Air Bags. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports2 fire reports1 injury reports

Fuel/propulsion System complaints

20 reports

Clear category filter

Mileage unknown · Feb 28, 2026

Fuel/propulsion System

Read full complaint

I noticed fuel / gas smell from my vehicle. I looked up cause for this type of occurrence. I was referred to a recall bulletin for this particular cause - Recall Campaign #2013020002. My vehicle (VIN #) is not on the recall list. Both MB dealerships in my area state I would have to cover the cost to replace the Fuel Filter Flange. I am certain the Fuel Filter Flange is defective and should be listed in the recall. I pulled up the rear seat and removed the cover to expose the Fuel Filter Flange. There was gasoline on top of the Fuel Filter Flange. (I have documented with pictures).

NHTSA ODI #11721172

Mileage unknown · Aug 9, 2024

Fuel/propulsion System

After a fuel fill-up, I smell fuel inside the cabin and outside by the gas tank opening. This causes a constant stress..., what if there is a fire? I heard and read so many similar complains and concerns. This should constitute for a RECALL. What is the responsibility of NHTSA to the consumer's safety.

NHTSA ODI #11607580

Mileage unknown · Aug 8, 2024

Fuel/propulsion System

Read full complaint

When we fill up the SUV with gas, there is a very strong odor of gas outside of the passenger door & some odor "inside the SUV. We looked online Motortrend.com said Certain 2011-2012 MB CLK 350 4matic are being recalled for a potential fuel leak caused by a crack in the fuel filter flange, Dec 15, 2012.' We stopped by MBenz of Lynnwood, Wa and spoke Garrett, a service rep. Garrett said that this was not a safety issue and we can continue to safely drive the SUV. We disagreed! We are very concerned because we believe there is a safety issue, our SUV has a crack fuel line could catch on fire while we are driving and potentially anyone around us could be affected. We did not get a malfunction or error message.

NHTSA ODI #11607422

Mileage unknown · Jun 21, 2024

Fuel/propulsion System

Vaporized gasoline fuel odor emanating from the back seat area due to fuel filter flange crack

NHTSA ODI #11595654

Mileage unknown · Jun 29, 2023

Fuel/propulsion System

Read full complaint

I noticed the smell of fuel coming from my vehicle, specifically when I top off at the gas station. This is dangerous as fuel can combust if ignited. I took the vehicle to be service, to find out about the fuel odor and was advised of the NHTSA recall. Upon researching I see that although the NHTSA recall #12V557000 specifically covers this issue, when entering my VIN, the recall does not appear for MY specific vehicle, which is a 2011 GLK-350. It appears there are several affected vehicles not included in the recall. This is a failure on behalf of Mercedes Benz as it is simple to conclude that the issue includes more vehicles than initially recalled. These vehicles need to be included as well.

NHTSA ODI #11529496

Mileage unknown · Mar 21, 2023

EngineFuel/propulsion System

Read full complaint

I'm having the same issues as described in Recall no. 12V557000. However when I called Mercedes they mentioned that my Vin wasn't part of that recall. I don't understand how can that be when my car is 2011-2012 glk350 model as described in recall and I smell gas, can see gas leaking and the flange where my fuel filter is cracked as well as the flange to the fuel pump side. This car as well as many other Mercedes have two separate flanges that are prone to crack and not just the fuel filter side but the fuel pump side as well. there's many forums where they all have complained about this issue. If you can smell gas, there's obviously fuel vapors leaking and not to the mentioned the physical leak that is landing everywhere you drive. This is a serious fire hazard and is extremely harmful to my kids and passengers.

NHTSA ODI #11513030

Mileage unknown · Jan 3, 2023

Fuel/propulsion System

Read full complaint

Fuel/Propulsion System - There is a gas leaking from somewhere above the gas tank. I did not have this fixed yet because I see a recall for this but my VIN wasn't included in the initial recall. There are 17 other complaints on here for the same issue but we haven't been included in the recall as of today 1/2/2023. The recall that fixed other 2011 GLK 350s is NHTSA CAMPAIGN NUMBER: 12V557000 (FUEL SYSTEM, GASOLINE). My car is available for inspection upon request. I am very afraid of a fire because the tray underneath the car on the passenger side is full of gas & the tray is right over the exhaust. I stuck a large cotton swab in the tray to soak up the liquid & since it smelled like gas I tried to light it. It caught on fire immediately. This is definitely a safety hazard as it can ignite if a spark or lit cigarette would happen to bounce up in there. Yes it is unlikely but I have seen stranger things. The tray holds a large amount of gas and is directly under the gas tank. The check engine light came on and the diagnostic machine says fuel evap control system leak. A mechanic looked at the leak after taking the rear passenger tire off and finding the gas pooling in that tray. Odometer reads 145,000.

NHTSA ODI #11499874

Mileage unknown · Aug 16, 2022

Fuel/propulsion System

The fuel tank flange cracked. After refill the tank, the fuel smell is in the cabin, and fuel leak out under the seat.

NHTSA ODI #11479512

Mileage unknown · Apr 28, 2022

Fuel/propulsion System

Fuel leaking from top of the fuel tank.

