IllustrationMileage unknown · Dec 12, 2025
Visibility/wiper
sunroof
NHTSA ODI #11704778
2007 MERCEDES-BENZ Amg E63
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Amg E63 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
425–50K
1350–75K
675–100K
1100–150K
1150K+
26 reports with mileage · 3 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
29 reportssunroof
My 2007 Mercedes-Benz E63 AMG, which has developed a fuel system defect resulting in a leak. This issue poses a significant safety risk, including the potential for fire and explosion, and is directly related to a known defect that Mercedes-Benz USA has previously acknowledged through an extended warranty campaign.Safety Risk: F…
Read full complaint
My 2007 Mercedes-Benz E63 AMG, which has developed a fuel system defect resulting in a leak. This issue poses a significant safety risk, including the potential for fire and explosion, and is directly related to a known defect that Mercedes-Benz USA has previously acknowledged through an extended warranty campaign.Safety Risk: Fuel system leaks pose an imminent danger, including the potential for fire and explosion, to vehicle occupants and others on the road. Manufacturer Acknowledgment: The warranty extension campaign underscores Mercedes-Benz’s recognition of this defect as a manufacturing issue, Repeat Occurrence: Having experienced this defect in my previous 2005 E500 4MATIC and now my 2007 E63 AMG, it is evident this issue is systemic and not isolated.Ethical and Legal Responsibility: Safety defects do not have an expiration date. Mercedes-Benz has an obligation to address this issue regardless of warranty status.Mercedes-Benz USA recognized the severity of this defect by extending the warranty coverage to 15 years and unlimited mileage for “Covered Fuel Tank Components” in specific models, including the 2003–2009 E-Class (W211). I received a notice in 2015 outlining this warranty extension, which covered the fuel tank, fuel filter/sender, fuel pump, and all related gaskets, seals, and retention rings. Additionally, Mercedes-Benz USA formally notified the U.S. Department of Transportation's National Highway Traffic Safety Administration (NHTSA), specifically the Office of Defects Investigation (ODI), of this extended warranty campaign in 2014. While the ODI concluded that the nature of the leaks "does not appear to present an unreasonable risk to motor vehicle safety," I strongly disagree. Any defect involving fuel system leaks represents a substantial safety hazard, including the potential for fire, explosion, and environmental harm.
VIA REGULAR MAIL AND ONLINE SUBMISSION RE: VIN # [XXX] – Mercedes Benz 2007 E 63 Dear NHTSA – We would like to bring to your attention the failure of the Fort Lauderdale Mercedes Benz dealership to properly honor the repair and replacement of parts and labor covered under a recall for Fuel Tank Components for MODEL 211 (E-Cl…
Read full complaint
