IllustrationEXTREME SMELL OF FUEL WHEN MAKING SHARP OR EXTENDED TURNS (FREEWAY ON/OFF RAMPS). ESPECIALLY, WHEN FULL TANK IS FULL. CALLED LOCAL DEALER AND MBUSA WAS TOLD THIS IS NOT COVERED UNDER THE 15 YEAR ' FUEL LEAK' EXTENDED WARRANTY! PLEASE NOTE THE PUDDLING OF FUEL NEAR THE BOTTOM OF WIRE HARNESS IN PICTURE ATTACHED.
2006 MERCEDES-BENZ E350
Owner reports · Recalls · Investigations
More warning signs than most E350 years
Owner complaints for the 2006 MERCEDES-BENZ E350 are substantially higher than the model-year median of 161.
About this comparison →How this year compares
Owner complaints by model year
Compare all E350 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
4325–50K
6950–75K
6975–100K
101100–150K
35150K+
333 reports with mileage · 65 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports9 fire reports11 injury reports
Fuel/propulsion System complaints
144 reportsTHIS VEHICLE IS A THREAT TO MY HEALTH WITH ALL THE PROBLEMS I'M HAVING WITH IT. I HAVE TO PRESS EXTRA HAD TO STOP . HAD BRAKES CHECKED AND THERE WAS NO PROBLEM. THERE IS A BAD GASOLINE LEAK AND LOUD SMELL OF GAS WHEN I FILL UP. LOOKED UNDER REAR SEAT AND SAW GAS ON GAS TANK. DRIED GAS UP AND THE BIG PUDDLE RETURNED. CAN I DRIVE …
Read full complaint
THIS VEHICLE IS A THREAT TO MY HEALTH WITH ALL THE PROBLEMS I'M HAVING WITH IT. I HAVE TO PRESS EXTRA HAD TO STOP . HAD BRAKES CHECKED AND THERE WAS NO PROBLEM. THERE IS A BAD GASOLINE LEAK AND LOUD SMELL OF GAS WHEN I FILL UP. LOOKED UNDER REAR SEAT AND SAW GAS ON GAS TANK. DRIED GAS UP AND THE BIG PUDDLE RETURNED. CAN I DRIVE THIS CAR? I NEED SOMEONE TO TELL ME WHAT TO DO. THE LAST AND MOST WORRISOME THING TO ME IS THAT THERE ARE 2 DTC CODES COMING UP CAUSING THE CHECK ENGINE LIGHT TO COME ON. HAD MECHANIC TO CLEAR THEN BUT THEY COME RIGHT BACK WHEN CAR IS STARTED. I NEED TO GET THIS CAR INSPECTED. SOMEONE TELL ME WHAT TO DO. MECHANIC SAID THAT THE CODE INDICATE A PROBLEM WITH THE ENGINE AND THAT IT MIGHT TAKE $8700 TO REPAIR EVERY THING. I DONT HAVE THAT TYPE OF MONEY. THIS IS THE CAR MAKERS PROBLEM. WHO IS LOOKING OUT FOR ME. IS THE GOVERMENT DOING THERE JOB WHEN IT COMES TO THIS CAR. HEARD THERE ARE MORE CARS LIKE THIS. OH THIS IS A 2006 MERCEDES E350. WILL THE GOVERMENT, DEALER OR MANUFACTURER BUY THIS CAR FROM ME. THIS IS A PLEA FOR HELP FROM ANYWHERE. THEY SAY THERE IS A RECALL ON THIS CAR BUT WHEN IT CAME OUT THERE WAS 1 YEAR LEFT ON CAR WARRANTY BEFORE IT RAN OUT. THE CAR DIDN'T QUIT RUNNING WHEN THE STALLING TO REPAIR THESE CARS TOOK PLACE. SOME ONE IS IN SOMEONES BACK POCKET. SOMEONE NEEDS TO DO THEIR JOB AND GET THIS PROBLEM TAKEN CARE OF ONCE AND FOR ALL. YOU MAY LOSE SOME FRIENDS IN THE PROCESS BUT THIS IS BETTER THAN SOMEONE LOSING THEIR LIFE. THIS VEHICLE HAS HAAD PROBLEMS STATIONARY AND WHILE MOVING.
