IllustrationCHECK ENGINE LIGHT CAME ON HAD VEHICLE CHECKED THROUGHLY DISCOVERED FUEL SENDING UNIT/TANK PROBLEM.
2006 MERCEDES-BENZ E350
Owner reports · Recalls · Investigations
More warning signs than most E350 years
Owner complaints for the 2006 MERCEDES-BENZ E350 are substantially higher than the model-year median of 161.
About this comparison →How this year compares
Owner complaints by model year
Compare all E350 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
4325–50K
6950–75K
6975–100K
101100–150K
35150K+
333 reports with mileage · 65 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports9 fire reports11 injury reports
Fuel/propulsion System complaints
144 reportsI AM A DISABLED VETERAN AND ON APRIL 30, 2015 MY CAR SMELLED LIKE GAS. MERCEDES BENZ USA SAID TO TAKE IT TO NEAREST DEALER ATLANTA CLASSIC CARS IN GWINNETT COUNTY, GA. THE PROBLEM: LEAKING FUEL TANK, IT TOOK 120 DAYS TO REPLACE THE TANK. THE CAR STILL SMELLS LIKE GAS, THE DEALERSHIP RECOMMENDED REPLACE THE SEAT CUSHIONS, AND …
Read full complaint
I AM A DISABLED VETERAN AND ON APRIL 30, 2015 MY CAR SMELLED LIKE GAS. MERCEDES BENZ USA SAID TO TAKE IT TO NEAREST DEALER ATLANTA CLASSIC CARS IN GWINNETT COUNTY, GA. THE PROBLEM: LEAKING FUEL TANK, IT TOOK 120 DAYS TO REPLACE THE TANK. THE CAR STILL SMELLS LIKE GAS, THE DEALERSHIP RECOMMENDED REPLACE THE SEAT CUSHIONS, AND THE FELT. BOTH ARE WET FROM GAS, AND HAS GAS VAPORS ON IT. THE TECHNICIAN SHOWED ME HOW TO LIFT UP THE SEATS, AND I TOOK PICTURES OF THE WET SEAT CUSHIONS, AND THE WET FELT. THE DEALERSHIP WANTS TO CHARGE ME $565.00. MY COMPLAINT IS THAT I SHOULD NOT HAVE TO PAY FOR A PROBLEM THAT I DID NOT CAUSE; THIS WAS CAUSED BY A LEAKING FUEL TANK. MY THROAT BURNS FROM THE GAS SMELLS, MY EYES WATER, AND I'M GETTING HEADACHES. PART OF MY DISABILITY IS ASTHMA AND THE FUMES IN THIS CAR EXACERBATES THE ASTHMA. I CALLED MERCEDES BENZ USA AND THEY SAID UNFORTUNATELY THEY COVERED JUST THE PART! THIS IS HORRIBLE, AND DANGEROUS TO RIDE AROUND WITH WET SEAT CUSHIONS WITH GAS ON THEM. I CANT BELIEVE MERCEDES IS NOT STANDING BEHIND THEIR PRODUCT. THIS IS A FIRETRAP AND THEY SHOULD BE RESPONSIBLE FOR REPLACING THE SEAT CUSHIONS AND FELT AT NO COST TO ME THE CONSUMER!
AFTER FILLING UP THE CAR WITH GASOLINE, I CAN SMELL THE DISTINCT ODOR OF GASOLINE FROM OUTSIDE THE VEHICLE AROUND THE REAR PASSENGER DOOR AREA (DRIVER'S SIDE). I BELIEVE THAT FUEL IS LEAKING FROM THE FUEL FILTER SENDER UNIT, WHICH IS LOCATED UNDER THE BACKSEAT. A NEW STORY SHOWING THE PROBLEM IS HERE: HTTP://WWW.WSBTV.COM/NEWS…
Read full complaint
AFTER FILLING UP THE CAR WITH GASOLINE, I CAN SMELL THE DISTINCT ODOR OF GASOLINE FROM OUTSIDE THE VEHICLE AROUND THE REAR PASSENGER DOOR AREA (DRIVER'S SIDE). I BELIEVE THAT FUEL IS LEAKING FROM THE FUEL FILTER SENDER UNIT, WHICH IS LOCATED UNDER THE BACKSEAT. A NEW STORY SHOWING THE PROBLEM IS HERE: HTTP://WWW.WSBTV.COM/NEWS/NEWS/LOCAL/MERCEDES-OWNERS-FIND-GASOLINE-POOLING-BACKSEAT/NDBZM/. MERCEDES IS REPLACING THESE COMPONENTS AS DESCRIBED IN NHTSA ACTION NUMBER : EA13003. I WENT TO A MERCEDES DEALERSHIP (DOWNTOWN LOS ANGELES MOTORS) AND SHOWED THE SERVICE CONSULTANT A PRINT OUT OF NHTSA ACTION NUMBER : EA13003. HE EXPLAINED THAT MY VEHICLE IS NOT COVERED BY THIS ACTION NUMBER. I CALLED MERCEDES CORPORATE AND WAS TOLD THAT MY VEHICLE IS NOT COVERED. I BELIEVE THAT MY VEHICLE HAS THE SAME SENDER UNIT THAT IS DESCRIBED IN NHTSA ACTION NUMBER : EA13003, SO I DO NOT UNDERSTAND WHY MERCEDES IS CLAIMING MY VEHICLE IS EXEMPT FROM THIS IMPORTANT SAFETY FIX. I WOULD LIKE MERCEDES TO REPLACE THE SENDER UNIT AND ANY COMPONENTS THAT ARE LEAKING GASOLINE.