VIA REGULAR MAIL AND ONLINE SUBMISSION RE: VIN # [XXX] – Mercedes Benz 2007 E 63 Dear NHTSA – We would like to bring to your attention the failure of the Fort Lauderdale Mercedes Benz dealership to properly honor the repair and replacement of parts and labor covered under a recall for Fuel Tank Components for MODEL 211 (E-Class) years 2003-2009. A copy of the Recall notice which provided for an extension of the Recall thru 01/31/2021 is attached. Also attached please find a recent repair invoice for the respective repairs which should have been repaired under this recall. Mercedes Benz undertook a “partial” repair of the parts covered under this recall and at the time of that repair failed to properly repair all of the parts related to this issue/recall. Instead, they only replaced one fuel tank/fuel pump while the extended warranty coverage was in place and left the issue to materialize/manifest in the remaining fuel pump/tank despite the fact that conditions indicated it would likely fail in the near term at the time of the partial repair. Of further concern is the fact that an active Recall for the exact same item exists and remains active for later model years. Clearly, they have not fixed the cause of failure for this vital car part and continue to place drivers/owners at considerable risk. NHTSA – ODI It is incredulous to me, a 25+ year dedicated Mercedes Benz customer that an experienced dealership would attempt to evade responsibility for such a significant safety recall item. When this issue exists, the smell and fumes of petroleum/gas can be easily smelled from the exterior of the car. If you were to light a cigarette – you would likely cause the car to explode. When this issue existed, the interior cabin of the car would fill with petroleum/gas fumes again placing the driver at considerable risk. Please review the attached documentation and require Mercedes Benz to acknowledge that their half-hearted repair done during the recall INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO
THE PROTECTIVE LACQUER FINISH HAS FAILED CAUSING WHEEL CORROSION AND RUST FROM THE INSIDE OUT STARTING AROUND THE WHEEL HUBS. THIS CORROSION IS LIKE A METAL CANCER THAT IS STARTING TO DETERIORATE THE PROPERTIES OF THE METALS AND ALLOYS. THIS IS A HIGH PERFORMANCE VEHICLE WITH HIGH PERFORMANCE WHEELS. THIS MFG DEFECT POSES SERIOU…
Read full complaint
THE PROTECTIVE LACQUER FINISH HAS FAILED CAUSING WHEEL CORROSION AND RUST FROM THE INSIDE OUT STARTING AROUND THE WHEEL HUBS. THIS CORROSION IS LIKE A METAL CANCER THAT IS STARTING TO DETERIORATE THE PROPERTIES OF THE METALS AND ALLOYS. THIS IS A HIGH PERFORMANCE VEHICLE WITH HIGH PERFORMANCE WHEELS. THIS MFG DEFECT POSES SERIOUS SAFETY CONCERNS AND IS A PRODUCT LIABILITY THAT DAIMLER NORTH AMERICA CORPORATION DBA MERCEDES BENZ USA'S HAS KNOWN ABOUT BUT YET HAS DONE NOTHING. THIS DEFECT HAS AFFECTED SEVERAL OTHER MERCEDES BENZ VEHICLES OF THE AMG PERFORMANCE LINE. OTHER MODELS INCLUDE SLK 55 AND SLK 350 FROM 2000-2009. IN ADDITION TO RUST AND CORROSION FORMING FROM THE INSIDE OUT ON SOME WHEELS, THE BOLTS THAT HOLD THE WHEELS TO THE HUB ASSEMBLY TEND TO RUST AS WELL FURTHERING THIS SAFETY ISSUE. NOTE: VEHICLE IS USUALLY PARKED AND COVERED IN A CLIMATICALLY CONTROLLED GARAGE WHICH IS NOT EXPOSED TO THE USUAL ELEMENTS OF NATURE.
I FILLED UP THE GAS, TOOK A SHORT DRIVE HOME, AND PARKED IN THE GARAGE. NEXT DAY, THERE IS A STRONG GASOLINE SMELL IN THE GARAGE AS WELL AS INSIDE THE CAR. THIS HAPPENED WHENEVER I FILLED UP THE GAS SINCE THEN.