CAR HAD QUARTER TANK WHEN BOUGHT. DROVE OUT GAS AND PUT ABOUT ANOTHER QUARTER TANK OF GAS IN. DROVE THIS OUT. SMELLED NO FUMES. FILLED TANK UP. HAVE SMELLED LOUD GAS SMELL FOR 1 WEEK NOW.
REGARDLESS OF VEHICLE MOVEMENT GAS LEAK FROM FUEL TANK LOCATED UNDER BACK SEAT ABOVE EXHAUST SYSTEM. CONSTANT GAS SMELL, AND FUEL GAUGE ALWAYS JUMPING UP AND DOWN AGAIN REGARDLESS OF MOTION. CHECK ENGINE LIGHTS INDICATE FAULTY COOLANT TEMPERATURE SENSOR, AND FAULTY FUEL LEVEL SENSOR. DEALERSHIP IS REFUSING TO COVER TANK ASSEMBLY…
Read full complaint
REGARDLESS OF VEHICLE MOVEMENT GAS LEAK FROM FUEL TANK LOCATED UNDER BACK SEAT ABOVE EXHAUST SYSTEM. CONSTANT GAS SMELL, AND FUEL GAUGE ALWAYS JUMPING UP AND DOWN AGAIN REGARDLESS OF MOTION. CHECK ENGINE LIGHTS INDICATE FAULTY COOLANT TEMPERATURE SENSOR, AND FAULTY FUEL LEVEL SENSOR. DEALERSHIP IS REFUSING TO COVER TANK ASSEMBLY REPLACEMENT UNDER PZEV WARRANTY OF 15YRS / 150,000 MILES IN STATE OF CALIFORNIA. VEHICLE IS 2006, WITH 109K MILES. DOCUMENTATION OF TROUBLE CODES NOT AVAILABLE AT TIME OF REPORTING, BUT CAN BE PROVIDED UPON FUTURE REQUEST. FUEL RUNS DOWN THE SIDE OF THE TANK NARROWLY MISSING THE EXHAUST, POTENTIAL FIRE HAZARD.
MY 2006 MERCEDES BENZ E350 HAS A STRONG ODOR OF GASOLINE, PARTICULARLY STRONG AFTER FILLING THE TANK. MY UNDERSTANDING IS THAT THERE WAS A NHTSA INVESTIGATION INTO THIS PROBLEM IN THE PAST AND THE MANUFACTURER AGREED TO EXTEND THE WARRANTY TO REPAIR THE PROBLEM WHICH RESULTED IN NHTSA CLOSING THE PROBE. I CONTACTED MY LOCAL DE…
Read full complaint
MY 2006 MERCEDES BENZ E350 HAS A STRONG ODOR OF GASOLINE, PARTICULARLY STRONG AFTER FILLING THE TANK. MY UNDERSTANDING IS THAT THERE WAS A NHTSA INVESTIGATION INTO THIS PROBLEM IN THE PAST AND THE MANUFACTURER AGREED TO EXTEND THE WARRANTY TO REPAIR THE PROBLEM WHICH RESULTED IN NHTSA CLOSING THE PROBE. I CONTACTED MY LOCAL DEALERSHIP REGARDING THIS PROBLEM AND THEY INDICATED THAT THE WARRANTY IS NOT EXTENDED. THIS IMPLIES THAT THE MANUFACTURER IS NOT COMPLYING WITH THEIR AGREEMENT OR THE PROBE SHOULD BE REOPENED?
TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ E350. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL. THE FUEL FROM THE FUEL SENDING UNIT WAS LEAKING AND THERE WAS A POOL OF FUEL UNDERNEATH THE REAR SEAT OF THE VEHICLE, WHICH LEAKED INTO THE REAR SEATS. THE CONTACT ALSO SMELLED A FUEL ODOR THROUGHOUT THE VEHICLE AND NOTICED A DR…
Read full complaint
TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ E350. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL. THE FUEL FROM THE FUEL SENDING UNIT WAS LEAKING AND THERE WAS A POOL OF FUEL UNDERNEATH THE REAR SEAT OF THE VEHICLE, WHICH LEAKED INTO THE REAR SEATS. THE CONTACT ALSO SMELLED A FUEL ODOR THROUGHOUT THE VEHICLE AND NOTICED A DRIED FUEL FILM ON TOP OF THE VEHICLE'S ACCESS PANEL. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO MERCEDES-BENZ OF WEST COVINA (2010 E GARVEY AVE S, WEST COVINA, CA 91791, 626-859-1200). THE CONTACT INFORMED THE DEALER OF AN ARTICLE FROM NHTSA THAT STATED THEY WOULD OFFER AN EXTENDED WARRANTY (P-BQ-FUEL-3WA) TO THEIR CONSUMERS REGARDING THIS DEFECT. THE MANUFACTURER REFUSED TO COVER THE VEHICLE BECAUSE THE SPECIFIC DEFECT PART WAS NOT COVERED UNDER THE WARRANTY. THE CONTACT WAS PROVIDED A QUOTE FOR THE REPAIR OF THE DEFECTIVE PART. THE MANUFACTURER AGREED WITH THE CONTACT THAT THE DEALER SHOULD COVER THE VEHICLE UNDER THE WARRANTY; HOWEVER, THE CONTACT WAS INFORMED THAT THE LOCAL DEALER REFUSED TO HONOR THE WARRANTY AND HAD THE RIGHT TO REFUSE THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 147,647.