THE E350 MERCEDES BENZ HAS A DEFECTED SEAL GASKET ON THE TOP OF THE GAS TANK AND WHEN THE TANK IS FILLED, FUMES AND GAS WILL EXIT THIS OPENING IN THE FUEL TANK. THE FUMES ARE VERY STRONG WHEN PARKED IN THE GARAGE AND MERCEDES BENZ HAS ACKNOWLEDGED THIS DEFECT IN THEIR TANKS AND THE SUIT HAS BEEN SETTLED. THE BENZ DEALERS WILL …
Read full complaint
THE E350 MERCEDES BENZ HAS A DEFECTED SEAL GASKET ON THE TOP OF THE GAS TANK AND WHEN THE TANK IS FILLED, FUMES AND GAS WILL EXIT THIS OPENING IN THE FUEL TANK. THE FUMES ARE VERY STRONG WHEN PARKED IN THE GARAGE AND MERCEDES BENZ HAS ACKNOWLEDGED THIS DEFECT IN THEIR TANKS AND THE SUIT HAS BEEN SETTLED. THE BENZ DEALERS WILL NOT HONOR THE REPAIRS BECAUSE IT IS NOT VIN SPECIFIC AND STATES THE MY VEHICLE IS NOT COVERED. THE MERCEDES BENZ HAS EXTENDED THE WARRANTY ON THESE VEHICLES FOR THIS PURPOSE AND IT STATES THESE DETAILS IN THEIR LETTER TO ALL BENZ OWNERS. THE LETTER STATES ALL YEARS 2004 TO 2009 E350 VEHICLES BUT DOES NOT GIVE VIN DETAILS. PLEASE ADVISE WHAT MY NEXT STEP WILL BE. THE NHTSA ACTION NUMBER : EA13003 WHICH EXPLAINS IN DETAILS WHAT THIS VEHICLE DEFECT IS AND HOW MERCEDES BENZ WILL REPAIR AS AN EXTENSION OF WARRANTY.
AS PER YOUR WEBSITE YOU CLOSED THIS INVESTIGATION ON THE BASIS OF MERCEDES NOTIFYING YOU THAT IT WILL EXTEND THE ORIGINAL WARRANTY COVERAGE ON COVERED FUEL TANK COMPONENTS IN E CLASS VEHICLES IN MY 2003-2009. HOWEVER WHEN I REACHED OUT TO MB-USA THEY INFORMED ME THAT MY VEHICLE WAS NOT COVERED UNDER THIS WARRANTY, WHICH SEEMS T…
Read full complaint
AS PER YOUR WEBSITE YOU CLOSED THIS INVESTIGATION ON THE BASIS OF MERCEDES NOTIFYING YOU THAT IT WILL EXTEND THE ORIGINAL WARRANTY COVERAGE ON COVERED FUEL TANK COMPONENTS IN E CLASS VEHICLES IN MY 2003-2009. HOWEVER WHEN I REACHED OUT TO MB-USA THEY INFORMED ME THAT MY VEHICLE WAS NOT COVERED UNDER THIS WARRANTY, WHICH SEEMS TO CONTRARY TO WHAT YOU HAVE PUBLISHED ON YOUR WEBSITE. CAN YOU PLEASE LET ME KNOW IF THIS IS CORRECT. THANKS. *TR
THERE IS A SERIOUS SAFETY ISSUE WITH 2006 MERCEDES-BENZ E CLASS (MBEC) BECAUSE OF A MANUFACTURER'S AND/OR DESIGN DEFECT WHICH CAUSES THIS VEHICLE TO NOT GO INTO PROPER GEAR AND/OR STALL SUDDENLY PUTTING THE PUBLIC AT RISK. I BARELY ESCAPED BEING SMASHED INTO BY ONCOMING TRAFFIC WHILE MAKING A ROUTINE LEFT HAND TURN INTO A GAS S…
Read full complaint
THERE IS A SERIOUS SAFETY ISSUE WITH 2006 MERCEDES-BENZ E CLASS (MBEC) BECAUSE OF A MANUFACTURER'S AND/OR DESIGN DEFECT WHICH CAUSES THIS VEHICLE TO NOT GO INTO PROPER GEAR AND/OR STALL SUDDENLY PUTTING THE PUBLIC AT RISK. I BARELY ESCAPED BEING SMASHED INTO BY ONCOMING TRAFFIC WHILE MAKING A ROUTINE LEFT HAND TURN INTO A GAS STATION BECAUSE MY MBEC WAS STUCK IN GEAR AND DID NOT ACCELERATE AS IT WAS MANUFACTURED AND DESIGNED TO DO BUT RATHER SPUTTERED AT LESS THAN 5 MILES PER HOUR (MPH). THE ONLY REASON I WAS NOT T-BONED AND LIKELY SERIOUSLY INJURED ALONG WITH OTHER PEOPLE WAS BECAUSE THE