SEVERAL TAIL LAMPS QUIT WORKING. I HAD A WARNING ON THE CAR DISPLAY LISTING NUMEROUS LIGHTS ON THE TRUNK INOPERATIVE. THE LICENSE PLATE LAMP, 3RD BRAKE LIGHT, AND THE AUTO OPEN AND CLOSE OF THE TRUNK WERE INOPERATIVE. ALSO, THE EMERGENCY TRUNK RELEASE FUNCTION INSIDE THE TRUNK WOULD NOT LIGHT UP AND WOULD NOT OPEN THE TRUNK. …
Read full complaint
SEVERAL TAIL LAMPS QUIT WORKING. I HAD A WARNING ON THE CAR DISPLAY LISTING NUMEROUS LIGHTS ON THE TRUNK INOPERATIVE. THE LICENSE PLATE LAMP, 3RD BRAKE LIGHT, AND THE AUTO OPEN AND CLOSE OF THE TRUNK WERE INOPERATIVE. ALSO, THE EMERGENCY TRUNK RELEASE FUNCTION INSIDE THE TRUNK WOULD NOT LIGHT UP AND WOULD NOT OPEN THE TRUNK. I SEARCHED A MB WEB FORUM TO SEE IF ANYONE ELSE HAD THE SAME PROBLEM. THERE ARE NUMEROUS CARS FROM SEVERAL YEAR GROUPS THAT ARE HAVING THE SAME PROBLEM. I TRACED THE PROBLEM TO 1 BROKEN WIRE IN A WIRING BUNDLE ATTACHED TO THE LEFT HINGE OF THE TRUNK. IT APPEARS THAT THE DESIGN AND PLACEMENT OF THIS WIRING BUNDLE IS CAUSING THE WIRING BUNDLE TO FLEX AND OVER TIME, WITH THE OPENING AND CLOSING OF THE TRUNK, THE WIRES ARE BREAKING. SINCE I HAD REDUCED CAPABILITY IN BRAKE LIGHTS, I ACCOMPLISHED THE FIX MYSELF TO REPAIR THE BROKEN WIRE. THIS FIX ONLY LASTED SEVERAL MONTHS BEFORE THE SAME THING HAPPENED AGAIN. I HAVE NOW "FIXED" IT MYSELF 3 TIMES. I HAVE MY CAR AT THE MERCEDES BENZ DEALER CURRENTLY AND MENTIONED THE PROBLEM TO THEM. THEY ARE AWARE OF IT AND WANT TO CHARGE ME TO FIX IT. I FEEL THIS SHOULD BE A COVERED SERVICE BULLETIN SINCE IT IS HAPPENING TO NUMEROUS CARS NOW. THIS IS A DESIGN FLAW IN THE LOCATION AND PLACEMENT OF THIS WIRING BUNDLE AND COULD LEAD UNEXPECTEDLY LOSING SOME, IF NOT ALL, BRAKE LIGHTS. ALSO, IF SOMEONE GETS LOCKED IN THE TRUNK AND THE WIRE IS BROKEN, THEY HAVE NO WAY OF OPENING THE TRUNK. *TR
I JUST PURCHASED THE VEHICLE USED FROM A DEALERSHIP. I DROVE THE VEHICLE 2000 MILES HOME AND I PARKED THE CAR IN MY GARAGE. I FILLED THE GAS TANK PRIOR TO PARKING IN MY GARAGE. THE NEXT MORNING I ENTERED MY GARAGE AND SMELLED A STRONG ODOR OF GASOLINE. I COULD SEE GAS UNDERNEATH MY CAR BY THE REAR DRIVERS SIDE WHEEL AND THE ODOR…
Read full complaint
I JUST PURCHASED THE VEHICLE USED FROM A DEALERSHIP. I DROVE THE VEHICLE 2000 MILES HOME AND I PARKED THE CAR IN MY GARAGE. I FILLED THE GAS TANK PRIOR TO PARKING IN MY GARAGE. THE NEXT MORNING I ENTERED MY GARAGE AND SMELLED A STRONG ODOR OF GASOLINE. I COULD SEE GAS UNDERNEATH MY CAR BY THE REAR DRIVERS SIDE WHEEL AND THE ODOR OF GASOLINE WAS SO STRONG MY EYES WERE WATERING AND I COULDN'T BREATH WELL. I OPENED THE GARAGE DOOR AND MOVED THE CAR OUTSIDE(PUSHED IT OUTSIDE TO AVOID AN EXPLOSION). THE ODOR OF GASOLINE IS VERY STRONG BY THE DRIVER'S SIDE REAR COMPARTMENT. I KEEP THE FUEL TANK AT HALF FULL OR LESS TO MINIMIZE THE GASOLINE VAPOROUS SMELL. I BOUGHT THE CAR IN CHICAGO AND DROVE IT HOME TO WASHINGTON STATE. *TR