FUEL PUMP LEAKING FUMES (AND FUEL?). WHILE PARKED AND PREPARING TO COME HOME THE FUEL PUMP FAILED AND THE CAR REFUSED TO START. IT WILL NOT BE REPAIRED UNLESS IT IS UNDER THE EXTENDED WARRANTY. I AM TRYING TO LEARN IF IT WILL BE COVERED UNDER A EXTENDED WARRANTY.
THE CAR WOULD NOT START FUEL PUMP FAULTY AND IS PART OF GAS TANK BAD DESIGN COST ME CLOSE TO $3800, SOME PAID BY MBZ. MBZ REPLACED 2009 GAS TANKS FOR FREE UNDER WARRANTY BUT WOULD NOT DO MINE. THIS IS A BAD DESIGN THEY SHOULD HAVE TOLD ME ABOUT IT SO I WOULD NOT BUY THE CAR. IT IS STUPID TO HAVE TO REPLACE GAS TANK IN ORDER TO R…
Read full complaint
THE CAR WOULD NOT START FUEL PUMP FAULTY AND IS PART OF GAS TANK BAD DESIGN COST ME CLOSE TO $3800, SOME PAID BY MBZ. MBZ REPLACED 2009 GAS TANKS FOR FREE UNDER WARRANTY BUT WOULD NOT DO MINE. THIS IS A BAD DESIGN THEY SHOULD HAVE TOLD ME ABOUT IT SO I WOULD NOT BUY THE CAR. IT IS STUPID TO HAVE TO REPLACE GAS TANK IN ORDER TO REPLACE A FUEL PUMP IN 2012 I HAD GAS LEAKAGE FROM THE SAME AREA AND I PAID TO FIX IT THEY SHOULD HAVE TOLD ME THIS WOULD BE A PROBLEM. INSTEAD THEY KEPT SILENT WHEN I TAKE MY CAR FOR SERVICE THEY ALWAYS LIST OF THINGS TO DO SO I CAN SPEND MORE MONEY AT THE DEALERSHIP WHY THE [XXX] NO BODY BOTHERED TO TELL ME ABOUT THIS PROBLEM THAT IT WOULD COST ME A LOT OF MONEY TO FIX . THIS CAR HAS COST OVER $60,000 TO BUY AND I DID NOT PAY THAT KIND OF MONEY FOR A CAR TO LAST ME ONLY 12 YEARS. MBZS ARE SUPPOSED TO LAST 30 YEARS OR MORE SO IFEEL CHEATED BIG TIME I THINK THEY ARE HIDING THIS BECAUSE THEY WILL GET SUED BIG TIME AND I HOPE THEY DO BOTH THE DEALERSHIP AND THE MBZ COMPANY. THE DEALERSHIP IS MERCEDES BANZ OF VALENCIA IN VALENCIA, CA 91355. PHONE NUMBER 661-753-5555. I HAVE THE NECESSARY PAPERWORK. I WOULD LIKE TO BE REIMBURSED FRO ALL THE COST, THE 3 WEEKS WITHOUT A CAR AND FRO THE PAIN AND SUFFERING THEY HAVE CAUSED ME AND SO IT WILL BE A LESSON TO MBZ AND THEIR DEALERS NOT TO PRATICE THIS FRAUD. I AM AVAILABLE FOR AN INTERVIEW OR MORE INFORMATION AS NEEDED. REGARDS, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ E350. WHILE DRIVING VARIOUS SPEEDS, THE "REDUCE BRAKING POWER" WARNING MESSAGE DISPLAYED. THE CONTACT STATED THAT THE SENTRO SONIC BRAKE CONTROL UNIT FAILED. IN ADDITION, THE FUEL TANK UNDER THE DRIVER'S SEAT FRACTURED AND SPILLED FUEL IN THE VEHICLE. CENTENNIAL IMPORTS IN PENSACOLA, FLO…
Read full complaint
TL* THE CONTACT OWNS A 2006 MERCEDES-BENZ E350. WHILE DRIVING VARIOUS SPEEDS, THE "REDUCE BRAKING POWER" WARNING MESSAGE DISPLAYED. THE CONTACT STATED THAT THE SENTRO SONIC BRAKE CONTROL UNIT FAILED. IN ADDITION, THE FUEL TANK UNDER THE DRIVER'S SEAT FRACTURED AND SPILLED FUEL IN THE VEHICLE. CENTENNIAL IMPORTS IN PENSACOLA, FLORIDA WAS MADE AWARE OF THE FAILURE AND DIAGNOSED THAT THE SENTRO SONIC BRAKE CONTROL UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 104,000.
