileage unknown · Sep 19, 2025

Electrical SystemLane Departure

Read full complaint

Vehicle: 2014 Mercedes-Benz ML350 VIN: [XXX] I have experienced repeated failures of the Blind Spot Assist / driver-assist system since purchasing this vehicle. When I first purchased the ML350 in Texas, the vehicle already showed warning messages (“Blind Spot Assist Inoperative / Pre-Safe Function Limited”). The dealer attempted repairs before delivery, but the defect persisted. After moving to New York, the problem continued. On June 26, 2023, I took the vehicle to The Automaster Mercedes-Benz in Shelburne, VT. Their diagnosis confirmed water intrusion into the blind spot radar sensors, consistent with Mercedes-Benz TSB LI54.71-P-056477. Both left and right sensors and wiring require replacement. This is a safety defect because Blind Spot Assist and Pre-Safe features are disabled without warning, increasing risk of collision when changing lanes. Many other owners have reported the same issue, and Mercedes has issued a TSB acknowledging the defect, but no recall has been provided. I request that NHTSA investigate this recurring safety problem and require Mercedes-Benz to provide coverage or a recall for affected vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11688328

170,001 miles · Jul 24, 2025

Lane Departure

Read full complaint

The contact owns a 2014 Mercedes-Benz ML350. The contact stated that upon starting the vehicle, the blind spot warning light illuminated. The contact was unable to identify if another vehicle was nearby. The vehicle was taken to an independent mechanic who determined that the blind spot detection system was inoperative. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 170,001.

NHTSA ODI #11675826

Mileage unknown · Jun 30, 2025

Electrical SystemEngineLane Departure

Read full complaint

I purchased a used Mercedes-Benz from Freehold Mitsubishi in early 2024. Within hours, serious safety issues appeared, including a check engine light, cylinder misfire, EVAP leak, traction control failure, and blind spot assist malfunction. The vehicle’s ECM and wiring harness were later found damaged due to oil leaks and electrical shorts. Despite multiple repair attempts, the vehicle was returned in worse condition and remains unsafe to drive. I am reporting these issues due to their potential risk to vehicle safety.

NHTSA ODI #11670372

Mileage unknown · Jul 24, 2021

Electrical SystemLane Departure

3 electrical related issues within a few months. 1. Blind spot and Lane Departure warning come on and off while driving. 2. Blind spot yellow light comes on the side mirrors while applying break 3. This week the turn signal periodically stop working and each time have to stop kill engine and start engine again to reset but res…

Read full complaint

NHTSA ODI #11426314

60,000 miles · May 14, 2019

Electrical SystemLane Departure

TL* THE CONTACT OWNS A 2014 MERCEDES-BENZ ML350. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE LANE ASSIST FEATURE FAILED. THE LANE ASSIST INOPERABLE WARNING LIGHT ILLUMINATED. THE FAILURE HAPPENED INTERMITTENTLY. MERCEDES-BENZ OF NOVI (39500 GRAND RIVER AVE, NOVI, MI 48375 (248) 426-9600) DIAGNOSED AND REPAIRED TH…

Read full complaint

NHTSA ODI #11207568

Official recalls

22V955000 · Fuel System, Diesel:delivery:fuel Pump:control/drive Module; Fuel System, Gasoline:delivery:fuel Pump:control/drive Module

Dec 23, 2022

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML550, 2012-2015 ML350, AMG ML63, 2015 ML250, ML400, 2016 GLE450, GLE300, 2016-2018 GLE350, GLE550, 2016-2019 GLE400, 2017-2019 AMG GLE43, and 2016-2020 AMG GLE63 vehicles. Water might accumulate in the spare tire wheel well and damage the fuel pump control unit, which could cause an engine stall while driving.

Consequence & remedy

Consequence: An engine stall while driving increases the risk of a crash.

Remedy: Dealers will install a water drain plug, inspect for water intrusion, and replace the fuel pump control unit as necessary, free of charge. Owner notification letters were mailed February 15, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2023010002 and 2023010003.