THERE IS A STRONG SMELL OF GASOLINE OVER 1/2 TANK FULL, AND FREQUENT CHECK ENGINE LIGHTS ON FOR AN EVAP SYSTEM LEAK. THIS IS A KNOWN ISSUE WITH THESE CARS, AND I AM CONCERNED TO DRIVE THE VEHICLE WITH GASOLINE FUMES COMING INSIDE THE CAR AND CREATING A FIRE HAZARD. MERCEDES KNOWS ABOUT THIS PROBLEM AND NEEDS TO ADDRESS IT. *TR
WHEN I FILL UP THE FUEL TANK TO FULL, I SMELL A STRONG SCENT OF GASOLINE INSIDE THE CAR. THE FUEL IS LEAKING SOMEWHERE UNTIL I BURN IT DOWN TO ABOUT A 3/4 TANK FULL. *TR
UPON EXITING THE FREEWAY AND COMING TO A COMPLETE STOP, VEHICLE WAS UNABLE TO ACCELERATE AS USUAL. ACCELERATION WAS VERY SLOW AND WITHOUT POWER. UPON LOOKING AT GAUGE CLUSTER, THE VEHICLE SHIFTED ITSELF INTO 5TH GEAR IT SEEMS. USING THE PADDLE SHIFTER I THEN PROCEEDED TO DOWNSHIFT THE TRANSMISSION TO 1ST GEAR TO PULL AWAY FRO…
Read full complaint
UPON EXITING THE FREEWAY AND COMING TO A COMPLETE STOP, VEHICLE WAS UNABLE TO ACCELERATE AS USUAL. ACCELERATION WAS VERY SLOW AND WITHOUT POWER. UPON LOOKING AT GAUGE CLUSTER, THE VEHICLE SHIFTED ITSELF INTO 5TH GEAR IT SEEMS. USING THE PADDLE SHIFTER I THEN PROCEEDED TO DOWNSHIFT THE TRANSMISSION TO 1ST GEAR TO PULL AWAY FROM STOP. CAR REMAINED IN AUTOMATIC MODE, BUT WAS NOT SHIFTING OUT OF GEAR. CLUSTER DISPLAYS AUTOMATIC COMFORT MODE, BUT WOULD NOT LEAVE FROM WHAT IT SEEMS 2ND GEAR. STOP ENGINE AND RESTART CAR, DRIVE AROUND AND CAR WILL NOT SHIFT OUT OF GEAR. UPON SEARCHING THE INTERNET THIS IS A VERY VERY COMMON ISSUE WITH ALL 7 SPEED AUTOMATIC TRANSMISSIONS OFFERED BY MERCEDES BENZ. THEY HAVE NOT ASSUMED RESPONSIBILITY FOR A DEFECT IN PART. MANY HAVE SPENT THOUSANDS OF DOLLARS DIAGNOSING AND REPAIRING TRANSMISSION RELATED ISSUES WHICH REVOLVE AROUND THIS SUB PAR TRANSMISSION. IF YOU SEARCH ONLINE FOR CONDUCTOR PLATE, MERCEDES YOU WILL FIND COUNTLESS PEOPLE WHO HAVE BEEN DEALING WITH TRANSMISSION FAILURE'S DUE TO THIS FAULTY PART. THIS ISSUE AFFECTS ALL MERCEDES 7 SPEED TRANSMISSIONS AND AS SEEN THROUGH ONLINE SEARCH IS A WORLD WIDE ISSUE. I HAVE READ ABOUT THIS IN THE UK, AUSTRALIA, SOUTH AMERICA, AS WELL AS IN THE USA. *TR
Official recalls
424V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
21V196000 · Visibility:sun/moon Roof Assembly
Mar 19, 2021
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2007 C350, C230, C280, CLK350, E320CDI, E350 Wagon, E350, 2006 C55 AMG, CLK500, CLS500, CLS55 AMG, E500 Wagon, E500, E55 AMG, 2007 CLK550, CLS550, CLS63 AMG, E550, E63 AMG, and E63 Wagon AMG vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly causing the glass panel to detach from the vehicle.
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. Owner letters were mailed May 7, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall number 19V-918. MBUSA's number for this recall is 2021040012.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un