FUEL SMELL INSIDE CABIN. WAS TOLD FULLY COVERED ON EXTENDED WARRANTY DUE TO TSB NO. P-47-10-63 PARTS COVERED ARE FUEL TANK, FUEL FILTER/SENDER, FUEL PUMP, GASKET, SEALS AND RETENTION RINGS. DEALER CALLS TO SAY IT IS THE FUEL SENSOR AND IS NOT COVERED! AND COST IS 1400.00. FUEL SENSOR IS SITTING ON TOP OF THE FUEL FILTER/SENDER A…
Read full complaint
FUEL SMELL INSIDE CABIN. WAS TOLD FULLY COVERED ON EXTENDED WARRANTY DUE TO TSB NO. P-47-10-63 PARTS COVERED ARE FUEL TANK, FUEL FILTER/SENDER, FUEL PUMP, GASKET, SEALS AND RETENTION RINGS. DEALER CALLS TO SAY IT IS THE FUEL SENSOR AND IS NOT COVERED! AND COST IS 1400.00. FUEL SENSOR IS SITTING ON TOP OF THE FUEL FILTER/SENDER AND IS PLUGGED INTO IT!!! HOW CAN YOUR AGENCY ALLOW MB TO SKIRT COVERING SUCH A CLOSELY RELATED PART IN THIS SAFETY INVESTIGATION BY THE ODI????
Official recalls
424V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
21V196000 · Visibility:sun/moon Roof Assembly
Mar 19, 2021
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2007 C350, C230, C280, CLK350, E320CDI, E350 Wagon, E350, 2006 C55 AMG, CLK500, CLS500, CLS55 AMG, E500 Wagon, E500, E55 AMG, 2007 CLK550, CLS550, CLS63 AMG, E550, E63 AMG, and E63 Wagon AMG vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly causing the glass panel to detach from the vehicle.
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. Owner letters were mailed May 7, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall number 19V-918. MBUSA's number for this recall is 2021040012.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
PE10017 · Driver Air Bag Circuit High Resistance
Opened May 14, 2010 · Closed Nov 24, 2010
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System; Electrical System:wiring; Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Additional source detail variants (5)
Air Bags:frontal
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Air Bags
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring:interior/under Dash
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.
Electrical System:wiring
Mercedes-Benz USA (MBUSA) has reported a high number of warranty claims for air bag warning lamp illumination due to a diagnostic fault code 9103 or 9123 indicating a high resistance in the driver's frontal air bag firing circuit.MBUSA's testing and evaluation have shown that this condition is the result of a faulty connector (specifically, improper wire crimp) but that it will not prevent proper deployment of the driver's frontal air bag.The faulty connector can cause the air bag circuit resistance levels to exceed the threshold that illuminates the air bag warning lamp, but they do not exceed a higher limit at which proper deployment of the air bag may no longer occur.The agency believes that further expenditure of agency resources does not appear to be warranted at this time.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.During the investigation, ODI learned that MBUSA will initiate a warranty extension program to address the faulty connectors in subject model year 2005 and 2006 E-Class and other MBUSA model/model year vehicles.This action will extend the warranty coverage for this issue to 10 years or 100,000 miles, whichever occurs first.MBUSA will notify all affected vehicle owners of this action.A bulletin describing this program is available in the investigative file.