Additional source detail variants (2)

Fuel System, Gasoline:delivery:fuel Pump:control/drive Module

Consequence: An engine stall while driving increases the risk of a crash.

Remedy: Dealers will install a water drain plug, inspect for water intrusion, and replace the fuel pump control unit as necessary, free of charge. Owner notification letters were mailed February 15, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2023010002 and 2023010003.

Fuel System, Diesel:delivery:fuel Pump:control/drive Module

Consequence: An engine stall while driving increases the risk of a crash.

19V787000 · Communication

Nov 1, 2019

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2013-2017 vehicles due to a software fault that may cause the date and time for the emergency call system (eCall) to differ from the actual date and time, potentially relaying an inaccurate vehicle location. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V787-4620.pdf

Consequence & remedy

Consequence: An inaccurate vehicle location may delay emergency responders, increasing the risk of injury.

Remedy: MBUSA has initiated an Over the Air (OTA) remote update. MBUSA will also notify owners, and dealers will check software for a successful OTA or update the communication module software as needed, free of charge. The recall began December 23, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2019120008.

18V272000 · Suspension:front

Apr 27, 2018

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML350 Bluetec 4Matic and ML550 4Matic, 2012-2015 ML63 AMG 4Matic and ML350 4Matic, 2013-2016 GL350 Bluetec 4Matic, GL550 4Matic and GL63 AMG 4Matic, 2017 GLS350d 4Matic, GLS450 4Matic, GLS550 4Matic and GLS63 AMG 4Matic, 2015 ML400 4Matic, 2016 GLE400 4Matic, GLE350 4Matic, GLE63 AMG 4Matic, GLE63S AMG 4Matic, GLE450 4Matic Coupe and GLE63S AMG 4Matic Coupe, 2015-2016 GL450 4Matic and 2013-2014 GL450 4Matic vehicles equipped with the Active Curve System (ACS). In certain driving conditions, if the oil level in the ACS reservoir is below the minimum level, the oil may foam and leak out of the vent holes in the reservoir cap.

Consequence & remedy

Consequence: The leaking oil in the presence of an ignition source can increase the risk of a fire.

Remedy: MBUSA will notify owners, and dealers will correct the oil level as necessary and replace the reservoir sealing cap to prevent oil foam from leaking out, free of charge. The recall began August 30, 2018. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2018070015.

17V177000 · Air Bags:frontal:sensor/control MODULE-INACTIVE ; Electrical System:software

Mar 14, 2017

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 AMG GT-S, GLC300, CLA250 and GLE300d 4Matic vehicles, 2013 C250, E350 BlueTec and G63 AMG vehicles, 2008-2014 C300 vehicles, 2013-2014 C300 4Matic and ML350 4Matic vehicles, 2009 C350 vehicles, 2014 CLS550, E350 4Matic, E350 Coupe 4Matic, E350 Wagon 4Matic, GLK350 and SL550 vehicles, 2012 CLS550 4Matic vehicles, 2012-2016 E350 vehicles, 2016-2017 GL450 4Matic vehicles, 2012-2014 ML350 4Matic BlueTec vehicles, 2015 S550, S550 4Matic and C300 4Matic Sedan vehicles, 2015-2016 C300 Sedan vehicles, and 2017 SL63 AMG vehicles. Various control units on these vehicles may have been updated with incorrect software, potentially affecting the correct deployment of the air bags in the event of a crash.

Consequence & remedy

Consequence: If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.

Remedy: MBUSA will notify owners, and dealers will update software in the affected control units, free of charge. The recall began April 21, 2017. Owners may contact MBUSA customer service at 1-800-367-6372.

Additional source detail variants (2)

Electrical System:software

Consequence: If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.

Remedy: MBUSA will notify owners, and dealers will update software in the affected control units, free of charge. The recall began April 21, 2017. Owners may contact MBUSA customer service at 1-800-367-6372.

Air Bags:frontal:sensor/control MODULE-INACTIVE

Consequence: If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.