OTHER DRIVERS SWERVED INTO ONCOMING TRAFFIC CAUSING THOSE DRIVERS TO ALSO SWERVE. MIRACULOUSLY NO ONE WAS INJURED, THIS TIME. ALSO, THE REASON WHY I WAS TURNING INTO THE GAS STATION WAS BECAUSE I WAS FORCED TO GET OFF THE HIGHWAY BECAUSE MY MBEC WOULD NOT CHANGE GEAR AFTER I GOT ON THE HIGHWAY AND WAS APPROACHING RED-LINING AT AND IT SEEMED LIKE THE ENGINE MIGHT BLOW. THE TIPTRONIC ALSO FAILED DURING THIS MALFUNCTION. I HAD THE AUTHORIZED MB DEALER THAT I HAVE USED SINCE I PURCHASED MY MBEC PICKUP MY VEHICLE TO LOOK INTO THIS ISSUE AND MY ADVISOR TOLD ME I NEEDED A NEW BALANCE SHAFT BECAUSE THE ONE IN MY VEHICLE HAD PREMATURELY WORN (EVEN THOUGH I HAVE ALWAYS STRINGENTLY FOLLOWED MY MB ADVISOR'S SUGGESTIONS) AND IT WOULD COST ROUGHLY $6,500. S/HE ALSO SAID THIS OCCURS IN ROUGHLY 15-20% OF '06 MBEC. BUT MB WOULD NOT FIX THIS SAFETY DEFECT UNLESS I PAID. WORSE YET, MY ADVISOR NEVER MADE ME AWARE OF THIS SERIOUS SAFETY ISSUE EVEN THOUGH S/HE PREVIOUSLY KNEW OR SHOULD HAVE KNOWN AND AS A RESULT PUT THE PUBLIC AT RISK BY NOT ENABLING ME TO RESOLVE THIS SERIOUS SAFETY ISSUE WITH MY MODEL YEAR VEHICLE UNTIL THE OCCURRENCE OF A NEAR CATASTROPHE. THERE SHOULD BE A SAFETY RECALL NOW THAT THIS SAFETY DEFECT HAS COME TO LIGHT AND UNLESS THERE IS, THE PUBLIC WILL REMAIN AT SERIOUS RISK. *TR
AFTER FILLING GAS AT THE SHELL GAS STATION I GOT ON TO THE 101 FREEWAY AND SUDDENLY THE INSIDES OF THE VEHICLE STARTED SMELLING GASOLINE, IT WAS SO BAD THAT I HAD TO OPEN THE WINDOWS AND PULL OVER. I FELT LIKE I WILL PASS OUT BECAUSE OF THE INTENSITY OF THE SMELL. *TR
STRONG ODOR OF GASOLINE FUEL INSIDE AND OUTSIDE OF THE VEHICLE AFTER REFILLING THE TANK. ODOR WENT AWAY AFTER DRIVING SOME DISTANCE THEREBY LOWERING THE FUEL LEVEL IN THE TANK. M-B OF TAMPA AND MB OF USA REFUSED TO MAKE WARRANTY REPAIR FUEL LEAKAGE PROBLEM DUE MY PZEV VEHICLE (WITH OPTION 917) WAS SOLD IN FLORIDA (NOT IN 10 STAT…
Read full complaint
STRONG ODOR OF GASOLINE FUEL INSIDE AND OUTSIDE OF THE VEHICLE AFTER REFILLING THE TANK. ODOR WENT AWAY AFTER DRIVING SOME DISTANCE THEREBY LOWERING THE FUEL LEVEL IN THE TANK. M-B OF TAMPA AND MB OF USA REFUSED TO MAKE WARRANTY REPAIR FUEL LEAKAGE PROBLEM DUE MY PZEV VEHICLE (WITH OPTION 917) WAS SOLD IN FLORIDA (NOT IN 10 STATES WHICH HAVE "0 EMISSION REQUIREMENTS"). AS PER SUMMARY OF O.D.I. "IN LETTER DATED SEPTEMBER 4, 2014, MERCEDES HAS NOTIFIED AGENCY (ODI NHTSA) THAT IT WILL EXTEND THE ORIGINAL WARRANTY COVERAGE TO 15 YEARS AND UNLIMITED MILEAGE ON "COVERED FUEL TANK COMPONENTS" IN E-CLASS VEHICLES IN MY 2003-2009 AND CLS-CLASS VEHICLES IN MY 2006-2011." LOOKS-LIKE MERCEDES DROPPED OUT OF THE GENERAL LIST OF THE MY 2003 THROUGH 2009 E-CLASS ALL PZEV VEHICLES (WITH OPTION 917) MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES, BUT SOLD TO CUSTOMERS BY M-B OFFICIAL DEALERS IN THE STATES, WHICH DO NOT HAVE "0-EMISSION" REQUIREMENTS. *TR