NHTSA ODI #11462608

Mileage unknown · Dec 8, 2021

Fuel/propulsion System

BECAUSE OF THE LOW QUALITY OF THE PLASTIC, WHICH WAS USED IN THE FUEL PUMP BODY ON MY GLK350, FORMED A CRACK ON BOTH BODIES OF THE FUEL TANKS. FUEL IS COMING OUT DIRECTLY UNDER THE REAR SEAT AND DRIPPING DOWN TO THE ROAD. THIS IS A SAFETY HAZARD, AND COULD CAUSE A POSSIBILITY OF FIRE.

NHTSA ODI #11443176

Official recalls

19V010000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2019

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2014 C250, C300 4Matic, C350, C63 AMG, E350 4Matic Coupe, E350 Cabrio, E350 Coupe, SLS AMG Cabrio, SLS AMG Coupe, 2014-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, GLK 350, GLK250 BlueTec 4Matic, GLK350 RWD, 2015-2017 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2014-2017 E550 Cabrio, and 2014-2016 E550 Coupe vehicles sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally, MBUSA is recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio, 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2011 C300, 2011-2014 C300 4Matic, C350, C63 AMG, E350 Cabrio, E350 Coupe, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2011-2016 E550 Cabrio, E550 Coupe, 2011-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." MBUSA is also recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2010-2011 C300, 2010-2014 C300 4Matic, C350, C63 AMG, E350 Coupe, 2011-2014 E350 Cabrio, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2016-2017 E550 Cabrio, 2010-2016 E550 Coupe, 2010-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MO, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the passenger or other occupants resulting in serious injury or death.

Remedy: MBUSA will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 29, 2019. Owners may contact MBUSA customer service at 1-800-367-6372.

16V363000 · Air Bags:frontal:passenger Side:inflator Module

May 26, 2016

Mercedes-Benz USA, LLC (MBUSA) is recalling certain model year 2008-2011 C300 Sedan, C300 4matic Sedan, C350 Sedan, C63 AMG Sedan vehicles, 2010-2011 GLK350, GLK350 4-Matic and E350 Coupe vehicles, 2011 SLS AMG, E350 Convertible, E550 Coupe and E550 Convertible vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, MBUSA is recalling certain model year 2008 C300 Sedan, C350 Sedan, C63 AMG Sedan and C300 4-Matic Sedan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: MBUSA will notify owners, and dealers will replace the passenger frontal air bag modules, free of charge. Owners were sent an interim notification October 2016. A second notice will be mailed when remedy parts are available. Owners may contact MBUSA customer service at 1-877-496-3691.

16V081000 · Air Bags:frontal:driver Side:inflator Module

Feb 11, 2016

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain model year 2009-2010 ML320 BlueTec 4Matic, GL320 BlueTec 4Matic and R320 CDI 4Matic, 2011 E350 Cabriolet and E550 Cabriolet, 2009-2011 ML350, ML350 4Matic, ML550 4Matic, ML63 AMG, and C63 AMG, 2010-2011 ML450 4Matic Hybrid, E350 Coupe, E350 4Matic, E550 Coupe, E550 4Matic, and E63 AMG, 2011-2012 GL350 BlueTec 4Matic and R350 BlueTec 4Matic, 2009-2012 GL450 4Matic, GL550 4Matic and R350 4Matic, 2007-2008 SLK280, SLK350, and SLK55 AMG, 2011-2014 SLS AMG Coupe, 2012 SLS AMG Cabriolet, 2013-2014 SLS AMG GT and SLS AMG GT Cabriolet, 2005 C230 Kompressor and C320, 2006-2007 C230, 2006-2011 C350, 2008-2011 C300 and C300 4Matic, 2010-2012 GLK350 and GLK350 4Matic and 2007-2008 Chrysler Crossfire vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: MBUSA will their notify owners, and Fiat Chrysler will notify the affected Chrysler owners. Dealers for the respective brands will replace the driver's frontal air bag module, free of charge. This recall began November 2016. Mercedes-Benz owners may contact MBUSA customer service at 1-800-367-6372 and Chrysler owners may contact Fiat Chrysler customer service at 1-800-853-1403.

12V557000 · Fuel System, Gasoline

Dec 3, 2012

Mercedes-Benz is recalling certain model year 2011-2012 S400, S550, S550 4Matic, S63 AMG, C300, C300 4Matic, E350, GLK350, GLK350 4Matic, CL550 4Matic, and CL63 AMG vehicles manufactured from April 18, 2011, through July 12, 2011. Due to an irregularity stemming from the molding process of the fuel filter flange, the fuel filter flange may crack when operated in high temperatures.

Consequence & remedy

Consequence: If the fuel filter flange cracks, it will leak fuel which may lead to a fire if an external ignition source is present.

Remedy: Mercedes-Benz will notify owners, and dealers will replace the fuel filter, free of charge. The recall campaign is expected to begin in February 2013. Owners may contact Mercedes-Benz at 1-800-367-6372.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Air Bags:frontal:passenger Side:inflator Module