I WAS FIRST OWNER OF THIS BENZ 2006 E350. IT WAS NEVER INVOLVED IN ANY ACCIDENT. I TYPICALLY PARKED THE CAR OUTSIDE GARAGE. HOWEVER, AFTER I MOVED THE CAR INSIDE MY GARAGE A FEW DAYS AGO, I SMELLED GAS. SO I LIFTED UP 2ND ROW SEAT, UNCOVERED THE COVERING-PIECE ON DRIVER'S SIDE, I SAW FUEL DELIVERY SYSTEM WITH TWO CONNECTORS,…
Read full complaint
I WAS FIRST OWNER OF THIS BENZ 2006 E350. IT WAS NEVER INVOLVED IN ANY ACCIDENT. I TYPICALLY PARKED THE CAR OUTSIDE GARAGE. HOWEVER, AFTER I MOVED THE CAR INSIDE MY GARAGE A FEW DAYS AGO, I SMELLED GAS. SO I LIFTED UP 2ND ROW SEAT, UNCOVERED THE COVERING-PIECE ON DRIVER'S SIDE, I SAW FUEL DELIVERY SYSTEM WITH TWO CONNECTORS, ONE FOR SENSOR AND ONE FOR POWER SUPPLY. I SAW THE AREA AROUND POWER CONNECTOR IS WET. IT SMELLS GAS. OBVIOUSLY, THE GAS LEAK WAS FROM THE TOP OF FUEL DELIVERY SYSTEM (OR TOP OF THE FUEL FILTER HOUSING). I'M GLAD I DID THIS INVESTIGATION TONIGHT. I PLAN TO SEE A BENZ DEALER TOMORROW IN LAGUNA NIGUEL, CA, WHERE THE DEALER TOLD ME IT IS NOT COVERED UNDER WARRANTY, EVEN AFTER I HOLD HIM THAT MY E350 IS UNDER BENZ 2006 - PZEV 15 YEARS OR 150,000 MI EMISSION RELATED WARRANTY. *TR
TL* THE CONTACT OWNS A 2006 MERCEDES BENZ E350. UPON REFUELING THE VEHICLE, THERE WAS A STRONG SMELL OF FUEL OUTSIDE AND INSIDE THE VEHICLE. WHEN THE VEHICLE WAS PARKED, THE STRONG FUMES WERE EXTREME. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FUEL SENDING UNIT WAS LEAKING AND NEEDED TO BE REPLACED. T…
Read full complaint
TL* THE CONTACT OWNS A 2006 MERCEDES BENZ E350. UPON REFUELING THE VEHICLE, THERE WAS A STRONG SMELL OF FUEL OUTSIDE AND INSIDE THE VEHICLE. WHEN THE VEHICLE WAS PARKED, THE STRONG FUMES WERE EXTREME. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FUEL SENDING UNIT WAS LEAKING AND NEEDED TO BE REPLACED. THE DEALER WAS NOT ABLE TO DETERMINE THE LOCATION OR THE SOURCE OF THE LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Official recalls
424V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
21V196000 · Visibility:sun/moon Roof Assembly
Mar 19, 2021
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2007 C350, C230, C280, CLK350, E320CDI, E350 Wagon, E350, 2006 C55 AMG, CLK500, CLS500, CLS55 AMG, E500 Wagon, E500, E55 AMG, 2007 CLK550, CLS550, CLS63 AMG, E550, E63 AMG, and E63 Wagon AMG vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly causing the glass panel to detach from the vehicle.
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. Owner letters were mailed May 7, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall number 19V-918. MBUSA's number for this recall is 2021040012.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
PE10017 · Driver Air Bag Circuit High Resistance
Opened May 14, 2010 · Closed Nov 24, 2010
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Additional source detail variants (5)
Air Bags:frontal
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Air Bags
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.